2007 CHRYSLER ASPEN radiator cap

The 4.7L engine block heater cord is located at the front of
the engine compartment near the radiator cap. The 5.7L
engine block heater cord is located on the left side of the
engine compartment and rearward of the power distri-
bution center.
WARNING!
Remember to disconnect the cord before driving.
Damage to the 110-115 volt electrical cord could
cause electrocution.
AUTOMATIC TRANSMISSION
Automatic Transmission
The electronic PRNDL on the instrument cluster indicates
the transmission gear selected. The selector lever is
mounted on the right side of the steering column. To
drive, move the selector lever from Park or Neutral to the
desired drive position. Pull selector lever toward you
when shifting into Reverse, Second, First or Park, or
when shifting out of Park.
Brake/Transmission Interlock System
This system prevents you from moving the gear shift out
of Park and into any gear unless the brake pedal is
pressed. This system is active only while the ignition
switch is in the ON position. Always depress thebrake
pedal first,before moving the gear selector out of PARK.
Gear Ranges
DO NOT race the engine when shifting from Park or
Neutral position into another gear range.
258 STARTING AND OPERATING

Cooling System
WARNING!
You or others can be badly burned by hot coolant or
steam from your radiator. If you see or hear steam
coming from under the hood, don’t open the hood
until the radiator has had time to cool. Never try to
open a cooling system pressure cap when the radia-
tor is hot.
Engine Coolant Checks
Check the engine coolant (antifreeze) protection every 12
months (before the onset of freezing weather, where
applicable). If coolant is dirty or rusty in appearance, the
system should be drained, flushed and refilled with fresh
coolant. Check the front of the A/C condenser for anyaccumulation of bugs, leaves, etc. If dirty, clean by gently
spraying water from a garden hose vertically down the
face of the condenser.
Check the coolant recovery bottle tubing for brittle rub-
ber, cracking, tears, cuts and tightness of the connection
at the bottle and radiator. Inspect the entire system for
leaks.
With the engine at normal operating temperature (but
not running), check the cooling system pressure cap for
proper vacuum sealing by draining a small amount of
coolant from the radiator drain cock. If the cap is sealing
properly, the engine coolant (antifreeze) will begin to
drain from the coolant recovery bottle. DO NOT RE-
MOVE THE COOLANT PRESSURE CAP WHEN THE
COOLING SYSTEM IS HOT.
MAINTAINING YOUR VEHICLE 381
7

Adding Coolant
Your vehicle has been built with an improved engine
coolant that allows extended maintenance intervals. This
coolant can be used up to 5 Years or 100,000 miles before
replacement. To prevent reducing this extended mainte-
nance period, it is important that you use the same
coolant throughout the life of your vehicle. Please review
these recommendations for using Hybrid Organic Addi-
tive Technology (HOAT) coolant.
When adding coolant, a minimum solution of 50% rec-
ommended Mopar Antifreeze/ Coolant 5 Year/100,000
Mile Formula HOAT (Hybrid Organic Additive Technol-
ogy), or equivalent, in water should be used. Use higher
concentrations (not to exceed 70%) if temperatures below
34°F (37°C ) are anticipated.
Use only high purity water such as distilled or deionized
water when mixing the water/engine coolant solution.The use of lower quality water will reduce the amount of
corrosion protection in the engine cooling system.
Please note that it is the owner’s responsibility to main-
tain the proper level of protection against freezing ac-
cording to the temperatures occurring in the area where
the vehicle is operated.
NOTE:Mixing coolant types will decrease the life of the
engine coolant and will require more frequent coolant
changes.
Cooling System Pressure Cap
The cap must be fully tightened to prevent loss of
coolant, and to insure that coolant will return to the
radiator from the coolant recovery bottle.
The cap should be inspected and cleaned if there is any
accumulation of foreign material on the sealing surfaces.
MAINTAINING YOUR VEHICLE 383
7

WARNING!
•The warning words “DO NOT OPEN HOT” on
the cooling system pressure cap are a safety pre-
caution. Never add coolant when the engine is
overheated. Do not loosen or remove the cap to
cool an overheated engine. Heat causes pressure
to build up in the cooling system. To prevent
scalding or injury, do not remove the pressure cap
while the system is hot or under pressure.
•Do not use a pressure cap other than the one
specified for your vehicle. Personal injury or
engine damage may result.
Disposal of Used Engine Coolant
Used ethylene glycol based engine coolant is a regulated
substance requiring proper disposal. Check with your
local authorities to determine the disposal rules for your
community. To prevent ingestion by animals or childrendo not store ethylene glycol based engine coolant in open
containers or allow it to remain in puddles on the
ground. If ingested by a child, contact a physician
immediately. Clean up any ground spills immediately.
Coolant Level
The coolant bottle provides a quick visual method for
determining that the coolant level is adequate. With the
engine cold, the level of the coolant in the coolant
recovery bottle should be between the ranges indicated
on the bottle.
The radiator normally remains completely full, so there is
no need to remove the radiator cap unless checking for
coolant freeze point or replacing coolant. Advise your
service attendant of this. As long as the engine operating
temperature is satisfactory, the coolant bottle need only
be checked once a month.
384 MAINTAINING YOUR VEHICLE

Axle Lubrication (Axle Fluid)............... 392
Ball Joints............................. 377
Battery..........................362,363,375
Charging............................ 354
Emergency Starting..................... 354
Gas Caution.......................... 354
Keyless Transmitter Replacement (RKE)....... 24
Saving Feature (Protection)............... 132
Belts, Drive............................ 372
Belts, Seat.............................. 39
Body Mechanism Lubrication............... 378
B-Pillar Location........................ 293
Brake Assist System...................... 280
Brake Control System, Electronic............. 279
Brake Fluid............................ 416
Brake System........................275,387
Anti-Lock (ABS)....................275,279
Disc Brakes.......................... 387Fluid Check.......................... 387
Hoses.............................. 388
Master Cylinder....................... 387
Parking............................. 273
Warning Light.....................190,193
Brakes............................... 275
Brake/Transmission Interlock............... 258
Break-In Recommendations, New Vehicle........ 71
Bulb Replacement....................... 407
Bulbs, Light............................ 407
Calibration, Compass..................... 158
Capacities, Fluid........................ 414
Caps, Filler
Fuel................................ 316
Oil (Engine).......................... 370
Power Steering........................ 377
Radiator (Coolant Pressure)............... 383
Car Washes............................ 393
INDEX 451
10

Carbon Monoxide Warning............72,161,315
Cargo Management System................. 178
Cargo Organizer....................... 178
Cargo Organizer........................ 178
Cargo (Vehicle Loading)................... 321
Catalytic Converter...................... 373
CD (Compact Disc) Player...............200,208
Cellular Phone........................83,232
Center High Mounted Stop Light............ 412
Certification Label....................... 321
Charging.............................. 354
Chart, Tire Sizing........................ 290
Child Restraint........................62,63
Child Restraint Tether Anchors.............65,70
Child Restraint with Automatic Belts........... 45
Child Seat.............................. 67
Circuit Breakers......................... 398
Cleaning
Wheels............................. 395Climate Control......................... 233
Climate Control, Rear Zone..............237,244
Clock.....................197,198,202,210,222
Compact Disc (CD) Maintenance............. 232
Compact Spare Tire...................... 301
Compass Calibration..................... 158
Compass Variance....................... 159
Console, Floor.......................172,175
Console, Overhead....................150,151
Contract, Service........................ 444
Coolant Pressure Cap (Radiator Cap)....362,363,383
Cooling System......................... 381
Adding Coolant (Antifreeze).............. 383
Coolant Capacity...................... 414
Coolant Level......................381,384
Disposal of Used Coolant................ 384
Drain, Flush, and Refill.................. 382
Inspection........................... 384
Points to Remember.................... 385
452 INDEX

Pressure Cap......................... 383
Radiator Cap......................... 383
Selection of Coolant (Antifreeze)......382,414,415
Temperature Gauge..................... 187
Cruise Control (Speed Control).............. 142
Cup Holder............................ 173
Customer Assistance..................... 442
Data Recorder, Event...................... 60
Daytime Running Lights................... 134
Dealer Service.......................... 367
Defroster, Rear Window................... 250
Defroster, Windshield..........73,235,236,241,242
Delay (Intermittent) Wipers................. 138
Diagnostic System, Onboard................ 364
Dimmer Switch, Headlight................. 188
Dipsticks
Automatic Transmission................. 389
Oil (Engine).......................... 368Power Steering........................ 377
Disarming, Theft System................... 18
Disc Brakes............................ 387
Disposal
Antifreeze (Engine Coolant)............... 384
Door Locks............................. 27
Door Opener, Garage..................... 160
Drive Belts............................ 372
Drive Shaft Universal Joints................ 378
DVD Player (Video Entertainment System)...... 226
E-85 Fuel............................. 318
Electric Remote Mirrors.................... 81
Electrical Power Outlets................... 169
Electronic Brake Control System............. 279
Electronic Speed Control (Cruise Control)...... 142
Electronic Stability Program (ESP).........193,283
Electronic Vehicle Information Center (EVIC).... 152
INDEX 453
10

Pets.................................. 71
Pets, Transporting........................ 71
Phone, Cellular.......................... 83
Phone, Hands-Free (UConnect™)............. 83
Placard, Tire and Loading Information......... 293
Positive Crankcase Valve.................. 387
Power
Brakes.............................. 387
Distribution Center (Fuses)..........362,363,401
Door Locks.........................19,28
Lift Gate............................. 35
Mirrors.............................. 81
Outlet (Auxiliary Electrical Outlet).......169,170
Steering..........................277,377
Steering Filler Cap..................362,363
Sunroof............................. 167
Windows............................. 31
Power Steering Fluid..................... 416
Pregnant Women and Seat Belts.............. 50Preparation for Jacking.................... 350
Pretensioners
Seat Belts............................. 48
Programmable Electronic Features......155,162,165
Programming Transmitters
(Remote Keyless Entry)...............23,162,165
Radial Ply Tires......................... 300
Radiator Cap (Coolant Pressure Cap).......381,383
Radio Broadcast Signals................... 198
Radio, Navigation....................... 222
Radio Operation...................200,208,232
Radio, Satellite.......................222,226
Radio (Sound Systems).................200,208
Rear Axle (Differential).................... 392
Rear Cup Holder........................ 175
Rear Liftgate............................ 34
Rear Window Defroster................... 250
Rear Window Features.................... 249
INDEX 461
10