2007 DODGE CHARGER radiator

Points To Remember
NOTE:
When the vehicle is stopped after a few miles
(kilometers) of operation, you may observe vapor coming
from the front of the engine compartment. This is nor-
mally a result of moisture from rain, snow, or high
humidity accumulating on the radiator and being vapor-
ized when the thermostat opens, allowing hot coolant to
enter the radiator.
If an examination of your engine compartment shows no
evidence of radiator or hose leaks, the vehicle may be
safely driven. The vapor will soon dissipate.
•Do not overfill the coolant recovery bottle.
•Check coolant freeze point in the radiator and in the
coolant recovery bottle. If antifreeze needs to be
added, contents of coolant recovery bottle must also be
protected against freezing.
•If frequent coolant additions are required, or if the
level in the coolant recovery bottle does not drop when
the engine cools, the cooling system should be pres-
sure tested for leaks.
•Maintain coolant concentration at 50% HOAT engine
coolant (minimum) and distilled water for proper
corrosion protection of your engine which contains
aluminum components.
•Make sure that the radiator and coolant recovery
bottle overflow hoses are not kinked or obstructed.
•Keep the front of the radiator clean. If your vehicle is
equipped with air conditioning, keep the front of the
condenser clean, also.
•Do not change the thermostat for summer or winter
operation. If replacement is ever necessary, install
ONLY the correct type thermostat. Other designs may
result in unsatisfactory coolant performance, poor gas
mileage, and increased emissions.
Hoses And Vacuum/Vapor Harnesses
Inspect surfaces of hoses and nylon tubing for evidence
of heat and mechanical damage. Hard or soft spots,
brittle rubber, cracking, tears, cuts, abrasions, and exces-
sive swelling indicate deterioration of the rubber.
312 MAINTAINING YOUR VEHICLE

Cavity Car-
tridge
FuseMini
FuseDescription
11 — 25 Amp
ClearAuto Shutdown/
Powertrain Control
Module (PCM)
12———
13———
14 — 25 Amp
ClearPowertrain Control
Module (PCM)
15 — 20 Amp
YellowInjectors, Ignition Coils
16———
17 30 Amp
Pink— Anti-lock Brakes System
(ABS) Valves - if
equipped/Powertrain
Control Module (PCM)
18 30 Amp
Pink— Windshield Wiper/
Washer
19 50 Amp
Red— Radiator FanCavity Car-
tridge
FuseMini
FuseDescription
20 20 Amp
Blue— Starter
21 50 Amp
Red— Anti-lock Brakes System
(ABS) Pump Motor - if
equipped
22 40 Amp
Green— AC Clutch/Radiator Fan
High — Low
23———
24 60 Amp
Yellow— Radiator Fan - AWD
25 30 Amp
Pink— Front Control Module
(FCM)
26 20 Amp
Blue— Transmission - RLE
27 30 Amp
Pink— Front Control Module
(FCM)
324 MAINTAINING YOUR VEHICLE

At Each Stop for Fuel
•
Check the engine oil level about 5 minutes after a fully
warmed engine is shut off. Checking the oil level while
the vehicle is on level ground will improve the accu-
racy of the oil level reading. Add oil only when the
level is at or below the ADD or MIN mark.
•Check the windshield washer solvent and add if
required.
Once a Month
•
Check tire pressure and look for unusual wear or
damage.
•Inspect the battery, and clean, and tighten the termi-
nals as required.
•Check the fluid levels of coolant reservoir and brake
master cylinder, and add as needed.
•Check all lights and all other electrical items for correct
operation.
•Check rubber seals on each side of the radiator for
proper fit.
At Each Oil Change
•
Change the engine oil filter.
•Inspect the exhaust system.
•Inspect the brake hoses.
•Inspect the CV joints and front and rear suspension
components.
•Check the coolant level, hoses, and clamps.
344 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Fluid Level Check..................... 316
Fluid Type.......................... 339
Gear Ranges......................... 201
Shifting..........................200,205
Special Additives..................... 317
Torque Converter..................... 204
Automatic Transmission Limp Home Mode . . . 204
Autostick..........................207,209
Ball Joints............................ 306
Battery............................... 303
Emergency Starting.................... 282
Jump Starting........................ 282
Keyless Transmitter Replacement (RKE)..... 21
Location.........................282,303
Bearings.............................. 318
Belts, Drive........................... 300
Belts, Seat............................. 34
Body Mechanism Lubrication.............. 306
B-Pillar Location....................... 228
Brake Assist System..................... 220
Brake, Parking......................... 213
Brake System.......................214,313Anti-Lock (ABS)...................... 214
Fluid Check......................315,339
Hoses.............................. 314
Master Cylinder...................... 315
Parking............................ 213
Warning Light....................133,214
Brakes............................... 214
Brake/Transmission Interlock.............. 200
Break-In Recommendations, New Vehicle...... 59
Bulb Replacement...................... 331
Bulbs, Light........................... 330
Calibration, Compass.................... 142
Capacities, Fluid....................... 337
Caps, Filler
Fuel............................... 254
Oil (Engine)......................... 298
Radiator (Coolant Pressure).............. 310
Car Washes........................... 319
Carbon Monoxide Warning.............60,253
Cassette Tape and Player Maintenance....... 178
Catalytic Converter..................... 301
CD (Compact Disc) Player.............150,157
INDEX 371
10

Cellular Phone.......................... 69
Chains, Tire........................... 240
Changing A Flat Tire.................... 274
Chart, Tire Sizing....................... 225
Check Engine Light
(Malfunction Indicator Light).............. 293
Child Restraint.................51,52,53,55,57
Child Restraint Tether Anchors...........54,55
Child Safety Locks....................... 26
Clean Air Gasoline...................... 251
Cleaning
Wheels............................. 320
Climate Control........................ 180
Clock..........................152,158,169
Compact Disc (CD) Maintenance........... 179
Compact Spare Tire..................... 235
Compass............................. 142
Compass Calibration.................... 142
Compass Variance...................... 143
Computer, Trip/Travel................... 140
Console.............................. 120
Console, Floor......................... 120
Console, Overhead...................... 108Contract, Service....................... 364
Coolant Pressure Cap (Radiator Cap)........ 310
Cooling System........................ 308
Adding Coolant (Antifreeze)............. 310
Coolant Capacity..................... 337
Coolant Level.....................308,311
Disposal of Used Coolant............... 311
Drain, Flush, and Refill................. 309
Inspection........................... 311
Points to Remember................... 312
Pressure Cap........................ 310
Radiator Cap........................ 310
Selection of Coolant (Antifreeze)....309,337,338
Cruise Control (Speed Control)............. 105
Cruise Light........................... 129
Cup Holder........................ 119,322
Customer Assistance.................... 362
Data Recorder, Event..................... 49
Daytime Running Lights.................. 97
Dealer Service......................... 294
Defroster, Rear Window.................. 190
Defroster, Windshield...............61,181,186
372 INDEX

Materials Added to.................... 299
Recommendation..................297,337
Synthetic........................... 299
Viscosity.........................298,337
Onboard Diagnostic System............292,293
Opener, Garage Door (HomeLink) ......... 109
Operating Precautions................... 292
Outside Rearview Mirrors................. 67
Overdrive............................ 202
Overhead Console...................... 108
Overheating, Engine..................130,272
Owner’s Manual (Operator Manual)......... 365
Panic Alarm........................... 20
Parking Brake......................... 213
Parking On Hill........................ 213
Passing Light........................... 98
Pedals, Adjustable...................... 104
Personal Settings....................... 146
Pets.................................. 58
Phone, Cellular......................... 69
Phone, Hands-Free (UConnect™)............ 69
Placard, Tire and Loading Information....... 228Power
Brakes............................. 214
Distribution Center (Fuses).............. 323
Door Locks.......................... 24
Mirrors............................. 68
Outlet (Auxiliary Electrical Outlet)........ 117
Seats............................... 89
Steering.........................217,305
Steering, Checking.................... 305
Sunroof............................ 114
Windows............................ 28
Pregnant Women and Seat Belts............. 41
Preparation for Jacking................... 274
Pretensioners
Seat Belts............................ 39
Programmable Electronic Features..... 110,113,146
Programming Transmitters
(Remote Keyless Entry)..............21,110,113
Radial Ply Tires........................ 235
Radiator Cap (Coolant Pressure Cap)........ 310
Radio Broadcast Signals.................. 149
Radio, Navigation...................... 168
INDEX 379
10