2007 CHRYSLER PT CRUISER boot

2007 Passenger Cars8
5/100 POWERTRAIN WARRANTY
The following powertrain components are covered for 5 years or
100,000 kilometres, whichever occurs first, measured from the
vehicle’s original warranty start date.
Vehicles placed in police, taxi, limousine, postal or ambulance
service and all SRT vehicles are excluded from the 5-year or
100,000-kilometre Powertrain Warranty and are covered only under
the 3-year or 60,000-kilometre Basic Warranty.

Engine – Cylinder block and all internal parts; cylinder head
assemblies; timing case, timing chain, timing belt, gears and
sprockets; vibration damper; oil pump; water pump and housing;
intake and exhaust manifolds; flywheel with starter ring gear; core
plugs; valve covers; oil pan; turbocharger housing and internal
parts; turbocharger wastegate actuator; supercharger; serpentine
belt tensioner; seals and gaskets for listed components only.

Transmission – Transmission case and all internal parts;
torque converter; drive/flex plate; transmission range switch;
transmission control module; bell housing; oil pan; seals and
gaskets for listed components only.

Note: Manual transmission clutch parts are not covered at any time.

Front-Wheel Drive – Transaxle case and all internal parts; axle
shaft assemblies; constant velocity joints and boots; differential
cover; oil pan; transaxle speed sensors; transaxle solenoid
assembly; PRNDL position switch; transaxle electronic controller;
torque converter; seals and gaskets for listed components only.

Note: Manual transmission clutch parts are not covered at any time.
5/100 POWERTRAIN WARRANTY

2007 Passenger Cars
Retailer Copy
Remove and attach to Repair Order
26-92-02-01 3N.

Maintenance Service
Schedule “B”
Odometer Reading
Date
50,000 km Maintenance Service Schedule “B”
50,000 km
 Change engine oil and engine oil filter (or every 3 months, whichever occurs first).
 Replace the engine air cleaner filter (All models).*
 Inspect and adjust the power steering pump belt tension (Caravan 2.4L engine only).
 Replace the spark plugs and ignition cables (PT Cruiser and Caravan 2.4L engines only).
 Replace the spark plugs (2.4L Sebring only).
 Inspect the PCV valve and replace if necessary (PT Cruiser, Pacifica and Minivan only).*
‡
 Change the All-Wheel Drive (AWD) power transfer unit fluid (Pacifica only).
 Replace the make-up air filter (PT Cruiser only).
 Adjust the generator drive belt tension (PT Cruiser only).
 Inspect the generator belt on 2.4L engines, replace if necessary (Caravan only).
 Check spare tire for proper pressure and correct stowage.
 Rotate tires and check tire pressure.
INSPECT THE FOLLOWING: Inspect the brake hoses.
 Inspect the CV joints and front and rear suspension components.
 Check the coolant level, hoses and clamps.
 Inspect the exhaust system.
 Inspect the tie rod ends and boot seals (PT Cruiser, Pacifica and Minivan only).
 Check the manual transmission fluid level (if equipped) (Sebring only).
 Check the manual transaxle fluid level and fill plug condition (PT Cruiser only).
 Check the automatic transaxle fluid level (PT Cruiser only).
 Check the automatic transmission fluid level.
*This maintenance is recommended by the manufacturer, but not required to maintain the emissions warranty.‡This maintenance is not required if previously replaced.

2007 Passenger Cars
DAIMLERCHRYSLER
R
ETAILER STAMP
Signature of authorized DaimlerChrysler Canada Retailer
Odometer Reading
Date
Repair Order No.  Change engine oil and engine oil filter (or every 3 months,
whichever occurs first).
 Replace the engine air cleaner filter (All models).*
 Inspect and adjust the power steering pump belt tension (Caravan
2.4L engine only).
 Replace the spark plugs and ignition cables (PT Cruiser and Caravan
2.4L engines only).
 Replace the spark plugs (2.4L Sebring only).
 Inspect the PCV valve and replace if necessary (PT Cruiser, Pacifica
and Minivan only).*‡ Change the All-Wheel Drive (AWD) power transfer unit fluid
(Pacifica only).
 Replace the make-up air filter (PT Cruiser only).
 Adjust the generator drive belt tension (PT Cruiser only).
 Inspect the generator belt on 2.4L engines, replace if necessary
(Caravan only).
 Check spare tire for proper pressure and correct stowage.
 Rotate tires and check tire pressure.
INSPECT THE FOLLOWING:
 Inspect the brake hoses.
 Inspect the CV joints and front and rear suspension components.
 Check the coolant level, hoses and clamps.
 Inspect the exhaust system.
 Inspect the tie rod ends and boot seals (PT Cruiser, Pacifica and
Minivan only).
 Check the manual transmission fluid level (if equipped) (Sebring only).
 Check the manual transaxle fluid level and fill plug condition (PT
Cruiser only).
 Check the automatic transaxle fluid level (PT Cruiser only).
 Check the automatic transmission fluid level.
*This maintenance is recommended by the manufacturer, but not required to
maintain the emissions warranty.
‡This maintenance is not required if previously replaced.
Maintenance Service Schedule “B”
50,000 km

2007 Passenger Cars
Retailer Copy
Remove and attach to Repair Order
26-92-02-01 3N.

Maintenance Service
Schedule “B”
Odometer Reading
Date
100,000 km
Maintenance Service Schedule “B”
100,000 km
 Change engine oil and engine oil filter (or every 3 months, whichever occurs first).
 Replace the engine air cleaner filter (All models).*
 Replace the air conditioning filter (Pacifica and Minivan only).
 Inspect and adjust the power steering pump belt tension (Caravan 2.4L engine only).
 Replace the spark plugs and ignition cables (PT Cruiser and Caravan 2.4L engines only).
 Replace the spark plugs (2.4L Sebring only).
 Inspect the PCV valve and replace if necessary (Pacifica and Minivan only).*
‡ Replace the make-up air filter (PT Cruiser only).
 Inspect the serpentine drive belt, replace if necessary (Town & Country/Caravan 3.3L and 3.8L engines and
Pacifica only).
‡ Adjust the generator drive belt tension (PT Cruiser only).
 Inspect the generator belt on 2.4L engines, replace if necessary (Caravan only).
 Change the automatic transaxle fluid and filter (All models).
† Flush and replace engine coolant at 60 months or 170,000 kilometres, whichever comes first (All models).
 Check spare tire for proper pressure and correct stowage.
 Rotate tires and check tire pressure.
INSPECT THE FOLLOWING: Inspect the front and rear brake linings and rotors (PT Cruiser only).
 Inspect the brake hoses.
 Inspect the CV joints and front and rear suspension components.
 Check the coolant level, hoses and clamps.
 Inspect the exhaust system.
 Inspect the tie rod ends and boot seals (PT Cruiser, Pacifica and Minivan only).
 Check the manual transmission fluid level (if equipped) (Sebring only).
 Check the manual transaxle fluid level and fill plug condition (PT Cruiser only).
 Check the automatic transaxle fluid level (PT Cruiser only).
 Check the automatic transmission fluid level.
*This maintenance is recommended by the manufacturer, but not required to maintain the emissions warranty.†This maintenance is required only for police, taxi, limousine type operation, or trailer towing.‡This maintenance is not required if previously replaced.

2007 Passenger Cars
DAIMLERCHRYSLER
R
ETAILER STAMP
Signature of authorized DaimlerChrysler Canada Retailer
Odometer Reading
Date
Repair Order No.
Maintenance Service Schedule “B”
100,000 km Change engine oil and engine oil filter (or every 3 months, whichever occurs first).
 Replace the engine air cleaner filter (All models).*
 Replace the air conditioning filter (Pacifica and Minivan only).
 Inspect and adjust the power steering pump belt tension (Caravan 2.4L engine
only).
 Replace the spark plugs and ignition cables (PT Cruiser and Caravan 2.4L
engines only).
 Replace the spark plugs (2.4L Sebring only).
 Inspect the PCV valve and replace if necessary (Pacifica and Minivan only).*
‡ Replace the make-up air filter (PT Cruiser only).
 Inspect the serpentine drive belt, replace if necessary (Town & Country/Caravan
3.3L and 3.8L engines and Pacifica only).
‡ Adjust the generator drive belt tension (PT Cruiser only).
 Inspect the generator belt on 2.4L engines, replace if necessary (Caravan only).
 Change the automatic transaxle fluid and filter (All models).
† Flush and replace engine coolant at 60 months or 170,000 kilometres,
whichever comes first (All models).
 Check spare tire for proper pressure and correct stowage.
 Rotate tires and check tire pressure.
INSPECT THE FOLLOWING: Inspect the front and rear brake linings and rotors (PT Cruiser only).
 Inspect the brake hoses.
 Inspect the CV joints and front and rear suspension components.
 Check the coolant level, hoses and clamps.
 Inspect the exhaust system.
 Inspect the tie rod ends and boot seals (PT Cruiser, Pacifica and Minivan only).
 Check the manual transmission fluid level (if equipped) (Sebring only).
 Check the manual transaxle fluid level and fill plug condition (PT Cruiser only).
 Check the automatic transaxle fluid level (PT Cruiser only).
 Check the automatic transmission fluid level.
*This maintenance is recommended by the manufacturer, but not required to maintain the
emissions warranty.
†This maintenance is required only for police, taxi, limousine type operation, or trailer towing.‡This maintenance is not required if previously replaced.

Retailer Copy
Remove and attach to Repair Order
26-92-02-01 3N.

Maintenance Service
Schedule “B”
Odometer Reading
Date
150,000 km Maintenance Service Schedule “B”
150,000 km
 Change engine oil and engine oil filter (or every 3 months, whichever occurs first).
 Replace the engine air cleaner filter (All models).*
 Inspect and adjust the power steering pump belt tension (Caravan 2.4L engine only).
 Replace the spark plugs and ignition cables (PT Cruiser and Caravan 2.4L engines only).
 Replace the spark plugs (2.4L Sebring only).
 Inspect the PCV valve and replace if necessary (PT Cruiser, Pacifica and Minivan only).*
‡
 Change the All-Wheel Drive (AWD) power transfer unit fluid (Pacifica only).
 Replace the make-up air filter (PT Cruiser only).
 Inspect the serpentine drive belt, replace if necessary (Town & Country/Caravan 3.3L and 3.8L
engines and Pacifica only).
‡
 Adjust the generator drive belt tension (PT Cruiser only).
 Inspect the generator belt on 2.4L engines, replace if necessary (Caravan only).
 Check spare tire for proper pressure and correct stowage.
 Rotate tires and check tire pressure.
INSPECT THE FOLLOWING: Inspect the front and rear brake linings and rotors (Sebring, Pacifica and Minivan only).
 Inspect the brake hoses.
 Inspect the CV joints and front and rear suspension components.
 Check the coolant level, hoses and clamps.
 Inspect the exhaust system.
 Inspect the tie rod ends and boot seals (PT Cruiser, Pacifica and Minivan only).
 Check the manual transmission fluid level (if equipped) (Sebring only).
 Check the manual transaxle fluid level and fill plug condition (PT Cruiser only).
 Check the automatic transaxle fluid level (PT Cruiser only).
 Check the automatic transmission fluid level.
*This maintenance is recommended by the manufacturer, but not required to maintain the emissions warranty.‡This maintenance is not required if previously replaced.

2007 Passenger Cars
DAIMLERCHRYSLER
R
ETAILER STAMP
Signature of authorized DaimlerChrysler Canada Retailer
Odometer Reading
Date
Repair Order No.
 Change engine oil and engine oil filter (or every 3 months, whichever
occurs first).
 Replace the engine air cleaner filter (All models).*
 Inspect and adjust the power steering pump belt tension (Caravan 2.4L
engine only).
 Replace the spark plugs and ignition cables (PT Cruiser and Caravan 2.4L
engines only).
 Replace the spark plugs (2.4L Sebring only).
 Inspect the PCV valve and replace if necessary (PT Cruiser, Pacifica and
Minivan only).*
‡ Change the All-Wheel Drive (AWD) power transfer unit fluid (Pacifica only).
 Replace the make-up air filter (PT Cruiser only).
 Inspect the serpentine drive belt, replace if necessary (Town & Country/
Caravan 3.3L and 3.8L engines and Pacifica only).
‡ Adjust the generator drive belt tension (PT Cruiser only).
 Inspect the generator belt on 2.4L engines, replace if necessary (Caravan
only).
 Check spare tire for proper pressure and correct stowage.
 Rotate tires and check tire pressure.
INSPECT THE FOLLOWING: Inspect the front and rear brake linings and rotors (Sebring, Pacifica and
Minivan only).
 Inspect the brake hoses.
 Inspect the CV joints and front and rear suspension components.
 Check the coolant level, hoses and clamps.
 Inspect the exhaust system.
 Inspect the tie rod ends and boot seals (PT Cruiser, Pacifica and Minivan
only).
 Check the manual transmission fluid level (if equipped) (Sebring only). Check the manual transaxle fluid level and fill plug condition (PT Cruiser
only).
 Check the automatic transaxle fluid level (PT Cruiser only).
 Check the automatic transmission fluid level.
*This maintenance is recommended by the manufacturer, but not required to
maintain the emissions warranty.
‡This maintenance is not required if previously replaced.
Maintenance Service Schedule “B”
150,000 km

Retailer Copy
Remove and attach to Repair Order
26-92-02-01 3N.

Maintenance Service
Schedule “B”
Odometer Reading
Date
200,000 km Maintenance Service Schedule “B”
200,000 km
 Change engine oil and engine oil filter (or every 3 months, whichever occurs first).
 Replace the engine air cleaner filter (All models).*
 Replace the air conditioning filter (Pacifica and Minivan only).
 Inspect and adjust the power steering pump belt tension (Caravan 2.4L engine only).
 Replace the spark plugs and ignition cables (PT Cruiser and Caravan 2.4L engines only).
 Replace the spark plugs (2.4L Sebring only).
 Inspect the PCV valve and replace if necessary (PT Cruiser, Pacifica and Minivan only).*
‡ Change the All-Wheel Drive (AWD) power transfer unit fluid (Pacifica only).
 Replace the make-up air filter (PT Cruiser only).
 Inspect the serpentine drive belt, replace if necessary (Town & Country/Caravan 3.3L and 3.8L engines and
Pacifica only).
‡ Replace the accessory drive belt every 200,000 km (Sebring only).
 Adjust the generator drive belt tension (PT Cruiser only).
 Inspect the generator belt on 2.4L engines, replace if necessary (Caravan only).
 Change the automatic transaxle fluid and filter (All models).
† Flush and replace engine coolant at 120 months if not done at 170,000 kilometres.
 Check spare tire for proper pressure and correct stowage.
 Rotate tires and ch
eck tire pressure.
INSPECT THE FOLLOWING: Inspect the brake hoses.
 Inspect the CV joints and front and rear suspension components.
 Check the coolant level, hoses and clamps.
 Inspect the exhaust system.
 Inspect the tie rod ends and boot seals (PT Cruiser, Pacifica and Minivan only).
 Check the manual transmission fluid level (if equipped) (Sebring only).
 Check the manual transaxle fluid level and fill plug condition (PT Cruiser only).
 Check the automatic transaxle fluid level (PT Cruiser only).
 Check the automatic transmission fluid level.
*This maintenance is recommended by the manufacturer, but not required to maintain the emissions warranty.†This maintenance is required only for police, taxi, limousine type operation, or trailer towing.‡This maintenance is not required if previously replaced.