2007 DODGE CALIBER manual transmission

WARNING!
Overfilling the brake fluid reservoir can result in
spilling brake fluid on hot engine parts and the
brake fluid catching fire.
Use only brake fluid that has been in a tightly closed
container to avoid contamination from foreign matter.
Do not allow petroleum based fluid to contaminate the
brake fluid as seal damage will result!
Automatic Transaxle (CVT)
Selection Of Lubricant
It is important that the proper lubricant is used in the
transaxle to assure optimum transaxle performance. Use
only the manufacturer’s recommended transmission
fluid which has been formulated with special metal to
metal friction coefficient additives to provide the proper
steel belt traction on the drive and driven pulleys. Refer
to Fluids, Lubricants and Genuine Parts for correct fluid
type.
CAUTION!
Using a transmission fluid other than the manufac-
turers recommended fluid will cause belt slip and
result in a complete transmission failure! Refer to
Fluids, Lubricants and Genuine Parts for correct
fluid type.
Fluid Level Check
The fluid level in the automatic transaxle should be
checked only by a trained technician.
Fluid and Filter Changes
Refer to the “Maintenance Schedule located if section 8 of
this manual for the correct change interval for your type
of driving.
Special Additives
Do not add any materials (other than leak detection dyes)
to Continuously Variable Transaxle (CVT) Fluid
(CVTF+4). CVTF+4 is an engineered product and its
performance may be impaired by supplemental addi-
tives.
MAINTAINING YOUR VEHICLE 301
7

Manual Transaxle
Lubricant Selection
Use only manufacturers recommended transmission
fluid. Refer to Fluids, Lubricants and Genuine Parts for
correct fluid type.
Fluid Level Check
Check the fluid level by removing the fill plug. The fluid
level should be between the bottom of the fill hole and a
point not more that 3/16” (4.7 mm) below the bottom of
the hole.
Add fluid, if necessary, to maintain the proper level.
Frequency Of Fluid Change
Under normal operating conditions, the fluid installed at
the factory will give satisfactory lubrication for the life of
the vehicle. Fluid changes are not necessary unless the
following conditions exist:
•The lubricant has become contaminated with water. If
contaminated with water, the fluid should be changed
immediately.
•If severe usage has occurred, refer to Maintenance
Schedule “B” in Section 8 of this manual.
Rear Drive Assembly (RDA )– AWD/4WD Models
Only
Lubricant Selection
Use only manufacturers recommended fluid. Refer to
Fluids, Lubricants and Genuine Parts for correct fluid
type.
Fluid Level Check
Visually inspected the unit at each oil change for leakage.
If leakage is detected, Check the fluid level by removing
the fill plug. The fluid level should be maintained be-
tween the bottom of the fill hole to 1/8 inch (4 mm)
below the fill hole.
Add fluid, if necessary, to maintain the proper level.
Frequency Of Fluid Change
Refer to the “Maintenance Schedule located if section 8 of
this manual for the correct change interval for your type
of driving.
302 MAINTAINING YOUR VEHICLE

•Check the fluid levels of coolant reservoir, brake/
clutch master cylinder, and manual transaxle and add
as needed.
•Check all lights and all other electrical items for correct
operation.
At Each Oil Change
•
Change the engine oil filter.
•Inspect the exhaust system.
•Inspect the brake hoses.
•Inspect the CV joints (if equipped) and front suspen-
sion components.
•Check the manual transmission fluid level (if
equipped).
•Check the coolant level, hoses, and clamps.
CAUTION!
Do not check the automatic transaxle fluid. It must
be check by a trained service technician every 15,000
miles and if required only the recommended fluid
be added. Refer to the section “Fluids, Lubricants
And Genuine Parts” for the proper fluid.
322 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Snow Tires............................ 247
Spare Tire.......................236,237,268
Spark Plugs........................... 286
Specifications
Oil ................................ 285
Speed Control (Cruise Control)..........109,148
Speedometer.......................... 144
Speedometer and Odometer............... 142
Starting .............................. 208
Automatic Transmission................ 208
Engine Fails to Start................... 209
Manual Transmission.................. 208
Starting Procedures..................... 208
Steering
Power...........................223,291
TiltColumn ......................... 108
Wheel Lock.......................... 13
Steering Wheel Mounted Sound
System Controls........................ 196
Storage.............................. 310
Stuck, Freeing......................... 274
Sun Roof............................. 122
Sun Visor Extension...................... 71Supplemental Restraint System - Airbag....... 39
Synthetic Engine Oil..................... 285
System, Navigation..................... 192
Tachometer........................... 144
Taillights............................. 312
Temperature Gauge, Engine Coolant......144,267
Tether Anchor, Child Restraint.............. 57
Theft Alarm (Security Alarm)............... 24
Theft System (Security Alarm).............. 24
Tie Down Hooks, Cargo.................. 130
TiltSteeringColumn .................... 108
Tire and Loading Information Placard....... 229
Tire Identification Number (TIN)........... 228
TireMarkings ......................... 225
TireSafetyInformation ................... 225
Tires ........................... 62,233,342
Aging(LifeofTires) ................... 239
Air Pressure......................... 233
Alignment.......................... 240
Chains............................. 247
Changing........................... 268
Compact Spare....................... 236
INDEX 357
10

Flat Changing........................ 271
General Information................... 233
High Speed......................... 235
Inflation Pressures.................... 234
Jacking............................. 268
LifeofTires ......................... 239
Load Capacity....................229,230
Pressure Monitor System (TPMS)......... 241
Quality Grading...................... 342
Radial............................. 236
Replacement......................... 239
Rotation ............................ 247
Safety ...........................225,233
Sizes ............................... 226
Snow Tires.......................... 247
Spare Tire........................... 268
Spinning ............................ 237
TreadWearIndicators .................. 238
Tongue Weight/Trailer Weight............. 258
Towing .............................. 255
Disabled Vehicle...................... 275
Guide .............................. 257
Recreational......................... 264Weight ............................. 257
Traction .............................. 224
TrailerTowing ......................... 255
Cooling System Tips................... 263
Hitches............................. 256
Minimum Requirements................ 259
Trailer and Tongue Weight.............. 258
Wiring............................. 262
TrailerTowingGuide .................... 257
TrailerWeight ......................... 257
Transaxle............................. 210
Automatic ................... 9,208,210,301
Autostick ........................... 214
Manual........................ 10,208,215
Operation........................... 210
Overdrive........................... 213
Selection of Lubricant.................. 301
Transmission
Range Indicator...................... 146
Transmitter Battery Service
(Remote Keyless Entry)................... 23
Transmitter, Garage Door
Opener (HomeLink) .................... 112
358 INDEX