2007 FORD FUSION (AMERICAS) brake fluid

1. Start the engine and let it run until it reaches normal operating
temperature (the engine coolant temperature gauge indicator will be
near the center of the normal area between H and C).
2. While the engine idles, turn the steering wheel left and right several
times.
3. Turn the engine off.
4. Check the fluid level in the reservoir. It should be between the
MIN/MAX or upper and lower lines. Do not add fluid if the level is in this
range.
5. If the fluid is low, add fluid in small amounts, continuously checking
the level until it reaches the range between the MIN/MAX or upper and
lower lines. Be sure to put the cap back on the reservoir.
BRAKE/CLUTCH FLUID
Brake and clutch systems are supplied from the same reservoir.
The fluid level will drop slowly as
the brakes wear, and will rise when
the brake components are replaced.
Fluid levels between the “MIN” and
“MAX” lines are within the normal
operating range; there is no need to
add fluid. If the fluid levels are
outside of the normal operating
range the performance of the
system could be compromised; seek
service from your authorized dealer
immediately.
TRANSAXLE FLUID
Checking 5–speed automatic transaxle fluid (If equipped)
Refer to yourscheduled maintenance informationfor scheduled
intervals for fluid checks and changes. Your transaxle does not consume
fluid. However, the fluid level should be checked if the transaxle is not
working properly, i.e., if the transaxle slips or shifts slowly or if you
notice some sign of fluid leakage.
Automatic transmission fluid expands when warmed. To obtain an
accurate fluid check, drive the vehicle until it is warmed up
(approximately 20 miles [30 km]). If your vehicle has been
MAX
MIN
2007 Fusion(fsn)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
257

operated for an extended period at high speeds, in city traffic
during hot weather or pulling a trailer, the vehicle should be
turned off for about 30 minutes to allow fluid to cool before
checking.
1. Drive the vehicle 20 miles (30 km) or until it reaches normal operating
temperature.
2. Park the vehicle on a level surface and engage the parking brake.
3. With the parking brake engaged and your foot on the brake pedal,
start the engine and move the gearshift lever through all of the gear
ranges. Allow sufficient time for each gear to engage.
4. Latch the gearshift lever in P (Park) and leave the engine running.
5. Remove the dipstick, wiping it clean with a clean, dry lint free rag. If
necessary, refer toIdentifying components in the engine compartment
in this chapter for the location of the dipstick.
6. Install the dipstick making sure it is fully seated in the filler tube.
7. Remove the dipstick and inspect the fluid level. The fluid should be in
the designated areas for normal operating temperature.
Low fluid level
Do not drive the vehicle if the fluid
level is below the lower notch on
the dipstick and the outside
temperatures are above 50°F
(10°C).
Correct fluid level
The transmission fluid should be checked at normal operating
temperature 149°F (65°C) on a level surface. The normal operating
temperature can be reached after approximately 20 miles (30 km) of
driving.
The transmission fluid should be in
between the notches if at normal
operating temperature 149°F
(65°C).
2007 Fusion(fsn)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
258

Checking automatic transmission fluid at normal operating
temperature (140°F-158°F [60°C-70°C])
Automatic transmission fluid expands when warmed. To obtain an
accurate fluid check, drive the vehicle until it is warmed up
(approximately 20 miles [30 km]) until the engine coolant gauge
indicates normal operating temperature. If your vehicle has been
operated for an extended period at high speeds, in city traffic
during hot weather or pulling a trailer, the vehicle should be
turned off for about 30 minutes to allow fluid to cool before
checking.
1. Drive the vehicle 20 miles (30 km) or until the coolant guage indicates
normal operating temperature.
2. Park the vehicle on a level surface and engage the parking brake.
3. With the parking brake engaged and your foot on the brake pedal,
start the engine and move the gearshift lever through all of the gear
ranges. Allow sufficient time for each gear to engage (approximately
10–15 seconds in each position).
4. Move the gearshift lever to P (Park) and leave the engine running.
5. Remove the dipstick, wiping it clean with a clean, dry, lint-free rag. If
necessary, refer toIdentifying components in the engine compartment
in this chapter for the location of the dipstick.
6. Install the dipstick making sure it is fully seated in the filler tube.
7. Remove the dipstick and inspect
the fluid level. The fluid should read
within the hot range on the dipstick
if at normal operating temperature
(140°F-158°F [60°C-70°C]).
Checking automatic transmission fluid at cool temperature
(59°F-77°F [15°C-25°C])
If a fluid check is necessary at a low
fluid temperature (59°F-77°F
[15°C-25°C]), perform the check
using the cold range on the dipstick.
However, the fluid must be
re-checked at the proper fluid temperature.
2007 Fusion(fsn)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
260

Checking and adding manual transmission fluid (if equipped)
1. Park the vehicle on a level
surface.
2. Engage the parking brake fully –
put in first gear.
3. Ensure the vehicle cannot move.
4. Clean the filler plug.
5. Remove the filler plug and
inspect the fluid level.
6. Fluid level should be at bottom of
the opening.
7. Add enough fluid through the filler opening so that the fluid level is
within 3/8 inch (10mm) of the bottom of the filler hole with the vehicle
on a level surface.
8. Install and tighten the fill plug securely.
Use only fluid that meets Ford specifications. Refer to theMaintenance
product specifications and capacitiessection in this chapter.
AIR FILTER
Refer toscheduled maintenance informationfor the appropriate
intervals for changing the air filter element.
When changing the air filter element, use only the Motorcraft air filter
element listed. Refer toMotorcraft part numbersin this chapter.
To reduce the risk of vehicle damage and/or personal burn
injuries do not start your engine with the air cleaner removed
and do not remove it while the engine is running.
2007 Fusion(fsn)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
262

MAINTENANCE PRODUCT SPECIFICATIONS AND CAPACITIES
Item Capacity Ford part nameFord part number /
Ford specification
Brake and clutch fluid
(if equipped)Fill between Min
and Max on
reservoirMotorcraft High
Performance DOT 3
Motor Vehicle Brake
FluidPM-1 or PM-1-C /
ESA-M6C25-A or
WSS-M6C62-A
Door weatherstrips — Silicone Spray LubricantXL-6 /
ESR-M13P4-A
Door latch, hood latch,
auxiliary hood latch,
door hinges, striker
plates, seat tracks and
fuel filler door hinge— Multi-Purpose GreaseXG-4 or XL-5 /
ESB-M1C93-B
Lock cylinders —Motorcraft Penetrating
and Lock LubricantXL-1 /
None
Engine coolant 2.3L
engine8.56 quarts
(8.1L)Motorcraft Premium
Gold Engine Coolant
(yellow-colored)
1
VC-7-B /
WSS-M97B51-A1
Engine coolant 3.0L
engine9.72 quarts
(9.2L)
Cooling system stop
leak pellets—Motorcraft Cooling
System Stop Leak PelletsVC-6 /
WSS-M99B37-B6
2007 Fusion(fsn)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
266

A
Accessory delay ..........................68
Air cleaner filter ...............262–264
Air conditioning ....................43, 45
Airbag supplemental
restraint system ........121, 130, 133
and child safety seats ............123
description ..............121, 130, 133
disposal ....................................136
driver airbag ............123, 130, 134
indicator light .........129, 132, 135
operation .................123, 130, 134
passenger airbag .....123, 130, 134
side airbag ...............................130
All Wheel Drive (AWD),
driving off road .........................183
Antifreeze
(see Engine coolant) ................239
Anti-lock brake system
(see Brakes) ..............................174
Anti-theft system ..................96, 99
arming the system ....................99
disarming a triggered
system .....................................100
triggering .................................100
Audio system (see Radio) ...21, 27
Automatic transaxle
fluid, adding ............................257
fluid, checking ........................257
Automatic transmission
driving an automatic
overdrive .........................179–180
fluid, adding ....................259, 262
fluid, checking ................259, 262
fluid, refill capacities ..............266
fluid, specification ..................266Auxiliary Input Jack ...................34
Axle
lubricant specifications ..........266
B
Battery .......................................237
acid, treating emergencies .....237
jumping a disabled battery ....205
maintenance-free ....................237
replacement, specifications ...264
servicing ..................................237
Belt-Minder.............................116
Brakes ........................................173
anti-lock ...................................174
anti-lock brake system (ABS)
warning light ...........................174
fluid, checking and adding ....257
fluid, refill capacities ..............266
fluid, specifications .................266
lubricant specifications ..........266
parking ....................................175
shift interlock ..........................177
Break-in period .............................5
Bulbs ............................................53
C
Capacities for refilling fluids ....266
Cassette tape player ...................21
Cell phone use ..............................7
Changing a tire .........................199
Child safety restraints ..............136
child safety belts ....................136
Child safety seats ......................140
attaching with tether straps ..144
in front seat ............................141
in rear seat ..............................141
2007 Fusion(fsn)
Owners Guide (post-2002-fmt)
USA(fus)
Index
274

J
Jack ............................................199
positioning ...............................199
storage .....................................199
Jump-starting your vehicle ......205
K
Keyless entry system
autolock .....................................86
Keys .......................................83, 97
positions of the ignition .........170
L
Lamps
autolamp system .......................49
bulb replacement
specifications chart ..................54
daytime running light ...............50
fog lamps ...................................50
headlamps .................................49
headlamps, flash to pass ..........51
instrument panel, dimming .....51
interior lamps ...........................53
replacing bulbs .........................54
Lane change indicator
(see Turn signal) ........................53
Lights, warning and indicator ....10
anti-lock brakes (ABS) ..........174
Load limits .................................163
Locks
autolock .....................................86
childproof ..................................89
doors ..........................................85
Lubricant specifications ...........266
Lug nuts ....................................204
Lumbar support, seats .............102M
Manual transmission .................182
fluid capacities ........................266
lubricant specifications ..........266
reverse .....................................183
Message center ...........................75
english/metric button ...............80
system check button ................79
warning messages .....................80
Mirrors .........................................69
automatic dimming rearview
mirror ........................................68
heated ........................................69
side view mirrors (power) .......69
Moon roof ....................................73
Motorcraft parts ........225, 245, 264
N
Navigation system .......................40
O
Octane rating ............................249
Oil (see Engine oil) ..................232
P
Parking brake ............................175
Parts (see Motorcraft parts) ....264
Passenger Occupant
Classification Sensor .................108
Power distribution box
(see Fuses) ...............................196
Power door locks ........................85
Power mirrors .............................69
Power point .................................66
2007 Fusion(fsn)
Owners Guide (post-2002-fmt)
USA(fus)
Index
277

checking the pressure ............152
inflating ...................................150
label .........................................162
replacing ..................................154
rotating ....................................156
safety practices .......................155
sidewall information ...............157
snow tires and chains ............163
spare tire .................................199
terminology .............................149
tire grades ...............................149
treadwear ........................148, 153
Towing .......................................168
recreational towing .................168
trailer towing ..........................168
wrecker ....................................210
Traction control ........................175
Transaxle
fluid, checking and adding
(automatic) .............................257
fluid, checking and adding
(manual) .................................262
Transmission .............................177
brake-shift interlock (BSI) ....177
fluid, refill capacities ..............266lubricant specifications ..........266
manual operation ....................182
Trunk ...........................................89
remote release ....................82, 92
Turn signal ..................................53
V
Vehicle Identification Number
(VIN) ..........................................270
Vehicle loading ..........................163
Ventilating your vehicle ...........173
W
Warning lights (see Lights) .......10
Washer fluid ..............................231
Water, Driving through .............189
Windows
power .........................................67
Windshield washer fluid and
wipers ..........................................63
checking and adding fluid .....231
replacing wiper blades ...........231
Wrecker towing .........................210
2007 Fusion(fsn)
Owners Guide (post-2002-fmt)
USA(fus)
Index
279