2007 FORD E SERIES check transmission fluid

Launching or retrieving a boat
Disconnect the wiring to the trailer before backing the trailer
into the water. Reconnect the wiring to the trailer after the
trailer is removed from the water.
When backing down a ramp during boat launching or retrieval:
•do not allow the static water level to rise above the bottom edge of
the rear bumper.
•do not allow waves to break higher than 6 inches (15 cm) above the
bottom edge of the rear bumper.
Exceeding these limits may allow water to enter vehicle components:
•causing internal damage to the components.
•affecting driveability, emissions and reliability.
Replace the rear axle lubricant any time the axle has been submerged in
water. Rear axle lubricant quantities are not to be checked or changed
unless a leak is suspected or repair required.
RECREATIONAL TOWING (ALL WHEELS ON THE GROUND)
An example of recreational towing would be towing your vehicle on a
trip behind a motorhome. Follow these guidelines if you have the need
for recreational towing of your vehicle with all four wheels on the
ground. These guidelines are designed to ensure that your transmission
is not damaged.
2WD vehicles (with automatic transmissions):
•Place the transmission in N (Neutral)
•Maximum speed is 35 mph (56 km/h)
•Maximum distance is 50 miles (80 km)
If a distance of 50 miles (80 km) or a speed of 35 mph (56 km/h) must
be exceeded, the drive shaft will have to be removed.
Ford recommends the driveshaft be removed/installed only by a qualified
technician at an authorized dealer. See your authorized dealer for
driveshaft removal/installation.
Improper removal/installation of the driveshaft can cause
transmission fluid loss, damage to the driveshaft and internal
transmission components.
2007 Econoline(eco)
Owners Guide (post-2002-fmt)
USA(fus)
Tires, Wheels and Loading
139

4. Turn the engine off.
For E-450 and E-550 vehicles with the Hydro-Boost Brake
System, do not press the brake pedal after the engine has been
turned off. Pressing the brake pedal after the engine has been turned
off will give a false power steering fluid level reading.
5. Recheck the fluid level on the dipstick. Do not add fluid if the level is
between the arrows in the FULL COLD range.
6. If the fluid is low, add fluid in small amounts, continuously checking
the level until it reaches the FULL COLD range. Be sure to put the
dipstick back in the reservoir.
BRAKE FLUID
The fluid level will drop slowly as
the brakes wear, and will rise when
the brake components are replaced.
Fluid levels below the “MAX” line
that do not trigger the brake system
warning lamp are within the normal
operating range, there is no need to
add fluid. If the fluid levels are outside of the normal operating range,
the performance of your brake system could be compromised, seek
service from your authorized dealer immediately.
DRIVELINE UNIVERSAL JOINT AND SLIP YOKE
Your vehicle may be equipped with universal joints that require
lubrication. Refer to thescheduled maintenance informationfor
maintenance intervals. If the original universal joints are replaced with
universal joints equipped with grease fittings, lubrication will also be
necessary.
TRANSMISSION FLUID
Checking automatic transmission fluid (if equipped)
Refer to yourscheduled maintenance informationfor scheduled
intervals for fluid checks and changes. Your transmission does not
consume fluid. However, the fluid level should be checked if the
transmission is not working properly, i.e., if the transmission slips or
shifts slowly or if you notice some sign of fluid leakage.
Automatic transmission fluid expands when warmed. To obtain an
accurate fluid check, drive the vehicle until it is at normal operating
MAX
2007 Econoline(eco)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
234

temperature (approximately 20 miles [30 km]). If your vehicle has been
operated for an extended period at high speeds, in city traffic during hot
weather or pulling a trailer, the vehicle should be turned off for about
30 minutes to allow fluid to cool before checking.
1. Drive the vehicle 20 miles (30 km) or until it reaches normal operating
temperature.
2. Park the vehicle on a level surface and engage the parking brake.
3. With the parking brake engaged and your foot on the brake pedal,
start the engine and move the gearshift lever through all of the gear
ranges. Allow sufficient time for each gear to engage.
4. Latch the gearshift lever in P (Park) and leave the engine running.
5. Remove the dipstick, wiping it clean with a clean, dry lint free rag. If
necessary, refer toIdentifying components in the engine compartment
in this chapter for the location of the dipstick.
6. Install the dipstick making sure it is fully seated in the filler tube.
7. Remove the dipstick and inspect the fluid level. The fluid should be in
the designated area for normal operating temperature or ambient
temperature.
Low fluid level
Do not drive the vehicle if the fluid
level is at the bottom of the dipstick
and the ambient temperature is
above 50°F (10°C).
Correct fluid level
The transmission fluid should be checked at normal operating
temperature 150°F-170°F (66°C-77°C) on a level surface. The normal
operating temperature can be reached after approximately 20 miles
(30 km) of driving.
You can check the fluid without driving if the ambient temperature is
above 50°F (10°C). However, if fluid is added at this time, an overfill
condition could result when the vehicle reaches normal operating
temperature.
The transmission fluid should be in
this range if at normal operating
temperature (150°F-170°F
[66°C-77°C]).
2007 Econoline(eco)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
235

4Automatic transmissions that require MERCON
V should only use MERCON
V fluid or fluid that
is specified dual usage MERCON
/ MERCON
V. Refer toscheduled maintenance informationto
determine the correct service interval. Use of any fluid other than the recommended fluid may
cause transmission damage.
Automatic transmissions that require MERCON
SP should only use MERCON
SP fluid. Use of a
dual usage fluid in an automatic transmission requiring MERCON
SP may cause transmission
damage. Refer toscheduled maintenance informationto determine the correct service interval.
Use of any fluid other than the recommended fluid may cause transmission damage.5Dana limited-slip axle (M60) requires 8 oz. (228 ml) of Additive Friction Modifier XL-3 or
equivalent meeting Ford specification EST-M2C118-A.6If your vehicle’s rear axle is filled with a synthetic rear axle lubricant it is considered lubricated
for life. These lubricants do not need to be checked or changed unless a leak is suspected, service
is required or the axle assembly has been submerged in water. The axle lubricant should be
changed any time the rear axle has been submerged in water.7Fill Dana rear axles to 1/4 inch to 9/16 inch (6 mm to 14 mm) below bottom of fill hole.8Optional fuel tank 55.0 gallons (208.0L).
2007 Econoline(eco)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
246

A
Accessory delay ..........................49
AdvanceTrac ..............................145
Air cleaner filter ...............237–239
Airbag supplemental restraint
system ....................................76–77
and child safety seats ..............78
description ................................77
disposal ......................................80
driver airbag ..............................79
indicator light ...........................80
operation ...................................79
passenger airbag .......................79
passenger deactivation
switch ........................................81
Ambulance packages ....................8
Antifreeze
(see Engine coolant) ................216
Anti-lock brake system
(see Brakes) ..............................144
Audio system
(see Radio) ......................19, 21, 25
Automatic transmission
driving an automatic
overdrive .................152, 155, 157
fluid, adding ............................234
fluid, checking ........................234
fluid, refill capacities ..............241
fluid, specification ..................241
Auxiliary power point .................48
Axle
lubricant specifications ..........241
refill capacities ........................241
traction lok ..............................149
B
Battery .......................................214acid, treating emergencies .....214
battery saver .............................34
jumping a disabled battery ....185
maintenance-free ....................214
replacement, specifications ...239
servicing ..................................214
BeltMinder
.................................72
Brakes ........................................143
anti-lock ...................................144
anti-lock brake system (ABS)
warning light ...........................144
fluid, checking and adding ....234
fluid, refill capacities ..............241
fluid, specifications .................241
lubricant specifications ..........241
parking ....................................145
shift interlock ..........................151
Break-in period .............................5
Bulbs ............................................39
C
Capacities for refilling fluids ....241
Cell phone use ..............................9
Child safety restraints ................86
child safety belts ......................86
Child safety seats ........................90
in front seat ..............................91
in rear seat ................................91
tether anchorage hardware .....94
Cleaning your vehicle
engine compartment ..............202
exterior ....................................205
instrument panel ....................203
interior .....................................204
interior trim ............................204
plastic parts ............................202
safety belts ..............................204
washing ....................................200
waxing .....................................201
2007 Econoline(eco)
Owners Guide (post-2002-fmt)
USA(fus)
Index
253

wheels ......................................201
wiper blades ............................203
Climate control (see Air
conditioning or Heating) ......31–33
Clock adjust
6-CD in dash .......................22, 27
AM/FM .......................................20
Compass, electronic ....................47
calibration .................................48
set zone adjustment .................47
Console
overhead ..............................45–46
Controls
power seat .................................61
Coolant
checking and adding ..............216
refill capacities ................220, 241
specifications ..........................241
Cruise control
(see Speed control) ....................51
Customer Assistance ................163
Ford Extended Service
Plan ..........................................196
Getting assistance outside
the U.S. and Canada ..............197
Getting roadside assistance ...163
Getting the service
you need .................................192
Ordering additional owner’s
literature .................................198
Utilizing the
Mediation/Arbitration
Program ...................................196
D
Daytime running lamps
(see Lamps) ................................35Dipstick
automatic transmission
fluid ..........................................234
engine oil .................................211
Driveline universal joint and
slip yoke ....................................234
Driving under special
conditions
through water .........................162
E
Emergencies, roadside
jump-starting ..........................185
Emergency Flashers .................165
Emission control system ..........230
Engine ........................................247
cleaning ...................................202
coolant .....................................216
diesel ...........................................7
fail-safe cooling .......................221
idle speed control ...................214
lubrication specifications .......241
refill capacities ........................241
service points ..........................209
starting after a collision .........165
Engine block heater .................143
Engine oil ..................................211
change oil soon warning,
message center .......................211
checking and adding ..............211
dipstick ....................................211
filter, specifications ........213, 239
recommendations ...................213
refill capacities ........................241
specifications ..........................241
Exhaust fumes ..........................143
F
Fail safe cooling ........................221
2007 Econoline(eco)
Owners Guide (post-2002-fmt)
USA(fus)
Index
254

Seat belts
(see Safety restraints) ...............66
Seats ............................................60
child safety seats ......................90
front seats .................................60
Servicing your vehicle ..............207
Setting the clock
AM/FM stereo ...........................20
AM/FM/In-dash 6 CD ..........22, 27
Spare tire
(see Changing the Tire) ...........178
Spark plugs,
specifications .....................239, 247
Special notice ................................8
ambulance conversions ..............8
diesel-powered vehicles .............7
utility-type vehicles ....................7
Specification chart,
lubricants ...................................241
Speed control ..............................51
Starting your vehicle ........140–142
jump starting ..........................185
Steering wheel
tilting .........................................45
T
Temperature control
(see Climate control) ...........31, 33
Tilt steering wheel ......................45
Tires ...................................104–105
alignment ................................114
care ..........................................110
changing ..........................178–179
checking the pressure ............109
inflating ...................................106
label .........................................121
replacing ..........................112, 181
rotating ....................................114safety practices .......................113
sidewall information ...............116
snow tires and chains ............122
spare tire .........................176, 178
terminology .............................105
tire grades ...............................105
treadwear ........................104, 111
Towing .......................................128
recreational towing .................139
trailer towing ..........................128
wrecker ....................................191
Traction-lok rear axle ...............149
Transmission .............................151
brake-shift interlock (BSI) ....151
fluid, checking and adding
(automatic) .............................234
fluid, refill capacities ..............241
lubricant specifications ..........241
Turn signal ..................................38
V
Vehicle Identification Number
(VIN) ..........................................248
Vehicle loading ..........................122
Ventilating your vehicle ...........143
W
Warning lights (see Lights) .......12
Washer fluid ..............................210
Water, Driving through .............162
Windows
power .........................................49
Windshield washer fluid and
wipers ..........................................44
checking and adding fluid .....210
replacing wiper blades ...........210
Wrecker towing .........................191
2007 Econoline(eco)
Owners Guide (post-2002-fmt)
USA(fus)
Index
257