2007 DODGE GRAND CARAVAN lock

The external lock cylinders should be lubricated twice a
year, preferably in the fall and spring. Apply a small
amount of a high quality lubricant such as Mopar  Lock
Cylinder Lubricant directly into the lock cylinder.
Windshield Wiper Blades
The rubber edges of the wiper blades and the windshield
should be cleaned periodically with a sponge or soft cloth
and a mild nonabrasive cleaner. This will remove accu-
mulations of salt or road film.
Operation of the wipers on dry glass for long periods
may cause deterioration of the wiper blades. Always use
washer fluid when using the wipers to remove salt or dirt
from a dry windshield. Avoid using the wiper blades to remove frost or ice from
the windshield. Keep the blade rubber out of contact with
petroleum products such as engine oil, gasoline, etc.
Windshield and Rear Window Washers
The fluid reservoir for the windshield washers and the
rear window washer is shared. It is located in the engine
compartment and should be checked for fluid level at
regular intervals. Fill the reservoir with windshield
washer solvent (not radiator antifreeze) and operate the
system for a few seconds to flush out the residual water.
The washer fluid reservoir will hold a full gallon of fluid
when the Low Washer Fluid Light illuminates.432 MAINTAINING YOUR VEHICLE

FUSES — INTEGRATED POWER MODULE
An Integrated Power Module (IPM) located in the engine
compartment near the battery. This center contains car-
tridge fuses and mini fuses. A label that identifies each
component may be printed on the inside of the cover.
Refer to the graphic below for FUSES/IPM location. Cavity Cartridge
Fuse Description
F4 30 Amp
Pink Front Wipers
F9 40 Amp
Green Anti-Lock Brake System
(ABS) Pump
F10 40 Amp
Green Front Blower
F13 40 Amp
Green Electronic Back Light (EBL)
F19 40 Amp
Green Body Control Module
(BCM) Feed 1
F20 30 Amp
Pink Central Amplifier
F22 30 Amp
Pink Seats
F27 40 Amp
Green Radiator FanIntegrated Power module (IPM)452 MAINTAINING YOUR VEHICLE

Cavity Mini Fuse Description
F21 25 Amp
Natural Anti-Lock Brake System
(ABS) Module
F23 10 Amp Red Ignition Switch
F24 20 Amp Yel-
low Hazard
F26 20 Amp Yel-
low Stop Lamp
F33 15 Amp Blue Front/Rear Washer
20 Amp Yel-
low Spare (IOD) CAUTION!• When installing the Integrated Power Module
cover, it is important to ensure the cover is prop-
erly positioned and fully latched. Failure to do so
may allow water to get into the Integrated Power
Module, and possibly result in a electrical system
failure.
• When replacing a blown fuse, it is important to
use only a fuse having the correct amperage
rating. The use of a fuse with a rating other than
indicated may result in a dangerous electrical
system overload. If a properly rated fuse contin-
ues to blow, it indicates a problem in the circuit
that must be corrected.454 MAINTAINING YOUR VEHICLE

2. Turn the bulb socket retaining ring or the bulb assem-
bly counterclockwise.
3. Disconnect the electrical connector and replace the
bulb. NOTE: On some vehicles it may be necessary to slide
the red release lock rearward and push forward on the
connector while depressing the release tab.
CAUTION!Do not touch the new bulb with your fingers. Oil
contamination will severely shorten bulb life. If the
bulb comes in contact with an oily surface, clean the
bulb with rubbing alcohol. MAINTAINING YOUR VEHICLE 457
7

Adding Fuel ........................... 357
Adding Washer Fluid .................. 303,432
Additives, Fuel ......................... 355
Adjustable Pedals ....................... 163
Air Conditioner Maintenance ............... 428
Air Conditioning ..................... 278,284
Air Conditioning Controls ................. 278
Air Conditioning Filter ................. 301,429
Air Conditioning, Operating Tips ............ 301
Air Conditioning, Rear Zone ............. 286,296
Air Conditioning Refrigerant ............... 428
Air Conditioning System .......... 278,284,289,428
Air Conditioning System, Zone Control ........ 279
Air Pressure, Tires ....................... 337
Airbag ................................ 57
Airbag Deployment ....................... 69
Airbag Light ................... 62,63,72,90,214
Airbag Maintenance ....................... 71
Airbag, Window (Side Curtain) ............... 58 Alarm Light ........................... 216
Alarm (Security Alarm) .................... 18
Alignment and Balance ................... 344
Alterations/Modifications, Vehicle ............. 7
Antenna, Satellite Radio ................... 274
Antifreeze (Engine Coolant) ........... 435,436,461
Disposal ............................ 437
Anti-Lock Brake System (ABS) .............. 321
Anti-Lock Warning Light .................. 214
Anti-Theft System ........................ 18
Appearance Care ........................ 446
Ashtray ............................... 188
Auto Down Power Windows ................ 33
Automatic Dimming Mirror ................. 96
Automatic Door Locks ................... 29,30
Automatic Headlights .................... 153
Automatic Temperature Control (ATC) ......... 289
Automatic Transaxle .................... 12,315
Interlock System ..................... 15,316496 INDEX

Reset Mode .......................... 317
Selection Of Lubricant ................ 443,463
Shifting ............................. 317
Special Additives ...................... 445
Automatic Transmission ................... 442
Adding Fluid ......................... 444
Fluid and Filter Changes ................. 445
Fluid Change ......................... 445
Fluid Level Check ...................... 444
Fluid Type ........................ 443,463
Ball Joints ............................. 430
Battery ............................... 427
Gas Caution .......................... 427
Jump Starting ......................... 405
Keyless Transmitter Replacement (RKE) ....... 26
Saving Feature (Protection) ............... 153
Bearings .............................. 446
Belts, Drive ............................ 423 Body Mechanism Lubrication ............... 431
B-Pillar Location ........................ 332
Brake Fluid ............................ 463
Brake, Parking .......................... 319
Brake System ........................ 321,439
Anti-Lock (ABS) ....................... 321
Fluid Check .......................... 441
Hoses .............................. 440
Warning Light ........................ 213
Brakes ............................. 321,439
Brake/Transmission Interlock ............... 316
Break-In Recommendations, New Vehicle ........ 88
Bulb Replacement ....................... 456
Bulbs, Light ............................ 455
Calibration, Compass ..................... 169
Capacities, Fluid ........................ 461
Caps, Filler
Fuel ................................ 357 INDEX 497
10

Oil (Engine) .......................... 422
Radiator (Coolant Pressure) ............... 436
Car Washes ............................ 447
Carbon Monoxide Warning ................. 356
Cargo Compartment
Luggage Carrier ....................... 199
Cargo (Vehicle Loading) ................... 198
Cassette Tape and Player Maintenance ......... 276
Cassette Tape Player ..................... 222
Catalytic Converter ...................... 425
Caution, Exhaust Gas .............. 43,89,356,433
CD (Compact Disc) Changer ....... 231,238,255,259
CD (Compact Disc)
Player ............ 228,232,237,243,246,251,253,259
CD (Compact Disc) Player Maintenance ........ 277
Cellular Phone ....................... 100,274
Center High Mounted Stop Light ............ 460
Center Lap Belts ......................... 53
Chains, Tire ............................ 345 Changing A Flat Tire ..................... 386
Chart, Tire Sizing ........................ 328
Check Engine Light (Malfunction Indicator
Light) ............................. 218,417
Child Restraint ...................... 75,76,77
Child Restraint Tether Anchors ............... 79
Child Safety Locks ........................ 38
Child Seat ............................ 74,82
Clean Air Gasoline ....................... 354
Cleaning
Wheels ............................. 448
Climate Control ......................... 278
Clock ............................. 220,258
Coat Hook ............................ 198
Compact Disc (CD) Maintenance ............. 277
Compact Disc (CD) Player ............... 222,228
Compact Spare Tire ...................... 340
Compass .............................. 168
Compass Calibration ..................... 169498 INDEX

Door Ajar Light ......................... 213
Door Locks ............................. 27
Door Locks, Automatic .................... 29
Door Opener, Garage ..................... 177
Drive Belts ............................ 423
Drive Shaft Universal Joints ................ 431
Driving
On Slippery Surfaces .................... 326
DVD Player (Video Entertainment System) ...... 259
E-85 Fuel ............................. 360
Electric Remote Mirrors .................... 98
Electrical Power Outlets ................... 185
Electronic Speed Control (Cruise Control) ...... 164
Electronic Vehicle Information Center (EVIC) .... 172
Emergency, In Case of
Hazard Warning Flasher ................. 384
Jacking ........................ 386,387,399
Jump Starting ......................... 405 Overheating .......................... 385
Emission Control System Maintenance ...... 417,466
Engine ............................ 414,415
Air Cleaner .......................... 425
Air Cleaner Filter ...................... 424
Block Heater ......................... 315
Break-In Recommendations ................ 88
Checking Oil Level ..................... 420
Compartment ...................... 414,415
Coolant (Antifreeze) .................... 462
Cooling ............................. 434
Exhaust Gas Caution .................. 43,356
Flooded, Starting ...................... 313
Fuel Requirements .................. 353,461
Oil ........................... 420,461,462
Oil Change Interval .................... 421
Oil Disposal .......................... 423
Oil Filler Cap ......................... 422
Oil Filter Disposal ...................... 423500 INDEX