2007 FORD F650 climate control

Introduction 4
Safety and environment protection 5
Symbol glossary 8
Vehicle Inspection Guide 11
Instrument Cluster 22
Warning lights and chimes 22
Gauges 27
Entertainment Systems 32
AM/FM stereo 32
AM/FM stereo cassette with CD 38
AM/FM stereo with in-dash six CD 43
Climate Controls 49
Heater only 49
Manual heating and air conditioning 50
Lights 52
Headlamps 52
Turn signal control 53
Interior lamps 54
Bulb replacement 54
Driver Controls 58
Windshield wiper/washer control 58
Steering wheel adjustment 58
Power windows 59
Mirrors 61
Speed control 63
Locks and Security 67
Keys 67
Locks 67
Table of Contents
1
2007 F-650/750(f67)
Supplement
USA(fus)

HEATER ONLY SYSTEM (IF
EQUIPPED)
1.Fan speed adjustment:Controls
the volume of air circulated in the
vehicle.
2.Temperature selection:
Controls the temperature of the
airflow in the vehicle.
3.Air flow selections:Controls the direction of the airflow in the
vehicle. See the following for a brief description on each control.
:Distributes outside air through the instrument panel vents.
OFF:Outside air is shut out and the fan will not operate.
:Distributes outside air through the instrument panel vents and the
floor vents.
:Distributes outside air through the floor vents.
:Distributes outside air through the windshield defroster vents and
floor vents.
:Distributes outside air through the windshield defroster vents.
Operating tips
•To reduce fog build up on the windshield during humid weather, place
the air flow selector in the
position.
•To reduce humidity build up inside the vehicle during cold or warm
weather, do not drive with the air flow selector in the OFF position.
•Under normal weather conditions, do not leave the air flow selector in
OFF when the vehicle is parked. This allows the vehicle to “breathe”
using the outside air inlet vents.
•Do not put objects under the front seats that will interfere with the air
flow to the back seats.
•Remove any snow, ice or leaves from the air intake area at the base of
the windshield.
To aid in side window defogging/demisting in cold weather:
1. Select
2. Set the temperature control to full heat
3. Set the fan speed to its highest speed
2007 F-650/750(f67)
Supplement
USA(fus)
Climate Controls
49

4. Direct the outer instrument panel vents towards the side windows
To increase airflow to the outer instrument panel vents, close the vents
located in the middle of the instrument panel.
Do not place objects on top of the instrument panel as these
objects may become projectiles in a collision or sudden stop.
MANUAL HEATING AND AIR CONDITIONING SYSTEM (IF
EQUIPPED)
1.Fan speed adjustment:Controls
the volume of air circulated in the
vehicle.
2.Temperature selection:
Controls the temperature of the
airflow in the vehicle.
3.Air flow selections:Controls the direction of the airflow in the
vehicle. See the following for a brief description on each control.
MAX A/C:Uses recirculated air to cool the vehicle. Air flows from the
instrument panel vents only.
A/C:Uses outside air to cool the vehicle. Air flows from the instrument
panel vents only.
:Distributes outside air through the instrument panel vents.
OFF:Outside air is shut out and the fan will not operate.
:Distributes outside air through the instrument panel vents and the
floor vents.
:Distributes outside air through the floor vents.
:Distributes outside air through the windshield defroster vents and
floor vents.
:Distributes outside air through the windshield defroster vents.
2007 F-650/750(f67)
Supplement
USA(fus)
Climate Controls
50

Operating tips
•To reduce fog build up on the windshield during humid weather, place
the air flow selector in the
position.
•To reduce humidity build up inside the vehicle: do not drive with the
air flow selector in the OFF or MAX A/C position.
•Under normal weather conditions, do not leave the air flow selector in
MAX A/C or OFF when the vehicle is parked. This allows the vehicle
to “breathe” using the outside air inlet vents.
•Do not put objects under the front seats that will interfere with the
airflow to the back seats.
•Remove any snow, ice or leaves from the air intake area at the base of
the windshield.
To aid in side window defogging/demisting in cold weather:
1. Select
2. Select A/C
3. Modulate the temperature control to maintain comfort.
4. Set the fan speed to its highest speed
5. Direct the outer instrument panel vents towards the side windows
To increase airflow to the outer instrument panel vents, close the vents
located in the middle of the instrument panel.
Do not place objects on top of the instrument panel as these
objects may become projectiles in a collision or sudden stop.
2007 F-650/750(f67)
Supplement
USA(fus)
Climate Controls
51

If you drive in extremely hot climates:
•It is still necessary to maintain the coolant concentration
above 40%.
•NEVER decrease the coolant concentration below 40%.
•Engine coolant concentrations below 40% will decrease the
corrosion protection characteristics of the engine coolant and
may cause engine damage.
•Engine coolant concentrations below 40% will decrease the
freeze protection characteristics of the engine coolant and may
cause engine damage.
•If available, refer to the chart on the coolant container to
ensure the coolant concentration in your vehicle will provide
adequate protection at the temperatures in which you drive.
Vehicles driven year-round in non-extreme climates should use a 50/50
mixture of engine coolant and distilled water for optimum cooling system
and engine protection.
Fan clutches
Your vehicle’s cooling system is equipped with a viscous fan clutch.
•The fan clutch helps control cooling, increase performance, improve
fuel economy and reduce noise.
•The fan clutch is controlled by bimetallic spring sensors. Do not
tamper with these sensors as this may change their calibration or keep
the fan clutch from operating at all.
Stay clear of the fan/fan area while the engine is running or
possible personal injury may occur.
FUEL FILTER/WATER SEPARATOR
Do not drain water separator while engine is running. Fuel may
ignite if separator is drained while engine is running or vehicle is
moving.
The fuel filter/water separator removes any contaminated particles
and/or water from the fuel before the fuel enters the engine.
The fuel filter/water separator should be drained as recommended in the
Scheduled Maintenance Guidechapter.
2007 F-650/750(f67)
Supplement
USA(fus)
Maintenance and Specifications
185

A
Air conditioning ..........................50manual heating and air
conditioning system .................50
Air suspension ...................119–120
Anti-lock brake system
(see Brakes) ..............................117
Audio system
(see Radio) ................32, 34, 38, 43
Automatic transmission ............121 fluid, adding ............................198
fluid, checking ........................198
fluid, refill capacities ..............228
fluid, specification ..................214
Auxiliary power point .................59
Axle ............................130, 167, 204 lubricant specifications ..........214
refill capacities ........................227
B
Battery .......................................179 charging system warning
light ............................................22
jumping a disabled battery ....148
servicing ..................................268
voltage gauge ............................27
BeltMinder
.................................79
Brakes ..........................99, 104, 168 adjustment ..............................170
anti-lock ...........................117–118
anti-lock brake system (ABS)
warning light .....................22, 118
brake warning light ..................22
fluid, checking and
adding ..............................170, 196
fluid, specifications .................214
parking ....................100, 106, 171
Bulbs ............................................54 C
Catalytic converter
(see Emission control) .............171
CD-single premium .....................32
Cell phone use ..............................7
Child safety restraints ................84
child safety belts ......................84
Child safety seats ........................86 attaching with tether straps ....90
in front seat ..............................88
in rear seat ................................88
tether anchorage hardware .....90
Child safety seats - booster
seats .............................................84
Cleaning your vehicle chrome and aluminum
parts .........................................161
engine compartment ..............161
exterior ....................................163
instrument panel ....................162
interior .....................................162
interior trim ............................162
plastic parts ............................161
washing ....................................160
waxing .....................................160
wheels ......................................161
Climate control (see Air
conditioning or Heating) ......49–50
Clutch ................................123, 197 adjusting ..................................197
fluid ..........................................197
operation while driving ..........124
specifications ..........................214
Controls power seat .................................71
Coolant ......................................181 checking and adding ......181–182
disposal ....................................184
2007 F-650/750 (f67)
Supplement
USA (fus)
Index
271

Parking brake ....................100, 106warning light .............................22
Power door locks ........................67
Power mirrors .............................61
Power point .................................59
Power steering ..........................173 fluid, checking and adding ....195
fluid, refill capacity ................228
fluid, specifications .................214
Power Take-Off (PTO) operation .................................128
Power Windows ...........................59
R
Radio ..........................32, 34, 38, 43
Relays ........................................142
Remote entry system locking/unlocking doors ...........67
Roadside assistance ..................140
S
Safety belts
(see Safety restraints) .........74–76
Safety defects, reporting ..........159
Safety restraints ....................74–76 BeltMinder
..............................79
cleaning the safety belts ..........78
extension assembly ..................78
for adults .............................75–76
for children .........................83–84
lap belt ......................................76
warning light and chime ....22, 79
Safety seats for children ............86
Scheduled Maintenance
Guide .........................................231 Coolant Change Record .........269 General Maintenance
Information .............................231
Seat belts
(see Safety restraints) ...............74
Seats ............................................68 child safety seats ......................86
heated ........................................73
Special notice ................................6
Specification chart,
lubricants ...................................214
Speed control ..............................63
Speedometer ...............................27
Starting your vehicle ..................91 jump starting ..........................148
preparing to start your
vehicle .......................................91
Steering .....................................172
Steering wheel controls ................................58, 63
tilting .........................................58
Suspension ................119–120, 201
T
Tachometer .................................27
Temperature control
(see Climate control) ...........49–50
Tires checking the pressure ............210
Towing wrecker ....................................152
Traction control off light ......................................22
Transmission .....................121, 125 automatic operation ...............121
fluid, checking and adding
(automatic) .............................198
2007 F-650/750 (f67)
Supplement
USA (fus)
Index
274