2007 DODGE CARAVAN instrument cluster

NOTE:The driver’s side sliding door cannot be opened
while the fuel door is open. This feature operates only
when the sliding door is fully closed prior to opening the
fuel door.
As a reminder, a fuel icon with an arrow “
”
indicating which side of the vehicle the fuel filler
door is located on, is located in the instrument
cluster, just below the Fuel Gage.
The fuel tank filler tube has a restricting door about 2
inches (50 mm) inside the opening. If using a portable
fuel container, it should have a flexible nozzle long
enough to force open the restricting door.CAUTION!
Damage to the fuel system or emission control
system could result from using an improper fuel
tank filler tube cap (gas cap). A poorly fitting cap
could let impurities into the fuel system and may
cause the Malfunction Indicator Light (MIL) to turn
on due to fuel vapors escaping from the system.
CAUTION!
To avoid fuel spillage and overfilling, do not “top
off” the fuel tank after filling.
358 STARTING AND OPERATING

NOTE:When the fuel nozzle “clicks” or shuts off, the
fuel tank is full.
WARNING!
•Never have any smoking materials lit in or near
the vehicle when the gas cap is removed or the
tank filled.
•Never add fuel when the engine is running. This
is in violation of most state and federal fire
regulations and will cause the malfunction indi-
cator light to turn on.
NOTE:
•Tighten the fuel filler cap until you hear a “clicking”
sound. This is an indication that the fuel filler cap is
properly tightened.
•If the gas cap is not tighten properly, the Malfunction
Indicator Light will come on. Be sure the gas cap is
tightened every time the vehicle is refueled.
WARNING!
A fire may result if gasoline is pumped into a
portable container that is inside of a vehicle. You
could be burned. Always place gas containers on the
ground while filling.
Loose Fuel Filler Cap Message
•
If the vehicle diagnostic system determines that the
fuel filler cap is loose, improperly installed, or dam-
aged, GASCAP will be displayed in the instrument
cluster odometer. Tighten the fuel filler cap properly
and press the odometer reset button to turn the
GASCAP message off.
STARTING AND OPERATING 359
5

ONBOARD DIAGNOSTIC SYSTEM — OBD II
Your vehicle is equipped with a sophisticated onboard
diagnostic system called OBD II. This system monitors
the performance of the emissions, engine, and automatic
transmission control systems. When these systems are
operating properly, your vehicle will provide excellent
performance and fuel economy, as well as engine emis-
sions well within current government regulations.
If any of these systems require service, the OBD II system
will turn on the “Malfunction Indicator Light.” It will
also store diagnostic codes and other information to
assist your service technician in making repairs. Al-
though your vehicle will usually be drivable and not
need towing, see your dealer for service as soon as
possible.CAUTION!
•Prolonged driving with the “Malfunction Indica-
tor Light” on could cause further damage to the
emission control system. It could also affect fuel
economy and driveability. The vehicle must be
serviced before any emissions tests can be per-
formed.
•If the “Malfunction Indicator Light” is flashing
while the engine is running, severe catalytic con-
verter damage and power loss will soon occur.
Immediate service is required.
Loose Fuel Filler Cap Message
After fuel is added, the vehicle diagnostic system can
determine if the fuel filler cap is loose, improperly
installed, or damaged. A loose fuel filler cap message will
be displayed in the instrument cluster. Tighten the gas
416 MAINTAINING YOUR VEHICLE

equipped with electric defrosters or the right rear quarter
window equipped with the radio antenna. Do not use
scrapers or other sharp instruments which may scratch
the elements.
When cleaning the rear view mirror, spray cleaner on the
towel or rag that you are using. Do not spray cleaner
directly on the mirror.
Cleaning Plastic Instrument Cluster Lenses
The lenses in front of the instruments in this vehicle are
molded in clear plastic. When cleaning the lenses, care
must be taken to avoid scratching the plastic.
1. Clean with a wet soft rag. A mild soap solution may be
used, but do not use high alcohol content or abrasive
cleaners. If soap is used, wipe clean with a clean damp
rag.
2. Dry with a soft tissue.
Seat Belt Maintenance
Do not bleach, dye or clean the belts with chemical
solvents or abrasive cleaners. This will weaken the fabric.
Sun damage can also weaken the fabric.
If the belts need cleaning, use a mild soap solution or
lukewarm water. Do not remove the belts from the car to
wash them.
Replace the belts if they appear frayed or worn or if the
buckles do not work properly.
Cleaning The Instrument Panel and Underseat
Cup Holders
Removal
Remove the ash receiver from the convenience tray if
there is a smoker’s package in your vehicle. With your
index finger, locate the stop tab located at the rear of the
convenience tray.
450 MAINTAINING YOUR VEHICLE

The Heated Mirrors, Lower Instrument Panel Power
Outlet and Removable Floor Console, when in the front
position are fused with self resetting fuses that are only
serviceable by an authorized dealer. The power seats are
fused by a 30 Amp circuit breaker located under the
driver’s seat. The Power Windows are fused by a 25 Amp
circuit breaker located under the instrument panel near
the steering column. If you experience temporary or
permanent loss of these systems see your authorized
dealer for service.
VEHICLE STORAGE
If you are leaving your vehicle dormant for more than 21
days you may want to take steps to protect your battery.
You may:
•Remove the 20 Amp mini fuse in the Integrated Power
Module labeled Ignition-Off Draw (IOD).
•Or, disconnect the negative cable from the battery.
•Anytime you store your vehicle, or keep it out of
service (i.e. vacation) for two weeks or more, run the
air conditioning system at idle for about five minutes
in the fresh air and high blower setting. This will
insure adequate system lubrication to minimize the
possibility of compressor damage when the system is
started again.
REPLACEMENT LIGHT BULBS
LIGHT BULBS — Interior Bulb Number
Center & Rear Dome Light .................. 578
Center & Rear Reading Lights ............... 578
Front Door Courtesy Light .................. 578
Front Header Reading Lights — If Equipped ..... 578
Instrument Cluster Lights .................PC74
Liftgate Light(s) .......................... 578
Overhead Console Reading Lights ..........PC579
Removable Console Light — If Equipped ....... 194
Visor Vanity Lights .................... 6501966
MAINTAINING YOUR VEHICLE 455
7

Head Phones........................... 268
Head Restraints ......................... 125
Headlights ............................ 151
Bulb Replacement ...................... 456
High Beam/Low Beam Select Switch ........ 156
Lights On Reminder .................... 153
Replacing ............................ 456
Time Delay .......................... 154
Heated Seats ........................... 126
Heater ............................... 278
Heater, Engine Block ..................... 315
Hitches Trailer Towing ........................ 371
HomeLink (Garage Door Opener) Transmitter . . . 177
Hood Release .......................... 149
Hook, Coat ............................ 198
Hoses ............................. 439,442
Ignition ............................... 12 Key ................................. 12
Ignition Key Removal ..................... 12
Illuminated Entry ........................ 20
Immobilizer (Sentry Key) ................... 15
Indicator, Traction Control ................. 218
Infant Restraint ........................ 75,76
Information Center ...................... 172
Information Center, Vehicle ................. 172
Inside Rearview Mirror .................... 96
Instrument Cluster ................. 209,210,211
Instrument Panel and Controls .............. 208
Instrument Panel Lens Cleaning ............. 450
Integrated Child Seat ...................... 74
Integrated Power Module (Fuses) ............ 452
Interior Appearance Care .................. 448
Interior Lights ....................... 151,152
Intermittent Wipers (Delay Wipers) .....157,301,303
Introduction ............................. 4
INDEX 503
10

Headlights On Reminder................. 153
High Beam Indicator .................... 217
High Beam/Low Beam Select ............. 156
Illuminated Entry ....................... 20
Interior .......................... 151,152
License ............................. 461
Liftgate Ajar .......................... 212
Lights On Reminder .................... 153
Low Fuel ............................ 212
Malfunction Indicator (Check Engine) ........ 218
Oil Pressure .......................... 217
Park ............................. 151,458
Passing ............................. 156
Reading ............................. 168
Rear Servicing ........................ 459
Rear Tail ............................ 459
Seat Belt Reminder ..................... 215
Security Alarm (Theft Alarm) .............. 216
Service ........................... 455,456 Service Engine Soon (Malfunction Indicator) . . . 218
Side Marker
.......................... 459
Theft Alarm (Security Alarm) .............. 216
Turn Signal ..................... 155,458,459
Voltage ............................. 215
Warning (Instrument Cluster Description) ..... 211
Washer Fluid ......................... 217
Load Leveling System .................... 201
Loading Vehicle ................... 198,363,366
Capacities ........................... 366
Tires ............................... 332
Locks Door ................................ 27
Steering Wheel ......................... 14
Lower Anchors and Tether for CHildren (LATCH) . 79
Lubrication, Body ....................... 431
Luggage Rack (Roof Rack) ................. 199
Lumbar Support ........................ 128
INDEX 505
10

Transmitter Battery Service (Remote
Keyless Entry) ........................... 26
Transmitter, Garage Door Opener (HomeLink ) . . 177
Transmitter Programming (Remote
Keyless Entry) ........................... 23
Transmitter, Remote Keyless Entry (RKE) ........ 20
Transporting Pets ........................ 83
Tread Wear Indicators .................... 342
Trip Odometer .......................... 219
Trip Odometer Reset Button ................ 220
Turn Signals ................... 155,212,458,459
UConnect™ (Hands-Free Phone) ............. 100
Uniform Tire Quality Grades ................ 491
Universal Joints ......................... 431
Universal Transmitter ..................... 177
Unleaded Gasoline ....................... 353
Untwisting Procedure, Seat Belt .............. 53 Vanity Mirrors
........................... 99
Variance, Compass ....................... 170
Vehicle Certification Label ................. 364
Vehicle Identification Number (VIN) ............ 6
Vehicle Information Center ................. 172
Vehicle Loading ................... 333,363,366
Vehicle Modifications/Alterations .............. 7
Vehicle Storage ....................... 300,455
Video Entertainment System (Rear Seat
Video System) .......................... 259
Warning Flasher, Hazard .................. 384
Warning Lights (Instrument Cluster Description) . . 211
Warnings and Cautions ..................... 6
Warranty Information ..................... 489
Washer, Adding Fluid .................. 303,432
Washer, Rear ........................ 302,303
Washing Vehicle ......................... 447
Wheel Alignment and Balance ............... 344
INDEX 513
10