2007 DODGE RAM 2500 DIESEL air filter

A visual inspection of the air cleaner filter element is
never recommended under normal circumstances. A
badly restricted element may appear clean while a soiled
element may be quite effective in filtering particles
without restricting air flow. Rely on the Filter Minder™
to determine when a filter change is necessary.
After a new filter element is inserted, press the rubber
button on the top of the Filter Minder™. This action will
reset the yellow disc to the clean position.
CAUTION!
When using an engine cleaner or a degreaser, be sure
to wrap and tape the Filter Minder™ to protect the
plastic housing from damage and discoloration.
CAUTION!
Many aftermarket performance air filter elements do
not adequately filter the air entering the engine. Use
of such filters can severely damage your engine.
Draining Fuel/Water Separator Filter
MAINTAINING YOUR VEHICLE 391
7

Priming if the engine has run out of fuel
1. Add a substantial quantity of fuel to the tank 5 to 10
gallons (19L to 38L).
2. Crank the engine for 1 to 2 seconds. If the engine does
not start, then release the key or starter button back to the
RUN position (do not turn the key back to the OFF
position). The electric fuel transfer pump will continue to
run and purge air from the system for about 25 seconds.
After 25 seconds, attempt to start the engine again.
3. Start the engine using the Normal Starting Procedure.
4. Repeat the procedure if the engine does not start.CAUTION!
Do not engage the starter motor for more than 15
seconds at a time. Allow two minutes between the
cranking intervals.
NOTE: The engine may run rough until the air is forced
from all the fuel lines.
CAUTION!
Diesel fuel will damage black top paving surfaces.
Drain the filter into an appropriate container.
MAINTAINING YOUR VEHICLE 393
7

or suspected. Proper maintenance of the entire vehicle
will help the effectiveness of the noise control systems.
Exhaust System
Inspect the entire exhaust system for leaks and damaged
parts. Devices such as hangers, clamps, and U-bolts
should be tight and in good condition. Damaged compo-
nents, burned or blown out mufflers, burned or rusted
out exhaust pipes should be replaced according to the
procedures and specifications outlined in the appropriate
service manual.
Air Cleaner Assembly
Inspect air cleaner housing for proper assembly and fit.
Make certain that the air cleaner is properly positioned
and that the cover is tight. Check all hoses leading to the
air cleaner for tightness. The air filter element must also
be clean and serviced according to the instructions out-
lined in the Maintenance Schedule Section of this
manual.Tampering With Noise Control System Prohibited
Federal law prohibits the following acts or the causing
thereof: (1) the removal or rendering inoperative by any
person, other than for purposes of maintenance, repair, or
replacement, of any device or element of design incorpo-
rated into any new vehicle for the purpose of noise
control prior to its sale or delivery to the ultimate
purchaser or while it is in use, or (2) the use of the vehicle
after such device or element of design has been removed
or rendered inoperative by any person.
Among those acts presumed to constitute tampering are
the acts listed below.
•AIR CLEANER
Removal of the air cleaner.
Removal of the air cleaner filter element from the air
cleaner housing.
Removal of the air ducting.
418 MAINTAINING YOUR VEHICLE

Once a Month
•Check tire pressure and look for unusual wear or
damage.
•Inspect the batteries and clean and tighten the termi-
nals as required.
•Check the fluid levels of coolant reservoir, brake
master cylinder, and transmission and transfer case (if
equipped), add as needed.
•Check Filter Minder™. Replace air cleaner filter
element if necessary.
•Check all lights and all other electrical items for correct
operation.
•Drain water from the fuel filter. At Each Oil Change
•Change the engine oil filter.
•Inspect the exhaust system.
•Inspect the brake hoses.
•Inspect the U-Joints ( if equipped) and front suspen-
sion components.
•Check the automatic transmission fluid level.
•Check the manual transmission fluid level.
•Check the coolant level, hoses, and clamps.
•Lubricate outer tie rod ends.
•Lubricate Front Drive Shaft Fittin
452 MAINTENANCE SCHEDULES
8
M
A I
N T
E
N A
N C E
S
C
H E
D
U L
E
S

Miles 116,250 120,000 123,750 127,500 131,250 135,000
(Kilometers) (186 000) (192 000) (198 000) (204 000) (210 000) (216 000)
Change engine oil and engine oil filter. X X X
Lubricate Front Drive Shaft Fitting (2500/
3500, 4X4). X X XXXX
Rotate tires. X X X
Check spare tire for proper pressure and cor-
rect stowage. XXX
Flush and replace engine coolant at 120
months, if not replaced at 102,000 miles (163
000 km). X
Lubricate outer tie rod ends 2500/3500 (4X4)
models. XXX
Clean engine air filter assembly. X
Adjust valve lash clearance. X
Inspect drive belts, replace as required. X
Drain and refill transfer case fluid (4X4). X
Replace fuel filter element. X X
SCHEDULE “B” 461
8
M A I
N T
E
N A
N C E
S
C
H E
D
U L
E
S

Adding Fuel........................... 320
Adjustable Pedals ....................... 132
Air Cleaner, Engine (Engine Air Cleaner Filter) . 389,418
Air Conditioner Maintenance ............... 396
Air Conditioning Refrigerant .............396,397
Air Conditioning System ................237,396
Air Conditioning System, Zone Control ........ 240
Air Filter .............................. 389
Air Pressure, Tires .................... 305,313
Airbag .............................. 45,51
Airbag Light ......................... 74,180
Airbag On/Off Switch ..................... 51
Airbag, Side ............................ 54
Alarm, Out of Park Sense .................. 273
Alarm, Panic ............................ 22
Alarm (Security Alarm) .................18,182
Alarm System (Security Alarm) ............... 18
Alignment and Balance ................... 312
Alterations/Modifications, Vehicle ............. 8 Antenna, Satellite Radio
................... 230
Antifreeze (Engine Coolant) ..............403,404
Capacities ........................... 445
Anti-Lock Warning Light ...............184,294
Anti-Theft Security Alarm (Theft Alarm) ........ 18
Anti-Theft System ..................... 18,182
Appearance Care ........................ 422
Ashtray ............................... 154
Automatic Dimming Mirror ................. 83
Automatic Transaxle ...................... 12
Interlock System ........................ 15
Automatic Transmission ................... 413
Adding Fluid ......................... 413
Fluid and Filter Changes ................. 414
Fluid Level Check ...................... 413
Fluid Type ........................ 414,447
Shift Indicator ........................ 182
Shifting ............................. 267
Special Additives ...................... 415
478 INDEX

Tow Hooks.......................... 371
Towing ............................. 372
Emission Control System Maintenance ......... 450
Engine ............................... 378
Air Cleaner .......................... 389
Block Heater ....................... 254,261
Break-In Recommendations ................ 71
Compartment ......................... 378
Coolant (Antifreeze) .................... 446
Cooling ............................. 401
Data Plate ........................... 380
Identification ......................... 378
Idling .............................. 263
Jump Starting ......................... 367
Oil .............................. 383,446
Oil Synthetic ......................... 262
Runaway ............................ 317
Temperature Gauge ..................... 181
Event Data Recorder ...................... 56 Exhaust Gas Caution
................73,172,401
Exhaust System ................. 73,400,401,418
Exterior Lighting ........................ 124
Fan .................................. 407
Filters Engine Oil ..................... 383,386,446
Flashers Turn Signal .......................... 127
Flat Tire Stowage ..................... 356,366
Fluid, Brake ........................... 447
Fluid Capacities ......................... 445
Fluid Level Checks Brake ............................... 409
Manual Transmission ................... 412
Power Steering ........................ 397
Transfer Case ......................... 412
Fluids, Lubricants and Genuine Parts .......... 446
Fog Lights ....................... 126,185,436
482 INDEX

Noise Control Maintenance .......................... 417
Tampering Prohibited ................... 418
Noise Emission Warranty ...............417,419
Occupant Restraints ....................... 31
Occupant Restraints (2500/3500/Mega Cab Only) . . 31
Odometer .......................... 182,186
Trip ............................. 182,186
Off-Pavement Driving (Off-Road) ............ 289
Off-Road Driving (Off-Pavement) ............ 289
Oil, Engine ............................ 446
Capacity ............................ 445
Change Interval ....................... 384
Dipstick ............................. 383
Disposal ............................ 389
Filter ......................... 383,386,446
Materials Added to ..................... 386
Pressure Gauge ....................... 180 Recommendation
...................... 385
Viscosity ............................ 385
Oil Filter, Change ........................ 386
Onboard Diagnostic System ................ 379
Opener, Garage Door (HomeLink ) ........... 143
Operating Precautions .................... 379
Out of Park Sense Alarm .................. 273
Outside Rearview Mirrors .................. 83
Overdrive ............................. 270
Overdrive OFF Switch .................... 270
Overhead Console .................... 136,137
Overhead Travel Information Center .......... 137
Owner’s Manual (Operator Manual) .......... 474
Panic Alarm ............................ 22
Parking Brake .......................... 290
Passenger Airbag On/Off Switch ............. 51
Passing Light ........................... 128
Pedals, Adjustable ....................... 132
INDEX 487
10