2007 FORD F650 oil temperature

ComponentLubrication
typeViscosity /
Ambient
temperature /
NotesEquivalent
Ford part
name /
number
Cab components
Hydraulic lift pump
fluidDexron III — Motorcraft
MERCON

Multi-Purpose
(ATF)
Transmission
Fluid /
XT-2-QDX
Cab latch and lock
leversMobile SHC 32
Low
Temperature
Lubricant (or
equivalent)——
Cab latch pivots;
Door check,
hinges, latches and
strikers; Seat
adjuster slidesGC/LB NLGI #2
lithium
complex-based
moly grease (or
equivalent) or
multi-purpose
lithium complex
grease— Motorcraft
Premium Long
Life Grease /
XG-1-C
Cab latch pivot
pinsLight engine oil — Motorcraft SAE
5W-30 Super
Premium Motor
Oil /
XO-5W30-QSP
Door lock cylinders Lock oil — Motorcraft
Penetrating and
Lock Lubricant
/ XL-1
2007 F-650/750(f67)
Supplement
USA(fus)
Maintenance and Specifications
225

ComponentLubrication
typeViscosity /
Ambient
temperature /
NotesEquivalent
Ford part
name /
number
Door window
regulatorsNGLI #2
multipurpose
lithium complex
grease— Motorcraft
Multi-Purpose
Grease Spray /
XL-5 or
Motorcraft
Multi-Purpose
Grease / XG-4
Weatherstripping Silicone
lubricant— Motorcraft
Silicone Spray /
XL-6
Engine oil
6.0L Power Stroke
engineAPI CI-4/SL SAE 15W–40
above 10°F
(–12°C)Motorcraft SAE
15W-40 Super
Duty Motor Oil
/
XO-15W40-QSD
SAE 10W-30
–10°F to 90°F
(–23°C to
32°C)Motorcraft SAE
10W-30 Super
Duty Motor Oil
/
XO-10W30-QSD
SAE 0W–30
below 0°F
(–18°C)Motorcraft SAE
0W-30 Super
All Season
Motor Oil /
XO-0W30-LAS
Cummins B and
Caterpillar enginesRefer to engine operator manual
Brake fluid
Master cylinder DOT 3,
ESA-M6C25–A
or
WSS-M6C62–A— Motorcraft High
Performance
DOT 3 Motor
Vehicle Brake
Fluid, PM-1 or
PM-1–C
(1)Add the coolant type originally equipped in your vehicle.
2007 F-650/750(f67)
Supplement
USA(fus)
Maintenance and Specifications
226

Avoid driving your vehicle if it does not operate properly. If the engine
diesels (more than five seconds of engine run-on after shut-off), misfires,
surges, stalls or backfires, see your dealer. Be alert for fluid leakage,
odor, smoke, loss of oil pressure, or charge indicator or over temperature
warning.
Do NOT use diesel fuel blended with waste oil in engines equipped with
a catalytic converter-muffler. Waste lube oil blending in fuel will plug the
catalytic converter-muffler, resulting in a significant loss of engine power.
Emissions control system(s) laws
Federal law prohibits vehicle manufacturers, dealers and other persons
engaged in the business of repairing, servicing, selling, leasing or trading
motor vehicles, as well as fleet operators from knowingly removing or
rendering an emissions control device or system inoperative. Further,
modifications of the emissions control system(s) could create liability on
the part of individual owners under the laws of some states. In Canada,
modification of the emissions control system could create liability under
applicable Federal or Provincial laws.
NOISE EMISSIONS WARRANTY, PROHIBITED TAMPERING ACTS
AND MAINTENANCE
On January 1, 1978, Federal regulations became effective governing the
noise emissions on trucks over 10,000 lb. (4,536 kg) GVWR. The
following statements concerning prohibited tampering acts and
maintenance and the noise warranty are found in the Warranty Guide,
and are applicable to completed trucks.
Tampering with noise control system prohibited
Federal law prohibits the following acts or the causing thereof: (1) The
removal or rendering inoperative, by any person other than for purposes
of maintenance, repair or replacement, of any device or element of
design incorporated into any new vehicle for the purpose of noise control
prior to its sale or delivery to the ultimate purchaser or while it is in use,
or (2) the use of the vehicle after such device or element of design has
been removed or rendered inoperative by any person.
2007 F-650/750(f67)
Supplement
USA(fus)
Scheduled Maintenance Guide
234

SPECIAL OPERATING CONDITIONS
If your driving habitsfrequentlyinclude one or more the following
conditions:
•Short trips oflessthan 10 miles (16 km) when outside temperatures
remain below freezing.
•Operating duringhot weatherin stop-and-go “rush hour” traffic.
•Operating in severe dust conditions.
•Extensive idling, or low speed operation such as door-to-door delivery
service.
•High speed operation with a fully loaded vehicle (maximum GVW).
•Snowplowing.
Perform the following:
•Change engine oil and oil filter every three months, 5,000 miles (8,000
km) or 125 hours of engine service.
•If the vehicle is used for stationary use, change engine oil and filter
every three months, 5,000 miles or 200 hours of engine operation,
whichever comes first.
•If operating in severe dust conditions, replace the air filter more often
than regular intervals as determined by the air filter restriction gauge.
Make sure that the air filter restriction gauge is in good working order.
•Lube the manual transmission and the rear axle every 30,000 miles
(48,000 km) or six months, whichever comes first.
•See the Allison, Cummins and Caterpillar Operator’s Manual.
2007 F-650/750(f67)
Supplement
USA(fus)
Scheduled Maintenance Guide
268

recovery reservoir ..................181
refill capacities ........................228
specifications ..........................214
temperature gauge ...................27
Cruise control
(see Speed control) ....................63
Customer Assistance ........140, 156 Ford accessories for your
vehicle .....................................163
Getting assistance outside
the U.S. and Canada ......156, 158
Getting roadside assistance ...140
Getting the service you
need .........................................156
Ordering additional owner’s
literature .................................159
D
Daytime running lamps
(see Lamps) ................................52
Defects, reporting .....................159
Defrost ...................................49–50 windshield ...........................49–50
with heating and air
conditioning system .................50
with standard heating
system .......................................49
Doors lubricant specifications ..........214
Driving under special
conditions through water ...........................96
E
Emergencies, roadside jump-starting ..........................148
Emission control system ..194, 233 catalytic converter ..................171 Engine
cleaning ...................................161
coolant .....................................181
lubrication specifications .......214
Engine fan .................................185
Engine oil ..................................176 checking and adding ..............176
oil pressure gauge ....................27
recommendations ...................177
refill capacities ........................228
specifications ..........................214
F
Fan, Engine Cooling .................185
Flashers, hazard ........................141
Fuel ............................................189 calculating fuel
economy ..........................191–192
capacity ...................................229
choosing the right fuel ...........190
filling your vehicle with fuel ..189
filter,
specifications ..........185, 187–188
gauge .........................................27
improving fuel
economy ..........................191–192
running out of fuel ...........95, 191
safety information relating to
automotive fuels .....................189
Fuses ..................................141, 148
G
Gas mileage
(see Fuel economy) .........191–192
Gauges .........................................27 battery voltage gauge ...............27
engine coolant temperature
gauge .........................................27
2007 F-650/750 (f67)
Supplement
USA (fus)
Index
272