2007 FORD FUSION (AMERICAS) checking oil

Poor wiper quality can be improved by cleaning the wiper blades and the
windshield, refer toWindows and wiper bladesin theCleaning
chapter.
To prolong the life of the wiper blades, it is highly recommended to
scrape off the ice on the windshield before turning on the wipers. The
layer of ice has many sharp edges and can damage the micro edge of the
wiper rubber element.
ENGINE OIL
Checking the engine oil
Refer to thescheduled maintenance informationfor the appropriate
intervals for checking the engine oil.
1. Make sure the vehicle is on level ground.
2. Turn the engine off and wait a few minutes for the oil to drain into the
oil pan.
3. Set the parking brake and ensure the gearshift is securely latched in
P (Park) (automatic transmissions) or 1 (First) (manual transmissions).
4. Open the hood. Protect yourself from engine heat.
5. Locate and carefully remove the engine oil level indicator (dipstick).
•2.3L I4 engine
2007 Fusion(fsn)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
232

•2.3L I4 engine
•3.0L DOHC V6 Duratec engine
•Do not overfill the engine with oil. Oil levels above this mark
may cause engine damage.If the engine is overfilled, some oil must be
removed from the engine by an authorized dealer.
7. Put the indicator back in and ensure it is fully seated.
On 2.3L I4 engine, be sure the
notch in the indicator flange is
aligned with the V on the engine
when it is reinserted.
Adding engine oil
1. Check the engine oil. For instructions, refer toChecking the engine
oilin this chapter.
2. If the engine oil level is not within the normal operating range, add
only certified engine oil of the recommended viscosity. Remove the
engine oil filler cap and use a funnel to pour the engine oil into the
opening.
3. Recheck the engine oil level. Make sure the oil level is not above the
normal operating range on the engine oil level indicator (dipstick).
4. Install the indicator and ensure it is fully seated.
2007 Fusion(fsn)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
235

•Always dispose of automotive
batteries in a responsible manner.
Follow your local authorized
standards for disposal. Call your
local authorized recycling center
to find out more about recycling
automotive batteries.
ENGINE COOLANT
Checking engine coolant
The concentration and level of engine coolant should be checked at the
intervals listed inscheduled maintenance information.The coolant
concentration should be maintained at 50/50 coolant and distilled water,
which equates to a freeze point of -34°F (-36°C). Coolant concentration
testing is possible with a hydrometer or antifreeze tester (such as the
Rotunda Battery and Antifreeze Tester, 014–R1060). The level of coolant
should be maintained at the “FULL COLD” level or within the “COLD
FILL RANGE” in the coolant reservoir. If the level falls below, add
coolant per the instructions in theAdding engine coolantsection.
Your vehicle was factory-filled with a 50/50 engine coolant and water
concentration. If the concentration of coolant falls below 40% or above
60%, the engine parts could become damaged or not work properly.A
50–50 mixture of coolant and water provides the following:
•Freeze protection down to -34°F (-36°C).
•Boiling protection up to 265°F (129°C).
•Protection against rust and other forms of corrosion.
•Enables calibrated gauges to work properly.
LEAD
RETURN
RECYCLE
2007 Fusion(fsn)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
239

Item Capacity Ford part nameFord part number /
Ford specification
Power Transfer Unit
(PTU) fluid (AWD)
5
12 ounces
(0.35L)Motorcraft SAE 75W-140
Synthetic Rear Axle
LubricantXY-75W140-QL /
WSL-M2C192-A
Windshield washer fluid4.75 quarts
(4.5L)Motorcraft Premium
Windshield Washer
ConcentrateZC-32-A /
WSB-M8B16-A2
Fuel tank17.5 gallons
(66.2L)——
1Add the coolant type originally equipped in your vehicle.2Use of synthetic or synthetic blend motor oil is not mandatory. Engine oil need only meet the
requirements of Ford specification WSS-M2C930-A and the API Certification mark.3Service refill capacity is determined by filling the transmission within 3/8 inch (10mm) of the
bottom of the filler hole with the vehicle on a level surface.4Indicates only approximate dry-fill capacity. Some applications may vary based on cooler size and
if equipped with an in-tank cooler. The amount of transmission fluid and fluid level should be set
by the indication on the dipstick’s normal operating range.5The Power Transfer Unit is lubricated for life with synthetic lube. Lubricant levels are not to be
checked or changed unless a leak is suspected or repair required. Replace Power Transfer Unit
lubricant with specified synthetic lubricant anytime the unit is submerged in water.
See your authorized dealer for fluid level checking or filling of the Power Transfer Unit.
2007 Fusion(fsn)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
268

Cleaning your vehicle
engine compartment ..............221
instrument panel ....................223
interior .....................................224
interior trim ............................224
plastic parts ............................222
washing ....................................219
waxing .....................................220
wheels ......................................220
wiper blades ............................222
Climate control (see Air
conditioning or Heating) ......43, 45
Clock ............................................66
Clock adjust
6-CD in dash .............................28
AM/FM/CD .................................22
Clutch
fluid ..........................................257
operation while driving ..........182
recommended shift speeds ....182
Compass, electronic
set zone adjustment .................77
Console ........................................65
overhead ....................................65
Controls
power seat ...............................104
steering column ........................72
Coolant
checking and adding ..............239
refill capacities ................243, 266
specifications ..........................266
Cruise control
(see Speed control) ....................69
Cupholder(s) .............................107
Customer Assistance ................190
Ford Extended Service
Plan ..........................................215Getting assistance outside
the U.S. and Canada ..............216
Getting roadside assistance ...190
Getting the service
you need .................................211
Ordering additional
owner’s literature ...................217
Utilizing the Mediation/
Arbitration Program ...............215
D
Daytime running lamps
(see Lamps) ................................50
Dipstick
automatic transmission
fluid ..................................257, 259
engine oil .................................232
Driving under special
conditions ..................181, 185, 187
sand .........................................186
snow and ice ...........................188
through water .................186, 189
E
Electronic message center .........75
Emergencies, roadside
jump-starting ..........................205
Emission control system ..........253
Engine ........................................269
cleaning ...................................221
coolant .....................................239
fail-safe cooling .......................244
idle speed control ...................237
lubrication specifications .......266
refill capacities ........................266
service points ..................229–230
starting after a collision .........192
Engine block heater .................173
2007 Fusion(fsn)
Owners Guide (post-2002-fmt)
USA(fus)
Index
275

Engine oil ..................................232
change oil soon warning,
message center .......................232
checking and adding ..............232
dipstick ....................................232
filter, specifications ........236, 264
recommendations ...................236
refill capacities ........................266
specifications ..........................266
Exhaust fumes ..........................173
F
Fail safe cooling ........................244
Fluid capacities .........................266
Foglamps .....................................50
Four-Wheel Drive vehicles
driving off road .......................184
Fuel ............................................245
calculating fuel
economy ............................76, 250
cap ...........................................247
capacity ...................................266
choosing the right fuel ...........248
comparisons with EPA
fuel economy estimates .........253
detergent in fuel .....................249
filling your vehicle
with fuel ..................245, 247, 250
filter, specifications ........245, 264
fuel pump shut-off switch .....192
improving fuel economy ........250
octane rating ...................249, 269
quality ......................................249
running out of fuel .................249
safety information relating
to automotive fuels ................245
Fuel pump shut-off switch .......192
Fuses ..................................192–193G
Gas cap (see Fuel cap) ............247
Gas mileage
(see Fuel economy) .................250
Gauges .........................................14
H
Hazard flashers .........................191
Head restraints .........................101
Headlamps ...................................49
aiming ..................................51–52
autolamp system .......................49
bulb specifications ....................54
daytime running lights .............50
flash to pass ..............................51
high beam .................................51
replacing bulbs .........................54
turning on and off ....................49
Heating
heating and air conditioning
system ...........................41, 43, 45
Hood ..........................................228
How to get going ........................17
I
Ignition ...............................170, 269
Illuminated visor mirror .............64
Infant seats
(see Safety seats) .....................140
Inspection/maintenance (I/M)
testing ........................................255
Instrument panel ........................66
cleaning ...................................223
cluster ........................................10
lighting up panel and
interior .......................................51
2007 Fusion(fsn)
Owners Guide (post-2002-fmt)
USA(fus)
Index
276