2007 FORD TAURUS check engine

Readiness for Inspection/Maintenance (I/M) testing
In some localities, it may be a legal requirement to pass an I/M test of
the on-board diagnostics system. If the
indicator is on, refer to the
description in theWarning lights and chimessection of the
Instrument Clusterchapter. Your vehicle may not pass the I/M test with
the
indicator on.
If the vehicle’s powertrain system or its battery has just been serviced,
the on-board diagnostics system is reset to a “not ready for I/M test”
condition. To ready the on-board diagnostics system for I/M testing, a
minimum of 30 minutes of city and highway driving is necessary as
described below:
•First, at least 10 minutes of driving on an expressway or highway.
•Next, at least 20 minutes driving in stop-and-go, city-type traffic with
at least four idle periods.
Allow the vehicle to sit for at least eight hours without starting the
engine. Then, start the engine and complete the above driving cycle. The
engine must warm up to its normal operating temperature. Once started,
do not turn off the engine until the above driving cycle is complete.
POWER STEERING FLUID
Check the power steering fluid.
Refer to thescheduled
maintenance informationfor the
service interval schedules. If adding
fluid is necessary, use only
MERCONAT F.
1. Start the engine and let it run
until it reaches normal operating
temperature (the engine coolant
temperature gauge indicator will be near the center of the normal area
between H and C).
2. While the engine idles, turn the steering wheel left and right several
times.
3. Turn the engine off.
2007 Taurus(tau)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
215

1. Drive the vehicle 20 miles (30 km) or until it reaches normal operating
temperature.
2. Park the vehicle on a level surface and engage the parking brake.
3. With the parking brake engaged and your foot on the brake pedal,
start the engine and move the gearshift lever through all of the gear
ranges. Allow sufficient time for each gear to engage.
4. Latch the gearshift lever in P (Park) and leave the engine running.
5. Remove the dipstick, wiping it clean with a clean, dry lint free rag. If
necessary, refer toIdentifying components in the engine compartment
in this chapter for the location of the dipstick.
6. Install the dipstick making sure it is fully seated in the filler tube.
7. Remove the dipstick and inspect the fluid level. The fluid should be in
the designated areas for normal operating temperature.
Low fluid level
Do not drive the vehicle if the fluid
level is at the bottom of the dipstick
and the outside temperatures are
above 50°F (10°C).
Correct fluid level
The transmission fluid should be checked at normal operating
temperatures 150°F-170°F (66°C-77°C) on a level surface. The normal
operating temperature can be reached after approximately 20 miles (30
km) of driving.
The transmission fluid should be in
this range if at normal operating
temperature (150°F-170°F
[66°C-77°C]).
High fluid level
Fluid levels above the safe range
may result in transaxle failure. An
overfill condition of transmission
fluid may cause shift and/or
engagement concerns and/or possible damage.
High fluid levels can be caused by an overheating condition.
DON’T ADD IF IN CROSSHATCH AREA--CHECH WHEN HOT-IDLING
DON’T ADD IF IN CROSSHATCH AREA--CHECH WHEN HOT-IDLING
DON’T ADD IF IN CROSSHATCH AREA--CHECH WHEN HOT-IDLING
2007 Taurus(tau)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
217

Items CapacityFord Part Name or
equivalentFord Part Number /
Ford Specification
Power steering fluidFill to line on
dipstickMotorcraft MERCON
AT FXT-2-QDX /
MERCON
Windshield washer fluid 94.7 oz (2.8L)Motorcraft Premium
Windshield Washer
ConcentrateZC-32-A /
WSB-M8B16-A2
1Ensure the correct automatic transmission fluid is used. Transmission fluid requirements are
indicated on the dipstick or on the dipstick handle. Check the container to verify the fluid being
added is of the correct type. Refer toscheduled maintenance informationto determine the
correct service interval.
Some transmission fluids may be labeled as dual usage, such as MERCONand MERCONV.
These dual usage fluids are not to be used in an automatic transmission that requires use of the
MERCONtype fluid. However, these dual usage fluids may be used in transmissions that require
the MERCONV type fluid.
MERCONand MERCONV type fluids are not interchangeable. DO NOT mix MERCON
and MERCONV. Use of a transmission fluid that indicates dual usage (MERCONand
MERCONV) in an automatic transmission application requiring MERCONmay cause
transmission damage. Use of any fluid other than the recommended fluid may cause
transmission damage.2Use of synthetic or synthetic blend motor oil is not mandatory. Engine oil need only meet the
requirements of Ford specification WSS-M2C930-A and the API Certification mark.3Add the coolant type originally equipped in your vehicle.
2007 Taurus(tau)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
221

The Vehicle Identification Number (VIN) contains the following
information:
1. World manufacturer identifier
2. Brake system / Gross Vehicle
Weight Rating (GVWR) / Restraint
System
3. Vehicle line, series, body type
4. Engine type
5. Check digit
6. Model year
7. Assembly plant
8. Production sequence number
TRANSMISSION/TRANSAXLE CODE DESIGNATIONS
You can find a
transmission/transaxle code on the
Safety Compliance Certification
Label. The following table tells you
which transmission or transaxle
each code represents.
Description Code
Automatic overdrive N
2007 Taurus(tau)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
224

A
Accessory delay ..........................44
Air cleaner filter .......................218
Air conditioning ..........................25
Airbag supplemental restraint
system ............................97–98, 106
and child safety seats ..............99
description ........................98, 106
disposal ....................................107
driver airbag ..............98, 100, 106
indicator light .........................105
operation ...................98, 100, 106
passenger airbag .......98, 100, 106
side airbag ...............................106
Antifreeze
(see Engine coolant) ................200
Anti-lock brake system
(see Brakes) ..............................149
Anti-theft system ..................72, 75
arming the system ....................75
disarming a triggered system ..76
triggering ...................................76
Audio system (see Radio) ...15, 18
Automatic transaxle
fluid, adding ............................216
fluid, checking ........................216
fluid, refill capacities ..............220
fluid, specification ..................220
Automatic transmission
driving an automatic
overdrive .................................154
Auxiliary power point .................42
B
Battery .......................................198
acid, treating emergencies .....198
jumping a disabled battery ....172maintenance-free ....................198
replacement, specifications ...218
servicing ..................................198
BeltMinder ...................................92
Brakes ........................................148
anti-lock ...................................149
anti-lock brake system (ABS)
warning light ...........................149
fluid, checking and adding ....216
fluid, refill capacities ..............220
fluid, specifications .................220
lubricant specifications ..........220
parking ....................................150
shift interlock ..........................152
Bulbs ............................................34
C
Capacities for refilling fluids ....220
CD changer .................................20
CD-single premium ...............15, 18
Cell phone use ..............................7
Changing a tire .........................166
Child safety restraints ..............108
child safety belts ....................108
Child safety seats ......................112
attaching with tether straps ..116
in front seat ............................113
in rear seat ......................113, 116
Cleaning your vehicle
engine compartment ..............186
instrument panel ....................188
interior .....................................188
interior trim ............................188
plastic parts ............................187
washing ....................................185
waxing .....................................185
wheels ......................................186
wiper blades ............................187
2007 Taurus(tau)
Owners Guide (post-2002-fmt)
USA(fus)
Index
227

Climate control (see Air
conditioning or Heating) ............25
Clock adjust
AM/FM/Cassette ........................15
AM/FM/CD .................................18
Compass
zone/calibration adjustment ....56
Compass Display .........................55
Console ........................................42
Controls
power seat .................................79
Coolant
checking and adding ..............200
refill capacities ................204, 220
specifications ..........................220
Cruise control
(see Speed control) ....................45
Customer Assistance ................157
Ford Extended Service
Plan ..........................................182
Getting assistance outside the
U.S. and Canada .....................183
Getting roadside assistance ...157
Getting the service you need 178
Ordering additional owner’s
literature .................................184
Utilizing the
Mediation/Arbitration
Program ...................................181
D
Daytime running lamps
(see Lamps) ................................30
Defrost
rear window ..............................27
Dipstick
automatic transmission
fluid ..........................................216engine oil .................................195
Driving under special
conditions ..................................156
through water .........................156
E
Electronic message center .........53
Emergencies, roadside
jump-starting ..........................172
Emergency Flashers .................159
Emission control system ..........213
Engine ........................................222
cleaning ...................................186
coolant .....................................200
idle speed control ...................198
lubrication specifications .......220
refill capacities ........................220
service points ..........................193
starting after a collision .........159
Engine block heater .................148
Engine oil ..................................195
checking and adding ..............195
dipstick ....................................195
filter, specifications ........197, 218
recommendations ...................197
refill capacities ........................220
specifications ..........................220
Exhaust fumes ..........................147
F
Floor mats ...................................62
Fluid capacities .........................220
Fuel ............................................205
calculating fuel
economy ............................54, 210
cap ...........................................207
capacity ...................................220
2007 Taurus(tau)
Owners Guide (post-2002-fmt)
USA(fus)
Index
228

headlamps, flash to pass ..........30
instrument panel, dimming .....30
interior lamps ...............32–33, 35
replacing bulbs .........................35
Lane change indicator
(see Turn signal) ........................32
Lights, warning and indicator ....10
anti-lock brakes (ABS) ..........149
Load limits .................................134
Locks
childproof ..................................64
doors ..........................................63
Lubricant specifications ...........220
Lug nuts ....................................171
Lumbar support, seats ...............78
M
Message center ...........................53
english/metric button ...............58
system check button ................58
warning messages .....................59
Mirrors .........................................45
automatic dimming rearview
mirror ........................................44
heated ........................................45
side view mirrors (power) .......45
Moon roof ....................................48
Motorcraft parts ........190, 209, 218
O
Octane rating ............................208
Oil (see Engine oil) ..................195
Overdrive ...................................153
P
Parking brake ............................150Parts (see Motorcraft parts) ....218
Passenger Occupant
Classification Sensor ...................83
Power distribution box
(see Fuses) ...............................164
Power door locks ........................63
Power mirrors .............................45
Power point .................................42
Power steering ..........................151
fluid, checking and adding ....215
fluid, refill capacity ................220
fluid, specifications .................220
Power Windows ...........................43
R
Radio ......................................15, 18
Rear window defroster ...............27
Relays ................................160, 166
Remote entry system .................66
illuminated entry ......................69
locking/unlocking doors .....66–67
opening the trunk .....................67
panic alarm ...............................67
replacing the batteries .............67
Roadside assistance ..................157
S
Safety Belt Maintenance ............91
Safety belts (see Safety
restraints) ........................81, 85–89
Safety defects, reporting ..........184
Safety restraints ..............81, 85–89
belt minder ...............................92
extension assembly ..................90
for adults .............................86–88
2007 Taurus(tau)
Owners Guide (post-2002-fmt)
USA(fus)
Index
230