2007 CHRYSLER PT CRUISER wheel

2007 Passenger Cars7
3/60 BASIC WARRANTY
If required because of a defect in material or workmanship, the 3/60
Basic Warranty will cover the adjustment, repair or replacement of
any factory-installed part of your vehicle except tires for 3 years or
60,000 kilometres, whichever occurs first. The following items are
exceptions; they are only covered (if defective) for 1 year or 20,000
kilometres, whichever occurs first:
light bulbs and fuses


brakes (rotors, pads, linings and drums)
windshield and rear window
wheel alignment and wheel balancing
Tires are warranted by the tire manu facturers, not by
DaimlerChrysler. For details, see the tire manu fac t urer’s warranty
booklet in your glovebox. Your DaimlerChrysler Retailer may be
able to assist you if you experience a problem with a factory-installed
tire.
Tires and spare tire should be replaced after six years, regardless
of the remaining tread. Failure to follow this warning can result
in sudden tire failure. You could lose control and have an accident
resulting in serious injury or death.
Your Koss headphones are warranted by the manufacturer,
not by DaimlerChrysler. For details, see the Koss manufacturer’s
warranty card in your glovebox.
3/60 BASIC WARRANTY

2007 Passenger Cars8
5/100 POWERTRAIN WARRANTY
The following powertrain components are covered for 5 years or
100,000 kilometres, whichever occurs first, measured from the
vehicle’s original warranty start date.
Vehicles placed in police, taxi, limousine, postal or ambulance
service and all SRT vehicles are excluded from the 5-year or
100,000-kilometre Powertrain Warranty and are covered only under
the 3-year or 60,000-kilometre Basic Warranty.

Engine – Cylinder block and all internal parts; cylinder head
assemblies; timing case, timing chain, timing belt, gears and
sprockets; vibration damper; oil pump; water pump and housing;
intake and exhaust manifolds; flywheel with starter ring gear; core
plugs; valve covers; oil pan; turbocharger housing and internal
parts; turbocharger wastegate actuator; supercharger; serpentine
belt tensioner; seals and gaskets for listed components only.

Transmission – Transmission case and all internal parts;
torque converter; drive/flex plate; transmission range switch;
transmission control module; bell housing; oil pan; seals and
gaskets for listed components only.

Note: Manual transmission clutch parts are not covered at any time.

Front-Wheel Drive – Transaxle case and all internal parts; axle
shaft assemblies; constant velocity joints and boots; differential
cover; oil pan; transaxle speed sensors; transaxle solenoid
assembly; PRNDL position switch; transaxle electronic controller;
torque converter; seals and gaskets for listed components only.

Note: Manual transmission clutch parts are not covered at any time.
5/100 POWERTRAIN WARRANTY

2007 Passenger Cars12
WHAT IS NOT COVERED
WHAT IS NOT COVERED
DAMAGE FROM MISUSE OR ACCIDENT
The warranties in this booklet do not cover repairs required
due to fire, accidents, abuse, negligence, objects striking your
vehicle, carrying corrosive materials (such as chemicals, acids
and fertilizers), misuse (such as driving over curbs, overloading,
spinning wheels, etc.), racing or participating in a racing event,
improper discon nection of components, modifying the exhaust
system, tampering or making adjustments which do not comply
with DaimlerChrysler specifications.
Disconnecting, tampering with or changing the reading of the
odometer will void your warranties.
DAMAGE FROM THE ENVIRONMENT
The warranties in this booklet do not cover fading or deterior ation
caused by exposure to the elements, or repairs required due to
airborne fallout, acid rain, chemicals, tree sap, insects, bird or
insect droppings, salt, sand, gravel, road hazards, hail, wind storms,
lightning, floods or any other event of nature. Road salt, car washes, scuffs and scratches, and everyday abrasion
from sand and dirt can affect the appearance of a vehicle’s wheels
(steel, chrome and aluminum) and other undercarriage parts. Some
surface corrosion with use is normal; it is not a defect and is not
covered by any warranty.
NORMAL MAINTENANCE AND WEAR
The warranties in this booklet do not cover normal
main tenance services, such as oil and filter changes, general
lubrication, tire rotation, engine tune-ups and replacing spark
plugs. Required maintenance services are described in detail in
your Owner’s Manual and herein. The warranties also do not
cover light bulbs and fuses, worn wiper blades, clutch discs, brake
rotors, pads, linings or drums, windshield and rear window, wheel
alignment and wheel balancing (unless they are defective, see
page 7).

2007 Passenger Cars
Retailer Copy
Remove and attach to Repair Order
26-92-02-01 3N.

Maintenance Service
Schedule “B”
Odometer Reading
Date
25,000 km Maintenance Service Schedule “B”
25,000 km
 Change engine oil and engine oil filter (or every 3 months, whichever occurs first).
 Inspect the engine air cleaner filter, replace if necessary (Sebring and PT Cruiser only).*
 Replace the engine air cleaner filter (Pacifica and Minivan only).
 Inspect and adjust the power steering pump belt tension (Caravan 2.4L engine only).
 Change the All-Wheel Drive (AWD) power transfer unit fluid (Pacifica only).
 Inspect the make-up air filter, replace if necessary (PT Cruiser only).*
 Inspect the generator belt on 2.4L engines, replace if necessary (Caravan only).
INSPECT THE FOLLOWING:
 Inspect the brake hoses.
 Inspect the CV joints and front and rear suspension components.
 Check the coolant level, hoses and clamps.
 Inspect the exhaust system.
 Check the manual transmission fluid level (if equipped) (Sebring only).
 Check the manual transaxle fluid level and fill plug condition (PT Cruiser only).
 Check the automatic transaxle fluid level (PT Cruiser only).
 Check the automatic transmission fluid level.
*This maintenance is recommended by the manufacturer, but not required to maintain the emissions
warranty.

2007 Passenger Cars
DAIMLERCHRYSLER
R
ETAILER STAMP
Signature of authorized DaimlerChrysler Canada Retailer
Odometer Reading
Date
Repair Order No.
 Change engine oil and engine oil filter (or every 3 months,
whichever occurs first).
 Inspect the engine air cleaner filter, replace if necessary
(Sebring and PT Cruiser only).*
 Replace the engine air cleaner filter (Pacifica and Minivan
only).
 Inspect and adjust the power steering pump belt tension
(Caravan 2.4L engine only).
 Change the All-Wheel Drive (AWD) power transfer unit
fluid (Pacifica only).
 Inspect the make-up air filter, replace if necessary
(PT Cruiser only).*
 Inspect the generator belt on 2.4L engines, replace if
necessary (Caravan only).
INSPECT THE FOLLOWING:
 Inspect the brake hoses.
 Inspect the CV joints and front and rear suspension
components.
 Check the coolant level, hoses and clamps.
 Inspect the exhaust system.
 Check the manual transmission fluid level (if equipped)
(Sebring only).
 Check the manual transaxle fluid level and fill plug
condition (PT Cruiser only).
 Check the automatic transaxle fluid level (PT Cruiser only).
 Check the automatic transmission fluid level.
*This maintenance is recommended by the manufacturer, but not required to
maintain the emissions warranty.
Maintenance Service Schedule “B”
25,000 km

2007 Passenger Cars
Retailer Copy
Remove and attach to Repair Order
26-92-02-01 3N.

Maintenance Service
Schedule “B”
Odometer Reading
Date
35,000 km Maintenance Service Schedule “B”
35,000 km
 Change engine oil and engine oil filter (or every 3 months, whichever occurs first).
 Inspect the engine air cleaner filter, replace if necessary (Pacifica and Minivan only).
 Change the All-Wheel Drive (AWD) rear carrier fluid (Pacifica only).
INSPECT THE FOLLOWING:
 Inspect the brake hoses.
 Inspect the CV joints and front and rear suspension components.
 Check the coolant level, hoses and clamps.
 Inspect the exhaust system.
 Check the manual transmission fluid level (if equipped) (Sebring only).
 Check the manual transaxle fluid level and fill plug condition (PT Cruiser only).
 Check the automatic transaxle fluid level (PT Cruiser only).
 Check the automatic transmission fluid level.

2007 Passenger Cars
DAIMLERCHRYSLER
R
ETAILER STAMP
Signature of authorized DaimlerChrysler Canada Retailer
Odometer Reading
Date
Repair Order No.
 Change engine oil and engine oil filter (or every 3 months,
whichever occurs first).
 Inspect the engine air cleaner filter, replace if necessary
(Pacifica and Minivan only).
 Change the All-Wheel Drive (AWD) rear carrier fluid
(Pacifica only).
INSPECT THE FOLLOWING:
 Inspect the brake hoses.
 Inspect the CV joints and front and rear suspension
components.
 Check the coolant level, hoses and clamps.
 Inspect the exhaust system.
 Check the manual transmission fluid level (if equipped)
(Sebring only).
 Check the manual transaxle fluid level and fill plug
condition (PT Cruiser only).
 Check the automatic transaxle fluid level (PT Cruiser
only).
 Check the automatic transmission fluid level.Maintenance Service Schedule “B”
35,000 km

2007 Passenger Cars
Retailer Copy
Remove and attach to Repair Order
26-92-02-01 3N.

Maintenance Service
Schedule “B”
Odometer Reading
Date
50,000 km Maintenance Service Schedule “B”
50,000 km
 Change engine oil and engine oil filter (or every 3 months, whichever occurs first).
 Replace the engine air cleaner filter (All models).*
 Inspect and adjust the power steering pump belt tension (Caravan 2.4L engine only).
 Replace the spark plugs and ignition cables (PT Cruiser and Caravan 2.4L engines only).
 Replace the spark plugs (2.4L Sebring only).
 Inspect the PCV valve and replace if necessary (PT Cruiser, Pacifica and Minivan only).*
‡
 Change the All-Wheel Drive (AWD) power transfer unit fluid (Pacifica only).
 Replace the make-up air filter (PT Cruiser only).
 Adjust the generator drive belt tension (PT Cruiser only).
 Inspect the generator belt on 2.4L engines, replace if necessary (Caravan only).
 Check spare tire for proper pressure and correct stowage.
 Rotate tires and check tire pressure.
INSPECT THE FOLLOWING: Inspect the brake hoses.
 Inspect the CV joints and front and rear suspension components.
 Check the coolant level, hoses and clamps.
 Inspect the exhaust system.
 Inspect the tie rod ends and boot seals (PT Cruiser, Pacifica and Minivan only).
 Check the manual transmission fluid level (if equipped) (Sebring only).
 Check the manual transaxle fluid level and fill plug condition (PT Cruiser only).
 Check the automatic transaxle fluid level (PT Cruiser only).
 Check the automatic transmission fluid level.
*This maintenance is recommended by the manufacturer, but not required to maintain the emissions warranty.‡This maintenance is not required if previously replaced.