2007 CHRYSLER PT CRUISER engine

2007 Passenger Cars8
5/100 POWERTRAIN WARRANTY
The following powertrain components are covered for 5 years or
100,000 kilometres, whichever occurs first, measured from the
vehicle’s original warranty start date.
Vehicles placed in police, taxi, limousine, postal or ambulance
service and all SRT vehicles are excluded from the 5-year or
100,000-kilometre Powertrain Warranty and are covered only under
the 3-year or 60,000-kilometre Basic Warranty.

Engine – Cylinder block and all internal parts; cylinder head
assemblies; timing case, timing chain, timing belt, gears and
sprockets; vibration damper; oil pump; water pump and housing;
intake and exhaust manifolds; flywheel with starter ring gear; core
plugs; valve covers; oil pan; turbocharger housing and internal
parts; turbocharger wastegate actuator; supercharger; serpentine
belt tensioner; seals and gaskets for listed components only.

Transmission – Transmission case and all internal parts;
torque converter; drive/flex plate; transmission range switch;
transmission control module; bell housing; oil pan; seals and
gaskets for listed components only.

Note: Manual transmission clutch parts are not covered at any time.

Front-Wheel Drive – Transaxle case and all internal parts; axle
shaft assemblies; constant velocity joints and boots; differential
cover; oil pan; transaxle speed sensors; transaxle solenoid
assembly; PRNDL position switch; transaxle electronic controller;
torque converter; seals and gaskets for listed components only.

Note: Manual transmission clutch parts are not covered at any time.
5/100 POWERTRAIN WARRANTY

2007 Passenger Cars12
WHAT IS NOT COVERED
WHAT IS NOT COVERED
DAMAGE FROM MISUSE OR ACCIDENT
The warranties in this booklet do not cover repairs required
due to fire, accidents, abuse, negligence, objects striking your
vehicle, carrying corrosive materials (such as chemicals, acids
and fertilizers), misuse (such as driving over curbs, overloading,
spinning wheels, etc.), racing or participating in a racing event,
improper discon nection of components, modifying the exhaust
system, tampering or making adjustments which do not comply
with DaimlerChrysler specifications.
Disconnecting, tampering with or changing the reading of the
odometer will void your warranties.
DAMAGE FROM THE ENVIRONMENT
The warranties in this booklet do not cover fading or deterior ation
caused by exposure to the elements, or repairs required due to
airborne fallout, acid rain, chemicals, tree sap, insects, bird or
insect droppings, salt, sand, gravel, road hazards, hail, wind storms,
lightning, floods or any other event of nature. Road salt, car washes, scuffs and scratches, and everyday abrasion
from sand and dirt can affect the appearance of a vehicle’s wheels
(steel, chrome and aluminum) and other undercarriage parts. Some
surface corrosion with use is normal; it is not a defect and is not
covered by any warranty.
NORMAL MAINTENANCE AND WEAR
The warranties in this booklet do not cover normal
main tenance services, such as oil and filter changes, general
lubrication, tire rotation, engine tune-ups and replacing spark
plugs. Required maintenance services are described in detail in
your Owner’s Manual and herein. The warranties also do not
cover light bulbs and fuses, worn wiper blades, clutch discs, brake
rotors, pads, linings or drums, windshield and rear window, wheel
alignment and wheel balancing (unless they are defective, see
page 7).

2007 Passenger Cars16
OTHER THINGS YOU SHOULD KNOW
OTHER THINGS YOU SHOULD KNOW
OPTIONAL SERVICE CONTRACT
DaimlerChrysler Canada has a service contract specially designed
for most new vehicles, to cover repair costs beyond your vehicle’s
warranty. Protection is available for almost every operating part of
your vehicle, and at reasonable cost.
DaimlerChrysler Canada stands fully behind its service
contracts. Be sure that the contract you buy is a genuine
DaimlerChrysler Service Contract. We are not responsible for
other companies’ contracts. See page 24 for details on available
service contracts.
APPEARANCE ITEMS
Defects or damage to sheet metal, paint, trim and other appearance
items are normally found and corrected during new vehicle
inspection. For your protection, if you find any such defect or
damage, you should tell your selling retailer immediately, because
if the problem worsens due to use and exposure, repairs will not be
covered by any warranty.
PRODUCTION CHANGES
DaimlerChrysler Canada and its retailers reserve the right to make
changes in vehicles built and/or sold at any time without in cur ring
any obligations to make the same or similar changes on vehicles
which were built and/or sold previously.
EXCHANGE PARTS
To reduce the amount of time your vehicle is out of service due
to repairs, DaimlerChrysler may offer exchange service on some
parts. Mopar
® or Autopar® brand exchange parts may be new,
remanufactured, reconditioned or repaired, but all meet
DaimlerChrysler standards and are warranted the same as new
parts. Examples of parts that may be serviced by exchange include
engines, transmissions, instrument clusters, radios, tape and CD
players, speedometers and various electronic modules.

MAINTENANCE Scheduled maintenance must be completed to provide the best vehicle
performance and reliability. The limited warranties in the warranty booklet DO NOT COVER repairs required due to improper maintenance. We strongly suggest you keep track of scheduled maintenance and keep receipts or other documents. Use only recommended Mopar Lubricants and genuine Mopar® Parts. In the event that a condition arises between maintenance intervals, please contact your retailer. avoid prolonged periods of idling.
noTe:
WHere TiMe (MonTHs) and MeTrage are indiCa Ted, folloW THe inTerval
THa T oCCUrs firsT.
aT ea CH sT op for f U el
•
Check the engine oil level about 5 minutes after
a fully warmed engine is shut off. Checking the oil level while the vehicle is on level ground will improve the accuracy of the oil level reading. Add oil only when the level is at or below the ADD or MIN mark.
•
Check the windshield washer solvent and add if required.
onCe a M on TH
•
Check the tire pressure and look for unusual
wear or damage.
•
Inspect the battery and clean and tighten the
terminals as required.
•
Check the fluid levels of coolant reservoir, brake
master cylinder, power steering and transmission and add as needed.
•
Check all the lights and all other electrical items
for correct operation.
•
Check rubber seals on each side of the radiator
for proper fit.
•
Check and clean wiper blades. Replace if required.
VISUAL INSPECTIONS – INSPECT FOR SIGNS OF COMPONENT DETERIORATION AND PHYSICAL DAMAGE.
There are two maintenance schedules contained in your Owner’s Manual. Schedule “B” best
describes operating cond itions in Canada and
is the reco mmended service schedule. For
your convenience, the scheduled maintenance intervals outlined in this booklet follow the Severe Service Schedule as described in your Owner’s Manual. Schedule “B” is for vehicles that are operated under one or more of the following conditions: day or night tempera­
tures are below 0°C (32°F); stop ­and ­go
driving; extensive engine idling; driving in dusty conditions; short trips of less than 16.2
km (10 mi.); more than 50% of your driving is at sustained high speeds during hot weather, above 32°C (90°F); trailer towing; taxi, police, or
delivery service (commercial service); off ­road
or desert driving; if equipped for and operating
with E ­85 (ethanol) fuel. Schedule “A” is for
vehicles that are not operated under any of the conditions listed under Schedule “B.”The performance of all scheduled service work is required to maintain your vehicle in good operating condition. DaimlerChrysler Canada Inc. reserves the right to deny warranty coverage if the vehicle has not been properly maintained. While we do not insist that such
work be performed by factory ­authorized
retailers, we strongly recommend that an authorized Chrysler, Jeep® or Dodge Retailer perform this work.
i
n Trod UCTion

2007 Passenger Cars
Maintenance Service
Schedule “B”
Odometer Reading
Date
Retailer Copy
Remove and attach to Repair Order
26-92-02-01 3N.

Maintenance Service Schedule “B”
5000 km
 Change engine oil and engine oil filter (or every 3 months, whichever occurs first).  Inspect the engine air cleaner filter, replace if necessary (Pacifica and Minivan only).
INSPECT THE FOLLOWING:
 Inspect the brake hoses.
 Inspect the CV joints and front and rear suspension components.
 Check the coolant level, hoses and clamps.
 Inspect the exhaust system.
 Check the manual transmission fluid level (if equipped) (Sebring only).
 Check the manual transaxle fluid level and fill plug condition (PT Cruiser only).
 Check the automatic transaxle fluid level (PT Cruiser only).
 Check the automatic transmission fluid level.
5000 km

2007 Passenger Cars
DAIMLERCHRYSLER
R
ETAILER STAMP
Signature of authorized DaimlerChrysler Canada Retailer
 Change engine oil and engine oil filter (or every 3 months,
whichever occurs first).
 Inspect the engine air cleaner filter, replace if necessary
(Pacifica and Minivan only).
INSPECT THE FOLLOWING:
 Inspect the brake hoses.
 Inspect the CV joints and front and rear suspension
components.
 Check the coolant level, hoses and clamps.
 Inspect the exhaust system.
 Check the manual transmission fluid level (if equipped)
(Sebring only).
 Check the manual transaxle fluid level and fill plug
condition (PT Cruiser only).
 Check the automatic transaxle fluid level (PT Cruiser
only).
 Check the automatic transmission fluid level.
Odometer Reading
Date
Repair Order No.
Maintenance Service Schedule “B”
5000 km

2007 Passenger Cars
Retailer Copy
Remove and attach to Repair Order
26-92-02-01 3N.

Maintenance Service
Schedule “B”
Odometer Reading
Date
Maintenance Service Schedule “B”
10,000 km
 Change engine oil and engine oil filter (or every 3 months, whichever occurs first).
 Inspect the engine air cleaner filter, replace if necessary (Pacifica and Minivan only).
 Check spare tire for proper pressure and correct stowage.
 Rotate tires and check tire pressure.
INSPECT THE FOLLOWING:

 Inspect the brake hoses.
 Inspect the CV joints and front and rear suspension components.
 Check the coolant level, hoses and clamps.
 Inspect the exhaust system.
 Check the manual transmission fluid level (if equipped) (Sebring only).
 Check the manual transaxle fluid level and fill plug condition (PT Cruiser only).
 Check the automatic transaxle fluid level (PT Cruiser only).
 Check the automatic transmission fluid level.10,000 km

2007 Passenger Cars
DAIMLERCHRYSLER
R
ETAILER STAMP
Signature of authorized DaimlerChrysler Canada Retailer
Odometer Reading
Date
Repair Order No.
 Change engine oil and engine oil filter (or every 3 months,
whichever occurs first).
 Inspect the engine air cleaner filter, replace if necessary
(Pacifica and Minivan only).
 Check spare tire for proper pressure and correct stowage.
 Rotate tires and check tire pressure.
INSPECT THE FOLLOWING:
 Inspect the brake hoses.
 Inspect the CV joints and front and rear suspension
components.
 Check the coolant level, hoses and clamps.
 Inspect the exhaust system.
 Check the manual transmission fluid level (if
equipped) (Sebring only).
 Check the manual transaxle fluid level and fill plug
condition (PT Cruiser only).
 Check the automatic transaxle fluid level (PT Cruiser
only).
 Check the automatic transmission fluid level.
Maintenance Service Schedule “B”
10,000 km