2007 CHRYSLER ASPEN transmission oil

WARNING!
Worn brake hoses can burst and cause brake failure.
You could have an accident. If you see any sign of
cracking, scuffing, or worn spots, have the brake
hoses replaced immediately.
Automatic Transmission
Fluid Level Check
Check the fluid level while the transmission is at normal
operating temperature 180°F (82°C). This occurs after at
least 15 miles (24 km) of driving. At normal operating
temperature the fluid cannot be held comfortably be-
tween the fingertips.
To check the automatic transmission fluid level properly,
the following procedure must be used:1. Operate the engine at idle speed and normal operating
temperature.
2. The vehicle must be on level ground.
3. Fully apply the parking brake and press the brake
pedal.
4. Place the gear selector momentarily in each gear
position ending with the lever in P (Park).
5. Remove the dipstick, wipe it clean and reinsert it until
seated.
6. Remove the dipstick again and note the fluid level on
both sides. The fluid level should be between the “HOT”
(upper) reference holes on the dipstick at normal operat-
ing temperature. Verify that solid coating of oil is seen on
both sides of the dipstick. If the fluid is low, add as
required into the dipstick tube.Do not overfill.After
adding any quantity of oil through the oil fill tube, wait
MAINTAINING YOUR VEHICLE 389
7

a minimum of two (2) minutes for the oil to fully drain
into the transmission before rechecking the fluid level.
NOTE:If it is necessary to check the transmissionbelow
the operating temperature, the fluid level should be
between the two “COLD” (lower) holes on the dipstick
with the fluid at approximately 70°F ( 21°C) (room
temperature). If the fluid level is correctly established at
room temperature, it should be between the “HOT”
(upper) reference holes when the transmission reaches
180°F ( 82°C). Remember it is best to check the level at the
normal operating temperature.
CAUTION!
Be aware that if the fluid temperature is below 50°F
(10°C) it may not register on the dipstick. Do not add
fluid until the temperature is elevated enough to
produce an accurate reading.
7. Check for leaks. Release parking brake.
To prevent dirt and water from entering the transmission
after checking or replenishing fluid, make certain that the
dipstick cap is properly reseated. It is normal for the
dipstick cap to spring back slightly from its fully seated
position, as long as its seal remains engaged in the
dipstick tube.
Automatic Transmission Fluid And Filter Change
It is important that proper lubricant is used in the
transmission. Refer to Fluids, Lubricants and Genuine
Parts for correct fluid type. It is important that the
transmission fluid be maintained at the prescribed level
using the recommended fluid.
390 MAINTAINING YOUR VEHICLE

At Each Stop for Fuel
•Check the engine oil level about 5 minutes after a fully
warmed engine is shut off. Checking the oil level while
the vehicle is on level ground will improve the accu-
racy of the oil level reading. Add oil only when the
level is at or below the ADD or MIN mark.
•Check the windshield washer solvent and add if
required.
Once a Month
•Check tire pressure and look for unusual wear or
damage.
•Inspect the battery and clean and tighten the terminals
as required.
•Check the fluid levels of coolant reservoir, brake
master cylinder, and transmission and add as needed.
•Check all lights and all other electrical items for correct
operation.At Each Oil Change
•Change the engine oil filter.
•Inspect the exhaust system.
•Inspect the brake hoses.
•Inspect the CV joints (if equipped) and front suspen-
sion components.
•Check the automatic transmission fluid level.
•Check the coolant level, hoses, and clamps.
420 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 48,000 51,000 54,000 57,000 60,000
(Kilometers) (80 000) (85 000) (90 000) (95 000) (100 000)
Change engine oil and engine oil filter, or at 3 months
whichever comes first.X X XXX
Rotate tires. X X X
Check spare tire for proper pressure and correct stowage. X X X
Change front and rear axle fluid (4X4). X
Inspect brake linings. X
Inspect engine air cleaner filter, replace if necessary.X
Replace spark plugs.X
Inspect PCV valve, replace as necessary.**X
Inspect auto tension drive belt and replace if required. X
Drain and refill automatic transmission fluid and change
main sump filter. This applies only if your vehicle is used
for police, taxi, fleet, or frequent trailer towing.X
Inspect transfer case fluid (4X4).X
Flush and replace engine coolant at 60 months, or 102,
000 miles (170 000 km) whichever comes first.X
SCHEDULE “B” 425
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Axle Lubrication (Axle Fluid)............... 392
Ball Joints............................. 377
Battery..........................362,363,375
Charging............................ 354
Emergency Starting..................... 354
Gas Caution.......................... 354
Keyless Transmitter Replacement (RKE)....... 24
Saving Feature (Protection)............... 132
Belts, Drive............................ 372
Belts, Seat.............................. 39
Body Mechanism Lubrication............... 378
B-Pillar Location........................ 293
Brake Assist System...................... 280
Brake Control System, Electronic............. 279
Brake Fluid............................ 416
Brake System........................275,387
Anti-Lock (ABS)....................275,279
Disc Brakes.......................... 387Fluid Check.......................... 387
Hoses.............................. 388
Master Cylinder....................... 387
Parking............................. 273
Warning Light.....................190,193
Brakes............................... 275
Brake/Transmission Interlock............... 258
Break-In Recommendations, New Vehicle........ 71
Bulb Replacement....................... 407
Bulbs, Light............................ 407
Calibration, Compass..................... 158
Capacities, Fluid........................ 414
Caps, Filler
Fuel................................ 316
Oil (Engine).......................... 370
Power Steering........................ 377
Radiator (Coolant Pressure)............... 383
Car Washes............................ 393
INDEX 451
10

Pressure Cap......................... 383
Radiator Cap......................... 383
Selection of Coolant (Antifreeze)......382,414,415
Temperature Gauge..................... 187
Cruise Control (Speed Control).............. 142
Cup Holder............................ 173
Customer Assistance..................... 442
Data Recorder, Event...................... 60
Daytime Running Lights................... 134
Dealer Service.......................... 367
Defroster, Rear Window................... 250
Defroster, Windshield..........73,235,236,241,242
Delay (Intermittent) Wipers................. 138
Diagnostic System, Onboard................ 364
Dimmer Switch, Headlight................. 188
Dipsticks
Automatic Transmission................. 389
Oil (Engine).......................... 368Power Steering........................ 377
Disarming, Theft System................... 18
Disc Brakes............................ 387
Disposal
Antifreeze (Engine Coolant)............... 384
Door Locks............................. 27
Door Opener, Garage..................... 160
Drive Belts............................ 372
Drive Shaft Universal Joints................ 378
DVD Player (Video Entertainment System)...... 226
E-85 Fuel............................. 318
Electric Remote Mirrors.................... 81
Electrical Power Outlets................... 169
Electronic Brake Control System............. 279
Electronic Speed Control (Cruise Control)...... 142
Electronic Stability Program (ESP).........193,283
Electronic Vehicle Information Center (EVIC).... 152
INDEX 453
10

Flashers
Hazard Warning....................... 346
Turn Signal.....................135,187,409
Flat Tire Stowage.....................348,354
Flexible Fuel Vehicles
Cruising Range........................ 320
Engine Oil........................... 320
Fuel Requirements..................318,319
Maintenance.......................... 321
Replacement Parts..................... 320
Starting............................. 320
Flooded Engine Starting................... 256
Floor Console.......................172,175
Fluid, Brake.........................387,416
Fluid Capacities......................... 414
Fluid Level Checks
Automatic Transmission................. 389
Brake............................... 387
Engine Oil........................... 368Power Steering........................ 377
Transfer Case......................... 391
Fluids, Lubricants and Genuine Parts.......... 415
Fog Lights..........................135,413
Folding Rear Seat..................... 117,120
Four Wheel Drive....................... 263
Operation........................... 263
Four-Way Hazard Flasher.................. 346
Freeing A Stuck Vehicle................... 288
Front Axle (Differential)................... 392
Fuel................................. 311
Filler Cap (Gas Cap).................... 316
Filter............................... 373
Gauge.............................. 187
Octane Rating...................... 311,415
Requirements...................... 311,414
Tank Capacity........................ 414
Fuel, Flexible.............See Flexible Fuel Vehicles
Fuel System Caution..................... 318
INDEX 455
10

Loading Vehicle......................... 321
Tires ............................... 293
Locks................................. 27
Automatic Door........................ 28
Child Protection........................ 30
Door................................ 27
Ignition.............................. 13
Keys................................ 12
Power Door........................... 28
Steering Wheel......................... 13
Lower Anchors and Tether for CHildren (LATCH) . 65
Lubricating Oil......................... 392
Lubrication, Body....................... 378
Lug Nuts............................. 352
Luggage Carrier......................... 176
Lumbar Support........................ 110
Maintenance Free Battery.................. 375
Maintenance Procedures................... 367Maintenance Schedule.................... 418
Schedule “A”......................... 434
Schedule “B”......................... 421
Malfunction Indicator Light (Check Engine) . . 194,365
Manual, Service......................... 446
Manual Transmission
Lubricant Selection..................... 416
Map/Reading Lights..................... 151
Memory Seat........................... 125
Mirrors................................ 79
Automatic Dimming...................80,83
Electric Powered....................... 81
Heated.............................. 83
Memory............................. 125
Outside.............................. 81
Rearview............................. 79
Vanity............................... 82
Modifications/Alterations, Vehicle............. 8
Monitor, Tire Pressure System............... 307
INDEX 459
10