2007 FORD FUSION (AMERICAS) oil change

Maintenance and Specifications 227
Engine compartment 229
Engine oil 232
Battery 237
Engine coolant 239
Fuel information 245
Air filter(s) 262
Part numbers 264
Maintenance product specifications and capacities 266
Engine data 269
Accessories 272
Index 274
All rights reserved. Reproduction by any means, electronic or mechanical
including photocopying, recording or by any information storage and retrieval
system or translation in whole or part is not permitted without written
authorization from Ford Motor Company. Ford may change the contents without
notice and without incurring obligation.
Copyright © 2006 Ford Motor Company
Table of Contents
3
2007 Fusion(fsn)
Owners Guide (post-2002-fmt)
USA(fus)

Handle a halogen headlamp bulb carefully and keep out of
children’s reach. Grasp the bulb only by its plastic base and do
not touch the glass. The oil from your hand could cause the bulb to
break the next time the headlamps are operated.
12. After the new bulb is installed, carefully let the bulb socket dangle
downward near the lamp housing (Passenger side only with ABS).
13. From the exterior wheel well area reach arm through splash shield
opening to install bulb socket with new bulb (Passenger side only with
ABS).
14. Install the new bulb socket into the lamp assembly by aligning the
indexing fingers, then rotate clockwise to locked position.
15. Install the protective cap/grill to the housing circular ring by pushing
and pressing it forward.
16. Re-apply pressure around the complete circular ring on the housing
to make sure the protective cap is completely seated.
17. Reinstall splash shield access panel with screw (Passenger side only
with ABS).
18. Reinstall the AirTube to the air filter assembly. (Driver’s side only).
19. Reinstall the vertical shield to the bolster. (Driver’s side only).
20. Turn the headlamps on and make sure they work properly. If the
headlamp was correctly aligned before you changed the bulb, you should
not need to align it again.
Replacing front parking lamp/turn signal bulbs
1. Make sure headlamp switch is in the OFF position, then open the
hood.
2. Reach over the front bolster.
2007 Fusion(fsn)
Owners Guide (post-2002-fmt)
USA(fus)
Lights
58

3. OIL PRESSURE
4. BRAKE FLUID LEVEL
5. EXTERIOR LAMPS
6. FUEL LEVEL
7. DISTANCE TO EMPTY
Units (English/Metric)
1. Select this function from the
SETUP menu for the current units
to be displayed.
2. Press the RESET control to
change from English to Metric.
Language
1. Select this function from the
SETUP menu for the current
language to be displayed.
2. Pressing the RESET control
cycles the message center through
each of the language choices.
3. Press and hold the RESET
control to set the language choice.
System warnings
System warnings alert you to possible problems or malfunctions in your
vehicle’s operating systems.
In the event of a multiple warning situation, the message center will
cycle the display to show all warnings by displaying each one for several
seconds.
The message center will display the last selected feature if there are no
more warning messages. This allows you to use the full functionality of
the message center after you acknowledge the warning by pressing the
RESET control and clearing the warning message.
2007 Fusion(fsn)
Owners Guide (post-2002-fmt)
USA(fus)
Driver Controls
80

5. Fully install the engine oil filler cap by turning the filler cap clockwise
until it stops.
To avoid possible oil loss, DO NOT operate the vehicle with the
engine oil level indicator and/or the engine oil filler cap removed.
Engine oil and filter recommendations
Look for this certification
trademark.
Use SAE 5W-20 engine oil
Only use oils “Certified For Gasoline Engines” by the American
Petroleum Institute (API). An oil with this trademark symbol conforms
to the current engine and emission system protection standards and fuel
economy requirements of the International Lubricant Standardization and
Approval Committee (ILSAC), comprised of U.S. and Japanese
automobile manufacturers.
To protect your engine’s warranty use Motorcraft SAE 5W-20 or an
equivalent SAE 5W-20 oil meeting Ford specification WSS-M2C930-A.
SAE 5W-20 oil provides optimum fuel economy and durability
performance meeting all requirements for your vehicle’s engine.
Do not use supplemental engine oil additives, cleaners or other engine
treatments. They are unnecessary and could lead to engine damage that
is not covered by Ford warranty.
Change your engine oil and filter according to the appropriate schedule
listed inscheduled maintenance information.
When changing the oil filter on the 2.3L engine you must also replace
the filter cap O-ring. The oil filter drain plug O-ring must also be
replaced whenever the oil filter drain plug is removed. Reuse of the
O-rings may cause engine oil leakage and may result in severe engine
damage. The customer warranty may be void for any damage to the
engine if the O-rings are not replaced.
Ford production and aftermarket (Motorcraft) oil filters are designed for
added engine protection and long life. If a replacement oil filter is used
2007 Fusion(fsn)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
236

Item Capacity Ford part nameFord part number /
Ford specification
Power Transfer Unit
(PTU) fluid (AWD)
5
12 ounces
(0.35L)Motorcraft SAE 75W-140
Synthetic Rear Axle
LubricantXY-75W140-QL /
WSL-M2C192-A
Windshield washer fluid4.75 quarts
(4.5L)Motorcraft Premium
Windshield Washer
ConcentrateZC-32-A /
WSB-M8B16-A2
Fuel tank17.5 gallons
(66.2L)——
1Add the coolant type originally equipped in your vehicle.2Use of synthetic or synthetic blend motor oil is not mandatory. Engine oil need only meet the
requirements of Ford specification WSS-M2C930-A and the API Certification mark.3Service refill capacity is determined by filling the transmission within 3/8 inch (10mm) of the
bottom of the filler hole with the vehicle on a level surface.4Indicates only approximate dry-fill capacity. Some applications may vary based on cooler size and
if equipped with an in-tank cooler. The amount of transmission fluid and fluid level should be set
by the indication on the dipstick’s normal operating range.5The Power Transfer Unit is lubricated for life with synthetic lube. Lubricant levels are not to be
checked or changed unless a leak is suspected or repair required. Replace Power Transfer Unit
lubricant with specified synthetic lubricant anytime the unit is submerged in water.
See your authorized dealer for fluid level checking or filling of the Power Transfer Unit.
2007 Fusion(fsn)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
268

Engine oil ..................................232
change oil soon warning,
message center .......................232
checking and adding ..............232
dipstick ....................................232
filter, specifications ........236, 264
recommendations ...................236
refill capacities ........................266
specifications ..........................266
Exhaust fumes ..........................173
F
Fail safe cooling ........................244
Fluid capacities .........................266
Foglamps .....................................50
Four-Wheel Drive vehicles
driving off road .......................184
Fuel ............................................245
calculating fuel
economy ............................76, 250
cap ...........................................247
capacity ...................................266
choosing the right fuel ...........248
comparisons with EPA
fuel economy estimates .........253
detergent in fuel .....................249
filling your vehicle
with fuel ..................245, 247, 250
filter, specifications ........245, 264
fuel pump shut-off switch .....192
improving fuel economy ........250
octane rating ...................249, 269
quality ......................................249
running out of fuel .................249
safety information relating
to automotive fuels ................245
Fuel pump shut-off switch .......192
Fuses ..................................192–193G
Gas cap (see Fuel cap) ............247
Gas mileage
(see Fuel economy) .................250
Gauges .........................................14
H
Hazard flashers .........................191
Head restraints .........................101
Headlamps ...................................49
aiming ..................................51–52
autolamp system .......................49
bulb specifications ....................54
daytime running lights .............50
flash to pass ..............................51
high beam .................................51
replacing bulbs .........................54
turning on and off ....................49
Heating
heating and air conditioning
system ...........................41, 43, 45
Hood ..........................................228
How to get going ........................17
I
Ignition ...............................170, 269
Illuminated visor mirror .............64
Infant seats
(see Safety seats) .....................140
Inspection/maintenance (I/M)
testing ........................................255
Instrument panel ........................66
cleaning ...................................223
cluster ........................................10
lighting up panel and
interior .......................................51
2007 Fusion(fsn)
Owners Guide (post-2002-fmt)
USA(fus)
Index
276

J
Jack ............................................199
positioning ...............................199
storage .....................................199
Jump-starting your vehicle ......205
K
Keyless entry system
autolock .....................................86
Keys .......................................83, 97
positions of the ignition .........170
L
Lamps
autolamp system .......................49
bulb replacement
specifications chart ..................54
daytime running light ...............50
fog lamps ...................................50
headlamps .................................49
headlamps, flash to pass ..........51
instrument panel, dimming .....51
interior lamps ...........................53
replacing bulbs .........................54
Lane change indicator
(see Turn signal) ........................53
Lights, warning and indicator ....10
anti-lock brakes (ABS) ..........174
Load limits .................................163
Locks
autolock .....................................86
childproof ..................................89
doors ..........................................85
Lubricant specifications ...........266
Lug nuts ....................................204
Lumbar support, seats .............102M
Manual transmission .................182
fluid capacities ........................266
lubricant specifications ..........266
reverse .....................................183
Message center ...........................75
english/metric button ...............80
system check button ................79
warning messages .....................80
Mirrors .........................................69
automatic dimming rearview
mirror ........................................68
heated ........................................69
side view mirrors (power) .......69
Moon roof ....................................73
Motorcraft parts ........225, 245, 264
N
Navigation system .......................40
O
Octane rating ............................249
Oil (see Engine oil) ..................232
P
Parking brake ............................175
Parts (see Motorcraft parts) ....264
Passenger Occupant
Classification Sensor .................108
Power distribution box
(see Fuses) ...............................196
Power door locks ........................85
Power mirrors .............................69
Power point .................................66
2007 Fusion(fsn)
Owners Guide (post-2002-fmt)
USA(fus)
Index
277