2007 CHRYSLER PT CRUISER tow

Cavity Cartridge
FuseMini
FuseDescription
1 40 Amp
GreenPower Top Feed Ð
Convertible Only
2 20 Amp
YellowAWD ECU Feed
Cavity Cartridge
FuseMini
FuseDescription
3 10 Amp
RedCHMSL Brake Switch
Feed
4 10 Amp
RedIgnition Switch Feed
5 20 Amp
YellowTrailer Tow
6 10 Amp
RedIOD Sw/Pwr Mir/
Ocm Steering Cntrl
Sdar/Hfm
7 30 Amp
GreenIOD Sense1
8 30 Amp
GreenIOD Sense2
9 40 Amp
GreenPower Seats
10 20 Amp
YellowCCN, Power Locks
Integrated Power Module Location
MAINTAINING YOUR VEHICLE 401
7

EMISSION CONTROL SYSTEM MAINTENANCE
The ªScheduledº maintenance services, listed inbold
typemust be done at the times or mileages specified to
assure the continued proper functioning of the emission
control system. These, and all other maintenance services
included in this manual, should be done to provide best
vehicle performance and reliability. More frequent main-
tenance may be needed for vehicles in severe operating
conditions such as dusty areas and very short trip
driving.
Inspection and service also should be done any time a
malfunction is suspected.
NOTE:Maintenance, replacement, or repair of the emis-
sion control devices and systems on your vehicle may be
performed by any automotive repair establishment or
individual using any automotive part, which has been
certified pursuant to U.S. EPA or, in the State of Califor-
nia, California Air Resources Board regulations.
MAINTENANCE SCHEDULE
There are three maintenance schedules that showre-
quiredservice for your vehicle.
First is ScheduleªBºÐALL ENGINES. It is for vehicles
that are operated under the conditions that are listed
below and at the beginning of the schedule.
²Day and night temperatures are below 32É F (0É C).
²Stop and go driving.
²Extensive engine idling.
²Driving in dusty conditions.
²Short trips of less than 10 miles (16 km).
²More than 50% of your driving is at sustained high
speeds during hot weather, above 90É F (32É C).
²Trailer towing.²L
414 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

SCHEDULE ªBºÐALL ENGINES
Follow schedule ªBºÐAll Engines if you usually operate
your vehicle under one or more of the following condi-
tions.
Change the automatic transmission fluid and filter every
60,000 miles (100 000 km) if the vehicle is usually
operated under one or more of the conditions marked
with anL.
Change the manual transaxle fluid every 48,000 miles
(80 000 km) if the vehicle is usually operated under one
or more of the conditions marked with an ².
²Day and night temperatures are below 32É F (0É C).
²Stop and go driving.
²Extensive engine idling.
²Driving in dusty conditions.
²Short trips of less than 10 miles (16.2 km).
²More than 50% of your driving is at sustained high
speeds during hot weather, above 90É F (32É C).
²Trailer towing.²L
²Taxi, police, or delivery service (commercial ser-
vice).²L
²Off-road or desert operation.
²If equipped for and operating with E-85 (ethanol)
fuel.
NOTE:IfANYof these apply to you then change your
engine oil every 3,000 miles (5 000 km) or 3 months,
whichever comes first, and follow schedule ªBÐAll
Enginesº of the9Maintenance Schedules9section of this
manual.
SCHEDULE ªBºÐALL ENGINES 417
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 39,000 42,000 45,000 48,000 51,000 54,000
(Kilometers) (65 000) (70 000) (75 000) (80 000) (85 000) (90 000)
Change engine oil and engine oil filter, if not
replaced at 3 months.XXXXX X
Rotate tires. X X X
Inspect the brake linings. X
Change the brake fluid. If vehicle is used for
trailer towing.X
Inspect theengine air cleaner filter,replace as
necessary.*X
Change the manual transaxle fluid.² X
Inspect theMake-up air filter.Replace as nec-
essary.X
SCHEDULE ªBºÐALL ENGINES 421
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 93,000 96,000 99,000 102,000 105,000
(Kilometers) (155 000) (160 000) (165 000) (170 000) (175 000)
Change engine oil and engine oil filter, if not re-
placed at 3 months.XXXXX
Rotate tires. X X
Inspect the brake linings. X
Change the brake fluid. If vehicle is used for trailer
towing.X
Inspect theengine air cleaner filterand replace as
necessary.*X
Change the manual transaxle fluid.² X
Replace theengine timing belt.*X
Flush and replace the engine coolant, if not replaced
at 60 months.X
Inspect theMake-up air filter,replace as necessary. X
424 SCHEDULE ªBºÐALL ENGINES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 138,000 141,000 144,000 147,000 150,000
(Kilometers) (230 000) (235 000) (240 000) (245 000) (250 000)
Change engine oil and engine oil filter, if not re-
placed at 3 months.XXXXX
Rotate tires. X X X
Inspect the brake linings. X
Replace theengine air cleaner filter.*X
Replace the spark plugs.X
Change the manual transaxle fluid.² X
Replace theMake-up air filter.X
Inspect thePCV valve and replace if necessary.*³ X
* This maintenance is recommended by the manufacturer
to the owner, but is not required to maintain the emis-
sions warranty.
³ This maintenance is not required if previously replaced.
² This maintenance is required only for police, taxi,
limousine type operation, or trailer towing.LThis maintenance is required only for police, taxi,
limousine type operation, or trailer towing.
Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.
SCHEDULE ªBºÐALL ENGINES 427
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Electrical Power Outlets................... 202
Electronic Speed Control (Cruise Control)...... 190
Electronic Vehicle Information Center (EVIC).... 231
Emergency Deck Lid Release Latch (Convertible) . . 42
Emergency, In Case of
Jacking............................. 344
Jump Starting......................... 350
Towing............................. 354
Emergency Seat Back Release (Sedan).......... 40
Emission Control System Maintenance......365,414
Engine............................362,363
Break-In Recommendations............... 112
Checking Oil Level..................... 368
Cooling............................. 381
Exhaust Gas Caution.................... 325
Fuel Requirements..................... 321
Jump Starting......................... 350
Oil ...........................368,410,411
Oil Change Interval.................... 369Oil Filler Cap...................362,363,370
Oil Filter............................ 411
Oil Selection.......................... 370
Oil Synthetic......................... 371
Overheating.......................... 342
Temperature Gauge..................... 224
Timing Belt.......................... 374
Event Data Recorder...................68,102
Exhaust Gas Caution.........38,39,113,325,380,381
Exhaust System......................... 380
Fabric Care............................ 396
Filler Location Fuel...................... 224
Filters
Air Cleaner.......................... 375
Engine Fuel.......................... 374
Engine Oil........................371,411
Flashers.............................. 342
Hazard Warning....................... 342
454 INDEX

Flat Tire Stowage........................ 349
Flooded Engine Starting................... 282
Fluid, Brake........................... 412
Fluid Capacities......................... 410
Fluid Leaks............................ 114
Fluid Level Checks
Automatic Transaxle.................... 391
Fluids................................ 411
Fluids, Lubricants and Genuine Parts.......... 411
Fog Light Service........................ 407
Fog Lights..........................183,229
Folding Front Passenger Seat............... 163
Folding Rear Seat.....................167,169
Folding Rear Seat (Convertible).............. 169
Folding Rear Seat (Sedan).................. 167
Freeing A Stuck Vehicle................... 353
Fuel..............................321,411
Adding............................. 325
Additives............................ 324Capacity............................ 410
Clean Air............................ 322
Filler Cap (Gas Cap).................224,325
Filler Door (Gas Cap)................... 224
Filter............................... 374
Gasoline............................ 321
Gauge.............................. 224
Hoses.............................. 387
Light............................... 229
Octane Rating........................ 321
Requirements......................... 321
System Hoses......................... 387
Tank Capacity........................ 410
Fueling............................... 325
Fuses................................ 400
Garage Door Opener (HomeLinkt) ........... 193
Gas Cap (Fuel Filler Cap)............325,328,364
Gasoline, Clean Air...................... 322
INDEX 455
10