2007 FIAT 600 brake

110CAR MAINTENANCE
CHECKING FLUID LEVELS
fig. 1
P4Q01095
Do not smoke while
working in the engine
compartment: the pres-
ence of flammable gas and
vapour could cause a fire.
Be very careful: scarves,
ties and other loose arti-
cles of clothing could eas-
ily get caught up in moving parts.
This can be extremely danger-
ous.
1. Engine oil - 2. Battery - 3. Brake fluid - 4. Windscreen washer fluid - 5. Engine
coolant.
Be careful not to mix up
the various types of fluids
when you are topping up:
they are all mutually incompati-
ble and could damage the car. ENGINE OIL
Check engine oil with the car on
level ground and while the engine is
still warm (approximately 5 minutes
after stopping the engine).
The oil level must be between the
MIN and MAX marks on the dipstick
B-fig. 2.The space between MIN and MAX
equals about 1 litre of oil.
If the oil level is near or even below
the MINmark, pour in oil through
the filler hole Auntil it reaches the
MAXmark.
The level of the oil should never ex-
ceed the MAXmark.
105-123 Seicento GB 22-11-2007 10:51 Pagina 110

112CAR MAINTENANCE
fig. 5
P4Q01042
Do not travel with the
windscreen washer reser-
voir empty. The wind-
screen washer is fundamental for
improving visibility. Some windscreen wiper
additives on the market
are flammable. The en-
gine compartment contains hot
parts which could start a fire in
the event of contact.
BRAKE FLUID fig. 5
Unscrew cap check that the fluid
level in the reservoir is at maximum.
Fluid level in the reservoir shall not
exceed the MAXmark. Check coolant level when the engine
is cold. The level should be included
between the MIN and MAXrefer-
ence lines on the reservoir.
If the level is low, top up slowly
through the filler on the reservoir
with a 50-50 mixture of distilled wa-
ter and FL Selenia PARAFLU UP
fluid until the level approaches the
MAX line. A 50-50 mixture of
PARAFLU UPand distilled water
gives freeze protection to –35°C.
For particularly hard climate condi-
tions, we recommend use of a 60%
PARAFLU UP and 40% demineralized
water mixture.
The engine cooling sys-
tem works with
PARAFLU UP. Top up
only with the same fluid con-
tained in the cooling circuit.
PARAFLU UP cannot be mixed
with other fluids. Should this take
place, do not start the engine and
contact Fiat Dealership.
WINDSCREEN/REAR
WINDOW WASHER LIQUID
To add liquid remove the cap A-
fig. 4.
Use a mixture of water and
TUTELA PROFESSIONAL SC35
fluid in the following concentrations:
30% of TUTELA PROFESSIONAL
SC35and 70% of water in summer.
50% of TUTELA PROFESSIONAL
SC35and 50% of water in winter.
fig. 4
P4Q01041
105-123 Seicento GB 22-11-2007 10:51 Pagina 112

The symbol πon the
container indicates syn-
thetic brake fluid distin-
guishing it from mineral fluid. Us-
ing mineral type fluid would
damage the special rubber brak-
ing system gaskets beyond re-
pair.
113CAR MAINTENANCE
Brake fluid is poisonous
and highly corrosive.
Wash the concerned
parts immediately with water
and mild soap in the event of an
accidental contact. Call a doctor
immediately if swallowed. If fluid has to be added, it is sug-
gested to use the brake fluid in table
"Fluids and lubricants" (see chapter
"Technical characteristics").
NOTE Clean accurately the tank cap
and the surrounding surface.
At plug opening, pay maximum at-
tention in order to prevent any impu-
rities from entering the tank.
For topping up, always use a funnel
with integrated filter with mesh equal
to or lower than 0.12 mm.
IMPORTANTBrake fluid absorbs
moisture, for this reason, if the vehi-
cle is mainly used in areas with a high
degree of atmospheric humidity, the
fluid should be replaced at more fre-
quent intervals than specified in the
“Service schedule”.
Make sure that the
highly corrosive brake
fluid does not drip onto
the paintwork. If it does, wash it
off immediately with water.
AIR CLEANER
REPLACEMENT
Loosen the screws A-fig. 6, remove
the cover B and remove the filtering
element C-fig. 7 to be replaced.
fig. 6
P4Q01043
fig. 7
P4Q01044
From time to time check the instru-
ment panel warning light by pressing
the reservoir cover (with the ignition
key at MAR) instrument panel warn-
ing light
xshould come on.
105-123 Seicento GB 22-11-2007 10:51 Pagina 113

127TECHNICAL SPECIFICATIONS
BRAKES
SERVICE AND EMERGENCY
BRAKES
Front:
– disc, floating caliper type with op-
erating cylinder for each wheel.
Rear:
– drum type with self-centring shoes
and operating cylinder for each wheel.
Crossed hydraulic circuit control.
7” vacuum brake booster.
ABS system with four sensors
(where fitted).
Automatic take-up of friction liner
wear.
Brake effort proportioning valves (2)
intervening on hydraulic circuit of the
rear brakes. HANDBRAKE
Controlled by a lever, it works me-
chanically on the rear brakes.
SUSPENSION
Front:
Independent wheel type, lower wish-
bones anchored to telescopic sup-
ports consisting of a cast iron riser
rigidly connected to a hydraulic dou-
ble action shock absorber. Leaf spring
and coaxial pads with the shock ab-
sorbers. Permanently lubricated joints.
Anti-roll bar anchored to the body
acting on suspension arm.
Rear:
Independent wheel with coil springs.
Jointed steel arms with bush and dou-
ble action telescopic gas shock ab-
sorbers. Water, ice and salt
sprinkled on the road de-
posit on the brake disc
and reduce effectiveness when
you brake.
Pay attention when in-
stalling extra spoilers, al-
loy wheels and non stan-
dard wheel caps: they could re-
duce the ventilation of the
brakes, thus reducing their effi-
ciency when braking suddenly
and frequently, or on long down-
hill slopes.
124-136 Seicento GB 22-11-2007 10:51 Pagina 127

132TECHNICAL SPECIFICATIONS
Van
760
450
610
720
1210
400
200
28
30 S - Active
735
465
610
630
1200
400
350
28
30
WEIGHTS
(1) If special equipment is fitted (sunroof, tow hitch etc.) the unladen weight increases, thus reducing the payload as specified in the maximum loads al-
lowed.
(2) The driver is responsible for arranging the load so that it complies with these limits.
Weight empty (including fluids, 90% fuel in the tank and no optional) kg
Payload
(4 occupants + 50 kg or driver + 330 kg) kg
Maximum loads permitted (2):
– front axle kg
– rear axle kg
– fully laden kg
Towable weight:
– trailer with brake kg
– trailer without brake kg
Weight on trailer ball joint kg
Maximum weight on roof kg
124-136 Seicento GB 22-11-2007 10:51 Pagina 132

133TECHNICAL SPECIFICATIONS
CAPACITIES
Fuel tank:
including a reserve about:
Engine cooling system:
Engine sump:
Engine sump and filter:
Gearbox/differential casing:
CV joint cavities and boots
(each):
Front and rear brakes hydraulic circuit:
Windscreen and rear window
washer liquid reservoir: Prescribed fuel
Recommended products
Unleaded petrol with no less
than 95 R.O.N.
Mixture of distilled water and
PARAFLU UPat 50% (❑)
SELENIA 20 K
TUTELA CAR TECHNYX
TUTELA ALL STAR
TUTELA TOP 4
Mixture of water and TUTELA
PROFESSIONAL SC35fluid litres kg
38 –
7–
4–
3.1 2.8
3.5 3.1
2.4 2.15
– 0.08
0.4 –
1.8 –
(❑) For particularly hard climate conditions, we recommend use of a 60% PARAFLU UP and 40% demineralized water mixture.
124-136 Seicento GB 22-11-2007 10:51 Pagina 133

135TECHNICAL SPECIFICATIONS
UseOriginal fluids
and lubricants
TETELA CAR
TECHNYX
Contractual Technical
Reference N.° F010.B05
TUTELA ALL STAR
Contractual Technical
Reference N.° F702.G07
TUTELA TOP 4
Contractual Technical
Reference N.° F001.A93
PARAFLU UP
Contractual Technical
Reference N.° F101.M01
TUTELA
PROFESSIONAL
SC 35
Contractual Technical
Reference N.° F201.D02 Fluid and lubricant specifications
for correct car operation
Lubricant with synthetic basis complying with SAE 75W-85.
Performance exceeds by far the API GL-4 PLUS
and FIAT 9.55550 standards required.
Grease containing Molybdenum bisulphide for high
temperature appliances. NLGI 1-2 consistency.
Synthetic fluid, F.M.V.S.S. no. 116, DOT 4, ISO 4925,
SAE J-1704, CUNA NC 956-01
Anti-freezing safety liquid (red colour) containing
monoethylene glycol inhibited with organic formula.
Antifreeze complying with CUNA NC 956-16, ASTM D
3306 standards.
Mixture of alcohols, water and surfactants
(CUNA NC 956-11).Change
Mechanical gear and
differential gear.
Constant-velocity
joints on wheel side.
Hydraulic brakes
and clutch hydraulic
controls.
Radiator antifreeze
proportion:
50% water and 50%
PARAFLU UP (
❒)
To be used diluted
or undiluted in
windscreen/rear
window washer/
wiper systems
IMPORTANTDo not top up or mix with fluids having characteristics different from those specified.
(
❒) For particularly hard climate conditions, we recommend use of a 60% PARAFLU UP and 40% demineralized water mixture.
Lubricants and greases
for transmission
Brake fluids
Protective agent
for radiatore
Windscreen/
rear window
washer fluid
124-136 Seicento GB 22-11-2007 10:51 Pagina 135

137INDEX
I I
N N
D D
E E
X X
ABS ............................................ 54
Accessories purchased by the
owner ......................................... 66
– Installation of electrical/
electronic devices .................... 67
– Radio transmitters and
mobile phones ...................... 67
Air filter ....................................... 113
Air recirculation ......................... 35
Ashtray ......................................... 42
Battery
– checking fluid level ............... 114
– jump starting .................. 84-101
– recharging .............................. 101
– replacing the battery ........... 114
– useful advice .......................... 115
– warning light for check ....... 115
Bodywork .................................... 124
Bonnet .......................................... 51
Boot
– extension ............................... 48
– opening ................................... 47
– securing the load .................. 49Brake fluid level .......................... 112
Brake lights .................................. 95
Brakes
– fluid level ................................ 112
– service and emergency ....... 126
Bulbs
– bulb replacement ................. 89
– exterior bulb replacement .. 92
– general information ............. 90
– interior bulb replacement .. 107
– types ....................................... 91Capacities .................................. 133
Car maintenance
– additional operations .......... 108
– annual inspection plan ......... 108
– scheduled servicing .............. 105
– service schedule ................... 106
Car parked .................................. 71
Car radio ..................................... 64
Carrying children in safety ..... 13
Ceiling (courtesy) light
– bulb replacement ................ 97– controls .................................. 39
Central locking ........................... 45
Cigar lighter ................................ 42
Clock.............................................. 24
Clutch ........................................... 127
CO
2emissions ........................... 136
Control buttons ......................... 40
Correct use of the vehicle ....... 70
Courtesy (ceiling) lights
– bulb replacement ................ 97
– controls .................................. 39
Courtesy light
– bulb replacement ................ 97
– controls .................................. 39
Dashboard ................................. 19
Dimensions ................................. 131
Dipped beam headlights
– bulb replacement ................ 92
– controls .................................. 37
Directable, adjustable air vents 33
Direction indicators
– controls .................................. 38
137-144 Seicento GB 28-11-2007 9:38 Pagina 137