POWER STEERING FLUID
•2.3L I4 engine
•3.0L V6 engine
•4.0L V6 engine
Check the power steering fluid. Refer to the scheduled maintenance
guide for the service interval schedules. If adding fluid is necessary, use
only MERCONAT F.
DONOTOVERFILLPOWERSTEERINGFLUID
2007 Ranger(ran)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
251
1. Start the engine and let it run until it reaches normal operating
temperature (the engine coolant temperature gauge indicator will be
near the center of the normal area between H and C).
2. While the engine idles, turn the steering wheel left and right several
times.
3. Turn the engine off.
4. Check the fluid level in the reservoir. It should be between the MIN
and MAX lines. Do not add fluid if the level is within this range.
5. If the fluid is low, add fluid in small amounts, continuously checking
the level until it reaches the FULL HOT range. Be sure to put the
dipstick back in the reservoir.
BRAKE FLUID
The fluid level will drop slowly as
the brakes wear, and will rise when
the brake components are replaced.
Fluid levels below the “MAX” line
that do not trigger the brake system
warning lamp are within the normal
operating range, there is no need to
add fluid. If the fluid levels are outside of the normal operating range,
the performance of your brake system could be compromised, seek
service from your authorized dealer immediately.
CLUTCH FLUID (IF EQUIPPED)
Check the fluid level. Refer toscheduled maintenance informationfor
the service interval schedules.
During normal operation, the fluid level in the clutch reservoir should
remain constant. If the fluid level drops, refill the fluid level to the step
in the reservoir.
Use only a DOT 3 brake fluid designed to meet Ford specifications. Refer
toMaintenance product specifications and capacitiesin this chapter.
Carefully read cautionary information on product label. For
MEDICAL EMERGENCY INFORMATION contact a physician or
Poison Control Center immediately; on Ford-Motorcraft products call:
1-800-959-3673 (FORD). Failure to follow these instructions may result
in personal injury.
MAX
2007 Ranger(ran)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
252
1. Clean the reservoir cap before
removal to prevent dirt and water
from entering the reservoir.
2. Remove cap and rubber
diaphragm from reservoir.
3. Add fluid until the level reaches
the step in the reservoir.
4. Reinstall rubber diaphragm and
cap onto reservoir.
TRANSMISSION FLUID
Checking automatic transmission fluid
•Refer toscheduled maintenance informationfor scheduled check
and change intervals.
•Transmission does not consume fluid.
•Check fluid when transmission is not operating properly or if you see
a leak.
•Fluid level must be checked at normal operating temperature, 20 miles
(30 km) of driving.
To check and add fluid:
1. Drive the vehicle 20 miles (30 km) to reach normal operating
temperatures.
2. If driven in hot weather, city traffic, pulling a trailer, allow
transmission to cool for 30 minutes before checking.
3. Engage parking brake, start engine.
4. Put your foot on the brake pedal and move the gearshift lever slowly
through all of the gear ranges.
5. Shift to P (Park) and leave the engine running.
6. Remove the dipstick, wipe clean with a dry lint free rag.
7. Install and fully seat the dipstick into the filler tube.
8. Remove the dipstick and inspect
the fluid level. Level should be in
the cross-hatched area.
2007 Ranger(ran)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
253
The Vehicle Identification Number (VIN) contains the following
information:
1. World manufacturer identifier
2. Brake system / Gross Vehicle
Weight Rating (GVWR) / Restraint
System
3. Vehicle line, series, body type
4. Engine type
5. Check digit
6. Model year
7. Assembly plant
8. Production sequence number
TRANSMISSION/TRANSAXLE CODE DESIGNATIONS
You can find a
transmission/transaxle code on the
Safety Compliance Certification
Label. The following table tells you
which transmission or transaxle
each code represents.
Description Code
Five-speed automatic (5R44E/5R55E) D
Five-speed manual (HD) J
Five-speed manual (R1) R
2007 Ranger(ran)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
267
A
Air cleaner filter ...............256–257
Airbag supplemental
restraint system ....................97–98
and child safety seats ..............99
description ................................98
disposal ....................................102
driver airbag ......................98, 100
indicator light .........................101
operation ...........................98, 100
passenger airbag ...............98, 100
Ambulance packages ....................8
Antifreeze
(see Engine coolant) ................234
Anti-lock brake system
(see Brakes) ..............................160
Anti-theft system ........................76
Audio system (see Radio) ..19, 21,
24, 29, 32, 37, 41
Automatic transmission ............163
driving an automatic
overdrive .................................164
fluid, refill capacities ..............259
fluid, specification ..................259
Auxiliary Input Jack ...................46
Auxiliary power point .................65
Axle
lubricant specifications ..........259
refill capacities ........................259
traction lok ..............................162
B
Battery .......................................232
acid, treating emergencies .....232
jumping a disabled battery ....200
maintenance-free ....................232
replacement, specifications ...257servicing ..................................232
Bed extender ..............................70
BeltMinder.................................93
Brakes ........................................160
anti-lock ...................................160
anti-lock brake system
(ABS) warning light ...............160
fluid, checking and adding ....252
fluid, refill capacities ..............259
fluid, specifications .................259
lubricant specifications ..........259
parking ....................................161
shift interlock ..........................163
Bulbs ............................................58
C
Capacities for refilling fluids ....259
Cargo area shade ........................70
Cell phone use ..............................8
Changing a tire .........................191
Child safety restraints ..............106
child safety belts ....................106
Child safety seats ......................109
attaching with tether straps ..112
in front seat ............................110
in rear seat ..............................110
Cleaning your vehicle
engine compartment ..............215
instrument panel ....................217
interior .....................................218
plastic parts ............................216
safety belts ..............................218
washing ....................................213
waxing .....................................214
wheels ......................................214
wiper blades ............................217
2007 Ranger(ran)
Owners Guide (post-2002-fmt)
USA(fus)
Index
271
Clock adjust
AM/FM Stereo ...........................19
AM/FM stereo CD ...............21, 24
CD-MP3 ...............................38, 41
Premium AM/FM stereo
CD6/MP3 .............................29, 33
Clutch
fluid ..........................................252
operation while driving ..........166
recommended shift speeds ....167
Console ........................................65
Coolant
checking and adding ..............234
refill capacities ................238, 259
specifications ..........................259
Cruise control
(see Speed control) ....................67
Customer Assistance ................178
Ford Extended Service
Plan ..........................................210
Getting assistance outside
the U.S. and Canada ..............211
Getting roadside assistance ...178
Getting the service you
need .........................................206
Ordering additional owner’s
literature .................................211
Utilizing the Mediation/
Arbitration Program ...............209
D
Daytime running lamps
(see Lamps) ................................55
Dipstick
engine oil .................................226
Driveline universal joint and
slip yoke ....................................256
Driving under special
conditions ..................168, 171, 175sand .........................................173
snow and ice ...........................176
through water .................174, 177
E
Emergencies, roadside
jump-starting ..........................200
Emergency Flashers .................180
Emission control system ..........248
Engine ........................................264
cleaning ...................................215
coolant .....................................234
idle speed control ...................232
lubrication specifications .......259
refill capacities ........................259
service points ..................222–224
starting after a collision .........180
Engine block heater .................159
Engine oil ..................................226
checking and adding ..............226
dipstick ....................................226
filter, specifications ........230, 257
recommendations ...................230
refill capacities ........................259
specifications ..........................259
Exhaust fumes ..........................159
F
Fluid capacities .........................259
Foglamps .....................................54
Four-Wheel Drive vehicles .......168
driving off road .......................170
electronic shift ........................169
indicator light .........................169
preparing to drive your
vehicle .....................................162
Fuel ............................................239
2007 Ranger(ran)
Owners Guide (post-2002-fmt)
USA(fus)
Index
272
Lane change indicator
(see Turn signal) ........................57
Lights, warning and indicator ....12
anti-lock brakes (ABS) ..........160
Load limits .................................137
Loading instructions .................143
Locks
doors ..........................................72
Lubricant specifications ...........259
Lug nuts ....................................199
Lumbar support, seats ...............81
M
Manual transmission .................166
fluid capacities ........................259
lubricant specifications ..........259
reverse .....................................167
Mirrors .........................................67
fold away ...................................67
side view mirrors (power) .......67
Motorcraft parts ........219, 239, 257
O
Octane rating ............................244
Oil (see Engine oil) ..................226
P
Parking brake ............................161
Parts (see Motorcraft parts) ....257
Passenger Occupant
Classification Sensor ...................84
Power distribution box
(see Fuses) ...............................185
Power door locks ........................72Power mirrors .............................67
Power point .................................65
Power steering ..........................161
fluid, checking and adding ....251
fluid, refill capacity ................259
fluid, specifications .................259
Power Windows ...........................66
Preparing to drive your
vehicle ........................................162
R
Radio ........19, 21, 24, 29, 32, 37, 41
CD-MP3 ...............................38, 41
Relays ........................................181
Remote entry system ...........72–73
illuminated entry ......................75
locking/unlocking doors ...........73
panic alarm ...............................73
replacing the batteries .............73
Roadside assistance ..................178
S
Safety Belt Maintenance ............91
Safety belts (see
Safety restraints) ............82, 86–90
Safety defects, reporting ..........212
Safety restraints ..............82, 86–90
BeltMinder..............................93
extension assembly ..................91
for adults .............................87–89
for children .....................105–106
lap belt ......................................87
Occupant Classification
Sensor ........................................84
safety belt maintenance ...........91
warning light and chime ..........92
Safety seats for children ..........109
2007 Ranger(ran)
Owners Guide (post-2002-fmt)
USA(fus)
Index
274