2007 DODGE CALIBER fuel filter

MAINTAINING YOUR VEHICLE
CONTENTS

Engine Compartment — Gasoline Engines...279

Onboard Diagnostic System — OBD II......280
▫Loose Fuel Filler Cap Message............280

Emissions Inspection And
Maintenance Programs
..................281

Replacement Parts.....................282

Dealer Service........................282

Maintenance Procedures.................283
▫Engine Oil..........................283
▫Drive Belt – Check Condition.............286
▫Spark Plugs.........................286
▫Catalytic Converter....................287▫Crankcase Emission Control System........288
▫Fuel Filter..........................288
▫Air Cleaner Element (Filter)..............288
▫Maintenance-Free Battery................289
▫Air Conditioner Maintenance.............290
▫Power Steering — Fluid Check............291
▫Front Suspension Ball Joints..............291
▫Body Lubrication.....................292
▫Windshield Wiper Blades................292
▫Windshield Washer Reservoir.............292
▫Exhaust System......................293
7

In unusual situations involving grossly malfunctioning
engine operation, a scorching odor may suggest severe
and abnormal catalyst overheating. If this occurs, stop
the vehicle, turn off the engine and allow it to cool.
Service, including a tune up to manufacturers specifica-
tions, should be obtained immediately.
To minimize the possibility of catalyst damage:
•Do not shut off the engine or interrupt the ignition
when the transaxle is in gear and the vehicle is in
motion.
•Do not try to start the engine by pushing or towing the
vehicle.
•Do not idle the engine with any spark plug wires
disconnected for prolonged period.
Crankcase Emission Control System
Proper operation of this system depends on freedom
from sticking or plugging due to deposits. As vehicle
mileage builds up, the PCV valve and passages may
accumulate deposits. If a valve is not working properly,
replace it with a new valve. DO NOT ATTEMPT TO
CLEAN THE OLD PCV VALVE!Check ventilation hose for indication of damage or
plugging deposits. Replace if necessary.
Fuel Filter
A plugged fuel filter can cause hard starting or limit the
speed at which a vehicle can be driven. Should an
excessive amount of dirt accumulate in the fuel tank,
frequent filter replacement may be necessary. The fuel
filters are located inside the fuel tank. See your dealer for
service.
Air Cleaner Element (Filter)
Under normal driving conditions, replace the filter at the
intervals shown on Schedule “A”. If, however, you drive
the vehicle frequently under dusty or severe conditions,
the filter element should be inspected periodically and
replaced if necessary at the intervals shown on Schedule
“B”.
288 MAINTAINING YOUR VEHICLE

FLUIDS AND CAPACITIES
U.S. Metric
Fuel (Approximate)13.5 Gallons 51.0 Liters
Engine Oil-With Filter
All Gasoline Engines (Use API Certified SAE 5W-20 Engine
Oil.)4.5 Quarts 4.26 Liters
Cooling System *
MoparAntifreeze/Coolant 5 Year/100,000 Miles Formula), or
equivalent.7.2 Quarts 6.8 Liters
* Includes heater and coolant recovery bottle filled to MAX level.
316 MAINTAINING YOUR VEHICLE

FLUIDS, LUBRICANTS AND GENUINE PARTS
Engine
Component Fluids, Lubricants and Genuine Parts
Engine Coolant MoparAntifreeze/Coolant 5 Year/100,000 Mile Formula HOAT (Hybrid Or-
ganic Additive Technology) or equivalent.
Engine Oil Use API Certified SAE 5W-20 Engine Oil. Refer to your engine oil filler cap
for correct SAE grade meeting DaimlerChrysler Material Standard MS-6395.
Engine Oil Filter Mopar04884900AB or equivalent.
Spark Plugs Refer to the Vehicle Emission Control Information label in the engine com-
partment.
Fuel Selection 87 Octane (R + M)/2
MAINTAINING YOUR VEHICLE 317
7

ABS (Anti-Lock Brake System)............. 220
Accelerator Pedal....................... 213
Adding Engine Coolant (Antifreeze)......... 295
Adding Fuel.......................... 252
Adding Washer Fluid.................108,133
Additives, Fuel........................ 250
Air Cleaner, Engine
(Engine Air Cleaner Filter)................ 288
Air Conditioner Maintenance.............. 290
Air Conditioning Controls................ 198
Air Conditioning, Operating Tips........... 203
Air Conditioning Refrigerant...........290,291
Air Conditioning System..............198,290
Air Pressure, Tires...................... 234
Airbag................................ 39
Airbag Deployment...................... 49
Airbag Light...................... 52,62,145
Airbag Maintenance...................... 51
Airbag, Side........................... 47
Alarm System (Security Alarm).......... 24,145
Alignment and Balance.................. 240
All Wheel Drive (AWD).................. 217
Alterations/Modifications, Vehicle............ 6Antenna, Satellite Radio.................. 195
Antifreeze (Engine Coolant).........294,316,317
Capacities........................... 316
Disposal............................ 296
Anti-Lock Brake System (ABS).......... 117,220
Anti-Theft Security Alarm (Theft Alarm)...... 24
Appearance Care....................... 303
Automatic Door Locks.................. 16,17
Automatic Transaxle........... 9,208,210,267,301
Fluid Level Check..................... 301
Interlock System.................... 14,212
Overheating......................... 267
Selection Of Lubricant................. 301
Shifting............................ 212
Special Additives..................... 301
Autostick ............................. 214
BallJoints ............................ 291
Battery ............................... 289
Keyless Transmitter Replacement (RKE)..... 23
Belts,Drive ........................... 286
Beverage Cooler........................ 134
Body Mechanism Lubrication.............. 292
346 INDEX

Engine Oil.......................... 286
Door Locks............................ 14
Door Locks, Automatic................... 16
Door Opener, Garage.................... 112
Downshifting.......................... 217
DriveBelts ............................ 286
Driver’s Seat Back Tilt.................... 96
Driving
On Slippery Surfaces.................. 224
Economy............................. 213
Electric Remote Mirrors................... 70
Electrical Power Outlets.................. 124
Electronic Brake Control System............ 118
Brake Assist System................... 118
Electronic Stability Program............. 119
Traction Control System................ 118
Electronic Speed Control (Cruise Control)..... 109
Electronic Stability Program (ESP).......... 119
Electronic Vehicle Information
Center (EVIC)......................... 152
Emergency, In Case of
Jacking............................. 268Jump Starting........................ 272
Towing ............................. 275
Emission Control System Maintenance....281,320
Engine............................... 279
Break-In Recommendations............... 61
Checking Oil Level.................... 283
Cooling ............................ 294
Exhaust Gas Caution.................. 251
Fuel Requirements.................... 248
Jump Starting........................ 272
Oil ..........................283,316,317
Oil Change Interval................... 284
Oil Filler Cap.....................279,285
Oil Filter............................ 317
OilSelection ......................... 285
Oil Synthetic......................... 285
Overheating......................... 266
Temperature Gauge................... 144
Enhanced Accident Response Feature......... 50
Event Data Recorder..................... 52
Exhaust Gas Caution............. 27,61,251,293
Exhaust System........................ 293
INDEX 349
10

Fabric Care........................... 305
Filler Location Fuel..................... 144
Filters
Air Cleaner.......................... 288
Engine Fuel......................... 288
Engine Oil.......................286,317
Flashers.............................. 266
Hazard Warning...................... 266
Turn Signal.......................... 312
Flat Tire Stowage....................... 271
Flooded Engine Starting.................. 209
Fluid, Brake........................... 318
Fluid Capacities........................ 316
Fluid Leaks............................ 63
Fluid Level Checks
Automatic Transaxle................... 301
Fluids ............................... 317
Fluids, Lubricants and Genuine Parts........ 317
FogLights ......................104,149,311
Fog Lights, Rear........................ 152
Folding Rear Seat....................... 99
Folding Rear Seat (Sedan)................. 99
FreeingAStuckVehicle .................. 274Fuel..............................248,317
Adding............................. 252
Additives ........................... 250
Capacity............................ 316
CleanAir ........................... 249
Filler Cap (Gas Cap)................144,252
Filler Door (Gas Cap).................. 144
Filter.............................. 288
Gasoline............................ 248
Gauge............................. 144
Hoses.............................. 298
Light .............................. 145
OctaneRating ........................ 248
Requirements........................ 248
System Hoses........................ 298
Tank Capacity........................ 316
Fuel System Caution.................... 254
Fueling .............................. 252
Fuses................................ 307
Garage Door Opener (HomeLink) .......... 112
Gas Cap (Fuel Filler Cap)...........252,253,280
Gasoline, Clean Air..................... 249
350 INDEX

Navigation Radio....................... 192
Navigation System...................... 192
New Vehicle Break-In Period............... 61
Occupant Classification System (OCS)........ 44
Occupant Restraints (Sedan)................ 28
Octane Rating, Gasoline (Fuel)............. 248
Odometer............................ 147
Trip ............................147,148
Oil, Engine.........................283,316
Capacity............................ 316
Change Interval...................... 284
Checking........................... 283
Disposal............................ 286
Filter.............................. 286
Identification Logo.................... 285
Materials Added to.................... 286
Recommendation..................285,316
Synthetic........................... 285
Viscosity............................ 285
Oil Pressure Light...................... 145
Onboard Diagnostic System............280,281
Opener, Garage Door (HomeLink) ......... 112Operator Manual (Owner’s Manual).......... 4
OutsideAirIntake ...................... 204
Overdrive............................ 213
Overheating, Engine..................... 266
Owner’s Manual (Operator Manual)....... 4,341
PaintCare ............................ 303
Panic Alarm........................... 21
Parking Brake......................... 218
Passing Light.......................... 106
Performance........................... 213
Personal Settings....................... 155
Pets .................................. 60
Phone, Cellular......................... 72
Phone, Hands-Free (UConnect™)............ 72
Placard, Tire and Loading Information....... 229
Power
Distribution Center (Fuses).............. 307
Door Locks.......................... 15
Mirrors ............................. 70
Outlet (Auxiliary Electrical Outlet)........ 124
Steering .........................223,291
Steering, Checking.................... 291
354 INDEX