2007 CHEVROLET KODIAK fuel pressure

Ination - Tire Pressure
The Certification or Tire Information label shows
the correct inflation pressures for your tires
when they are cold. Cold means your vehicle has
been sitting for at least three hours or driven
no more than 1 mile (1.6 km).
Notice:Do not let anyone tell you that
under-ination or over-ination is all right. It is
not. If your tires do not have enough air
(under-ination), you can get the following:
Too much exing
Too much heat
Tire overloading
Premature or irregular wear
Poor handling
Reduced fuel economy
If your tires have too much air (over-ination),
you can get the following:
Unusual wear
Poor handling
Rough ride
Needless damage from road hazards
When to Check
Check your tires once a month or more.
Also, check the tire pressure of the spare tire if
your vehicle has one.
How to Check
Use a good quality pocket-type gage to check tire
pressure. You cannot tell if your vehicle’s tires
are properly inflated simply by looking at
them. Radial tires may look properly inflated even
when they are underinflated.
Be sure to put the valve caps back on the valve
stems. They help prevent leaks by keeping out dirt
and moisture.
322

❑Diesel Engine: Inspect engine air cleaner filter
change indicator. If necessary, replace the
filter. If vehicle is driven in dusty/dirty conditions,
inspect filter change indicator at every engine
oil change. SeeEngine Air Cleaner/Filter
on page 280for more information.
❑DURAMAX
®/Isuzu Diesel Only: Replace fuel
filter (or every 750 hours of engine operation,
whichever occurs first).
❑Chassis lubrication service (or every 6 months,
whichever occurs first).(11)
❑Cooling system service. Clean the cooling
system filler cap with clean water, clean
the core, pressure test the cap and the
system for proper pressure capability, and
inspect condition of cooling and heater
hoses and clamps. Replace hoses if cracked,
swollen, or damaged.
❑Inspect door hinge pins and bushings and
replace as necessary.
❑Steering system service.(12)
❑Front and rear suspension service.(13)❑Spring-to-axle U-bolts and shackle bolts
service.(15)
❑Exhaust system service (or every 6 months,
whichever occurs first).(2) (3) (16)
❑Wheels and tires service.(14)
❑Hydraulic brake service (or every 6 months,
whichever occurs first).(6) (36)
❑Parking brake service (or every 6 months,
whichever occurs first).(21)
❑Air brake service (or every 6 months, whichever
occurs first).(32)
❑Air brake automatic slack adjuster service (or
every 500 hours, whichever occurs first).(33)
❑Check air brake relay valve operation and check
for leaks (or every month, or every 300 hours,
whichever occurs first).
❑Clean air brake application valve (or every
3 months, or every 300 hours, whichever
occurs first). Lubricate linkage.
❑Air brake chamber service (or every 2 months,
whichever occurs first).(34)
371

❑Cooling system service. Clean the cooling
system filler cap with clean water, clean
the core, pressure test the cap and the
system for proper pressure capability, and
inspect condition of cooling and heater
hoses and clamps. Replace hoses if cracked,
swollen, or damaged.
❑Replace fuel filter(s) (or every 12 months,
whichever occurs first).(2)
❑Steering system service.(12)
❑Front and rear suspension service.(13)
❑Spring-to-axle U-bolts and shackle bolts
service.(15)
❑Exhaust system service (or every 6 months,
whichever occurs first).(2) (3) (16)
❑Inspect door hinge pins and bushings and
replace as necessary.
❑Wheel bearing (grease type) service (and
whenever hubs are removed).(22) (36)
❑Wheels and tires service.(14)
❑Hydraulic brake service (or every 6 months,
whichever occurs first).(6) (36)
❑Parking brake service (or every 6 months,
whichever occurs first).(21)❑Air brake service (or every 6 months, whichever
occurs first).(32)
❑Air brake automatic slack adjuster service (or
every 500 hours, whichever occurs first).(33)
❑Check air brake relay valve operation and check
for leaks (or every month, or every 300 hours,
whichever occurs first).
❑Clean air brake application valve (or every
3 months, or every 300 hours, whichever
occurs first). Lubricate linkage.
❑Air brake chamber service (or every 2 months,
whichever occurs first).(34)
❑Air brake system valve service (or every
3 months, or every 900 hours, whichever
occurs first).(37)
❑C600, C700, and C800 Gasoline Engines
Only: Engine drive belts service (or every
12 months, whichever occurs first).(17)
❑Thermostatically controlled engine cooling
fan service.(3) (19)
❑Shields and underhood insulation
service.(3) (4) (20)
❑Rear axle air shift motor service.(10)
380

Part B: Owner Checks and Services
Listed in this part are owner checks and services
which should be performed at the intervals
specified to help ensure the safety, dependability
and emission control performance of your
vehicle.
For your safety and that of others, any of the
safety-related components that may have been
damaged in an accident should be checked
and any needed repairs made before operating
the vehicle.
At the minimum, these routine checks should be
made every 6 months or 6,000 miles (10 000 km),
whichever occurs first. Whenever repairs are
needed, have them completed before operating
the vehicle.
At Each Fuel Fill
It is important for you or a service station attendant
to perform these underhood checks at each fuel ll.
Engine Oil Level Check
Check the engine oil level and add the proper
oil if necessary. SeeEngine Oil (Caterpillar®
Diesel Engine) on page 268orEngine Oil
(Gasoline Engine) on page 268orEngine Oil
(DURAMAX
®/Isuzu Diesel Engine) on page 272.
Engine Coolant Level Check
Check the engine coolant level and add
DEX-COOL®coolant mixture if necessary. See
Engine Coolant (Gas and DURAMAX®/Isuzu
Engines) on page 284orEngine Coolant
(Caterpillar
®Diesel Engines) on page 287.
Windshield Washer Fluid Level Check
Check the windshield washer fluid level in the
windshield washer fluid reservoir and add
the proper fluid if necessary. SeeWindshield
Washer Fluid on page 296.
Tire Ination Check
Check tire inflation cold. Make sure the tires are
inflated to the correct pressures. SeeLoading Your
Vehicle on page 238andInation - Tire Pressure
on page 322.
391

A
Accessory Power Outlet(s).......................... 156
Adding a Snow Plow or Similar
Equipment................................................ 240
Adding Equipment to Your Airbag-Equipped
Vehicle....................................................... 81
Additives, Fuel............................................ 252
Add-On Electrical Equipment....................... 340
Air Cleaner/Filter, Engine............................. 280
Air Conditioning........................................... 157
Air Conditioning System.............................. 320
Air Pressure Gage...................................... 183
Air Shift Control........................................... 114
Air Suspension............................................ 129
Air Suspension Seats.................................... 13
Airbag
Off Light.................................................. 166
Readiness Light....................................... 165
Airbag Sensing and Diagnostic
Module (SDM).......................................... 409
Airbag System............................................... 68
Adding Equipment to Your
Airbag-Equipped Vehicle......................... 81
Airbag Off Switch....................................... 76
How Does an Airbag Restrain?.................. 73
Servicing Your Airbag-Equipped Vehicle..... 80Airbag System (cont.)
What Makes an Airbag Inflate?.................. 73
What Will You See After an Airbag
Inflates?................................................. 74
When Should an Airbag Inflate?................. 72
Where Are the Airbags?............................. 70
AM-FM Radio.............................................. 186
Antenna, Fixed Mast................................... 204
Anti-Lock Brake System (ABS).................... 212
Anti-Lock Brake, System Warning Light....... 172
Anti-Lock Brakes, Trailer System
Warning Light........................................... 172
Appearance Care
Aluminum or Chrome-Plated Wheels........ 337
Care of Safety Belts................................ 334
Chemical Paint Spotting........................... 338
Cleaning Exterior Lamps/Lenses.............. 335
Cleaning the Inside of Your Vehicle.......... 331
Fabric/Carpet........................................... 333
Finish Care.............................................. 335
Finish Damage......................................... 338
Instrument Panel, Vinyl, and Other
Plastic Surfaces.................................... 334
Sheet Metal Damage............................... 337
Tires........................................................ 337
Underbody Maintenance........................... 338
Vehicle Care/Appearance Materials.......... 339
417

Flashers, Hazard Warning........................... 142
Flat Tire...................................................... 330
Fluid
Automatic Transmission............................ 282
Manual Transmission................................ 283
Power Steering........................................ 295
Windshield Washer.................................. 296
Four-Wheel Drive...............................119, 312
Front Axle................................................... 313
Front Wheel Bearings with Oil-Filled Hubs ... 319
Fuel............................................................ 251
Additives.................................................. 252
Diesel Engine Fuel................................... 253
Filling a Portable Fuel Container.............. 266
Filling Your Tank...................................... 264
Filter........................................................ 317
Filter Replacement................................... 263
Fuels in Foreign Countries....................... 264
Gage....................................................... 181
Gasoline Octane...................................... 251
Gasoline Specifications............................ 251
Primary Filter and Water Separator.......... 317
Running Out of Fuel................................ 262
Secondary Filter and Water Separator/
Heater.................................................. 318
Very Cold Weather Operation................... 256
Water in Fuel........................................... 256Fuel (cont.)
Water in Warning Light............................ 182
What Fuel to Use.................................... 253
Fuses
Fuses and Circuit Breakers...................... 341
Instrument Panel Fuse Block................... 342
Underhood Fuse Block............................. 344
Windshield Wiper..................................... 341
G
Gage
Air Pressure............................................. 183
Check Gages Warning Light..................... 180
Engine Coolant Temperature.................... 173
Filter Minder............................................ 182
Fuel......................................................... 181
Hourmeter................................................ 183
Oil Pressure............................................. 175
Speedometer........................................... 163
Tachometer.............................................. 163
Transmission Temperature........................ 178
Voltmeter Gage........................................ 168
Gasoline
Octane..................................................... 251
Specifications........................................... 251
Gasoline Engine, Starting.............................. 97
GM Mobility Reimbursement Program.......... 407
422

Maintenance Schedule (cont.)
Introduction.............................................. 360
Maintenance Requirements...................... 360
Part A - Scheduled Maintenance
Services............................................... 362
Part B - Owner Checks and Services....... 391
Part C - Recommended Fluids and
Lubricants............................................. 397
Part D - Maintenance Record.................. 400
Scheduled Maintenance........................... 363
Scheduled Maintenance Supplements...... 363
Using....................................................... 362
Your Vehicle and the Environment............ 360
Malfunction Indicator Light........................... 174
Manual Transmission
Fluid........................................................ 283
Operation................................................. 116
Manual Windows........................................... 93
Marker Lamps............................................. 152
Mirrors
Manual Rearview Mirror........................... 133
Outside Convex Mirrors............................ 134
Outside Heated Mirrors............................ 134
Outside Manual Mirrors............................ 133
Outside Power Mirrors............................. 133N
New Vehicle Break-In.................................... 95
Noise Control System, Tampering ................ 314
Normal Maintenance Replacement Parts..... 352
O
Odometer.................................................... 163
Odometer, Trip............................................ 163
Off-Road Recovery...................................... 219
Oil
Change Engine Oil Light.......................... 176
Engine............................................268, 272
Low Oil Level Light.................................. 176
Pressure Gage......................................... 175
Oil, Engine Oil Life System........276, 278, 279
Older Children, Restraints............................. 42
Other Service Items
Air Conditioning System........................... 320
Automatic Ether Injection System............. 318
Front Wheel Bearings with
Oil-Filled Hubs...................................... 319
Fuel Filter................................................ 317
425