2007 CHEVROLET KODIAK service indicator

(2)= An Emission Control Service.
(3)= A Noise Emission Control Device.
(4)= Applies to vehicles sold in the United States
and is recommended for vehicles sold in Canada.
(5)= Check fluid level in brake master cylinder,
power steering pump, front and rear axles,
transmission, and hydraulic spring parking brake
pump (if equipped). A low fluid level in the
brake master cylinder can indicate worn brake
linings and should be checked accordingly.
(6)= Inspect brake lines and hoses for proper
hook-up, binding, leaks, cracks, chafing, etc.
Inspect disc brake pads for wear and rotors for
surface condition. Inspect caliper assemblies.
Check brake pedal for excessive free play or
travel (or every 6 months, whichever occurs first)
and have serviced if needed. Check brakes
more often if driving habits and conditions result
in frequent braking.(7)= This vehicle has the Engine Oil Life System.
This system will show you when to change the
engine oil and filter — usually between 3,000 miles
(5 000 km) and 12,000 miles (20 000 km) since
your last oil change. Under severe conditions,
the indicator may come on before 3,000 miles
(5 000 km). Never drive your 7.8L diesel engine
vehicle more than 12,000 miles (20 000 km),
or 12 months, or 600 engine hours, without an
oil and filter change.
Remember to reset the Engine Oil Life System
whenever the oil is changed. For more information,
seeEngine Oil Life System (Gasoline Engine)
on page 276orEngine Oil Life System
(DURAMAX
®Diesel) on page 278orEngine
Oil Life System (Caterpillar®Diesel Engine)
on page 279.
384

Starter Switch Check
{CAUTION:
When you are doing this inspection, the
vehicle could move suddenly. If the vehicle
moves, you or others could be injured.
1. Before you start, be sure you have enough
room around the vehicle.
2. Firmly apply both the parking brake and the
regular brakes.
Do not use the accelerator pedal, and be ready
to turn off the engine immediately if it starts.
3. On automatic transmission vehicles, try to
start the engine in each gear. The starter
should work only in PARK (P), if equipped,
or NEUTRAL (N). If the starter works in
any other position, your vehicle needs service.
On manual transmission vehicles, the starter
should work only when the clutch pedal is
all the way down.
Automatic Transmission Shift
Indicator Check
Check that the indicator points to the gear chosen.
Steering Check
Be alert for any changes in steering action,
abnormal front tire wear or steering wheel position.
An inspection or service is needed when the
steering wheel is harder to turn or has too much
free play, or if there are strange sounds when
turning or parking.
Brake System Check
Be alert to illumination of the low air warning lamp
or for the tone alarm, or changes in braking
action, such as repeated pulling to one side,
unusual sounds when braking or increased
brake pedal travel. Make sure air brake system
reservoirs are drained daily with full system
air pressure, and check system for leaks.
Any of these conditions could indicate the need
for brake system inspection and/or service.
393

Customer Assistance Information
Customer Assistance for Text Telephone
(TTY) Users.......................................... 406
Customer Assistance Offices.................... 406
Customer Satisfaction Procedure.............. 404
GM Mobility Reimbursement Program...... 407
Reporting Safety Defects to
General Motors..................................... 415
Reporting Safety Defects to the
Canadian Government.......................... 414
Reporting Safety Defects to the
United States Government.................... 414
Roadside Assistance Program.................. 408
Service Publications Ordering
Information........................................... 415
D
Daytime Running Lamps............................. 151
Daytime Running Lamps Indicator Light....... 179
Defensive Driving........................................ 206
Diesel Engine
Engine Alarm and Automatic Shutdown.... 104
Exhaust Brake......................................... 112
Exhaust Restrictor.................................... 108Diesel Engine (cont.)
Fuel......................................................... 253
High Idle System..................................... 106
Starting.................................................... 100
Differential Lock Control, Rear Axle............. 215
Differential Lock Indicator Light.................... 178
Doing Your Own Service Work.................... 249
Dome Lamps............................................... 153
Door
Locks......................................................... 91
Power Door Locks..................................... 92
Driver
Position, Safety Belt................................... 26
Driving
At Night................................................... 223
City.......................................................... 227
Defensive................................................. 206
Drunken................................................... 207
Freeway................................................... 228
Hill and Mountain Roads.......................... 230
In Rain and on Wet Roads...................... 224
Rocking Your Vehicle to Get it Out.......... 236
Tow Hooks............................................... 237
Winter...................................................... 231
Dual Tire Operation..................................... 323
420

E
Electrical System
Add-On Equipment................................... 340
Fuses and Circuit Breakers...................... 341
Fusible Links............................................ 341
Headlamp Wiring..................................... 341
Instrument Panel Fuse Block................... 342
Power Windows and Other Power
Options................................................. 341
Underhood Fuse Block............................. 344
Windshield Wiper Fuses........................... 341
Engine
Air Cleaner/Filter...................................... 280
Alarm and Automatic Shutdown................ 104
Battery..................................................... 304
Change Engine Oil Light.......................... 176
Check and Service Engine Soon Light..... 174
Checks Before Operating......................... 109
Coolant...........................................284, 287
Coolant Heater......................................... 111
Coolant Temperature Gage...................... 173
Diesel Engine Exhaust Brake................... 112
Drive Belt Routing.................................... 355
Exhaust................................................... 131
Exhaust Restrictor.................................... 108
Fan Breakage.......................................... 250Engine (cont.)
Fan Noise................................................ 294
High Idle System..................................... 106
Oil ...................................................268, 272
Oil Life System.......................276, 278, 279
Overheating............................................. 288
Overspeed Warning Light......................... 177
Reduced Power Light............................... 179
Shutdown Warning Light.......................... 177
Speed Limiter.......................................... 164
Starter Over-Crank Protection.................... 97
Starting Your Diesel................................. 100
Starting Your Gasoline............................... 97
Entry Lighting.............................................. 154
Event Data Recorders (EDR)...................... 409
Exhaust Brake Indicator Light...................... 178
Exhaust Restrictor....................................... 108
Extender, Safety Belt..................................... 41
Exterior Lamps............................................ 150
F
Filter
Engine Air Cleaner................................... 280
Filter Minder Gage...................................... 182
Finish Damage............................................ 338
Fixed Mast Antenna.................................... 204
421

L
Lamps
Dome....................................................... 153
Exterior.................................................... 150
Marker..................................................... 152
Reading................................................... 154
LATCH System
Child Restraints......................................... 57
Light
Airbag Off................................................ 166
Airbag Readiness..................................... 165
Anti-Lock Brake System Warning............. 172
Brake System Warning............................. 169
Change Engine Oil................................... 176
Charging System..................................... 167
Check Gages Warning............................. 180
Daytime Running Lamps Indicator............ 179
Differential Lock Indicator......................... 178
Engine Overspeed Warning...................... 177
Engine Shutdown Warning....................... 177
Exhaust Brake Indicator........................... 178
Highbeam On.......................................... 179
Low Coolant Warning............................... 173
Low Oil Level........................................... 176
Low Washer Fluid Warning...................... 180
Malfunction Indicator................................ 174Light (cont.)
Range Inhibit Warning Indicator................ 169
Reduced Engine Power............................ 179
Safety Belt Reminder............................... 164
Safety Belt Reminder Tone...................... 164
Service Transmission Warning.................. 168
Trailer Anti-Lock Brake System Warning ... 172
Wait to Start Indicator.............................. 174
Water in Fuel Warning............................. 182
Lighting
Entry........................................................ 154
Loading Your Vehicle................................... 238
Locks
Door.......................................................... 91
Power Door............................................... 92
Loss of Control........................................... 221
Low Coolant Warning Light.......................... 173
Low Washer Fluid Warning Light................. 180
M
Maintenance, Normal Replacement Parts.... 352
Maintenance Schedule
At Each Fuel Fill...................................... 391
At Least Once a Year.............................. 396
At Least Twice a Year.............................. 392
How This Section is Organized................ 360
424

Maintenance Schedule (cont.)
Introduction.............................................. 360
Maintenance Requirements...................... 360
Part A - Scheduled Maintenance
Services............................................... 362
Part B - Owner Checks and Services....... 391
Part C - Recommended Fluids and
Lubricants............................................. 397
Part D - Maintenance Record.................. 400
Scheduled Maintenance........................... 363
Scheduled Maintenance Supplements...... 363
Using....................................................... 362
Your Vehicle and the Environment............ 360
Malfunction Indicator Light........................... 174
Manual Transmission
Fluid........................................................ 283
Operation................................................. 116
Manual Windows........................................... 93
Marker Lamps............................................. 152
Mirrors
Manual Rearview Mirror........................... 133
Outside Convex Mirrors............................ 134
Outside Heated Mirrors............................ 134
Outside Manual Mirrors............................ 133
Outside Power Mirrors............................. 133N
New Vehicle Break-In.................................... 95
Noise Control System, Tampering ................ 314
Normal Maintenance Replacement Parts..... 352
O
Odometer.................................................... 163
Odometer, Trip............................................ 163
Off-Road Recovery...................................... 219
Oil
Change Engine Oil Light.......................... 176
Engine............................................268, 272
Low Oil Level Light.................................. 176
Pressure Gage......................................... 175
Oil, Engine Oil Life System........276, 278, 279
Older Children, Restraints............................. 42
Other Service Items
Air Conditioning System........................... 320
Automatic Ether Injection System............. 318
Front Wheel Bearings with
Oil-Filled Hubs...................................... 319
Fuel Filter................................................ 317
425