2007 CHEVROLET EXPRESS CARGO VAN oil

(i)Drain, ush, and rell cooling system. This
service can be complex; you should have
your dealer/retailer perform this service. See
Engine Coolant on page 312 for what to use.
Inspect hoses. Clean radiator, condenser, pressure
cap, and ller neck. Pressure test the cooling
system and pressure cap.
(j)A uid loss in any vehicle system could indicate
a problem. Have the system inspected and
repaired and the uid level checked. Add uid if
needed.
(k)Inspect system. Check all fuel and vapor lines
and hoses for proper hook-up, routing, and
condition. Check that the purge valve works
properly, if equipped. Replace as needed.
(l)If you drive regularly under dusty conditions,
inspect the lter at each engine oil change.
(m)Check system for interference or binding and
for damaged or missing parts. Replace parts
as needed. Replace any components that have
high effort or excessive wear. Do not lubricate
accelerator or cruise control cables.
(n)Visually inspect belt for fraying, excessive
cracks, or obvious damage. Replace belt if
necessary.Owner Checks and Services
These owner checks and services should be
performed at the intervals specified to help
ensure the safety, dependability, and emission
control performance of your vehicle. Your
GM Goodwrench
®dealer can assist you with
these checks and services.
Be sure any necessary repairs are completed at
once. Whenever any fluids or lubricants are added
to your vehicle, make sure they are the proper
ones, as shown inRecommended Fluids and
Lubricants on page 415.
At the First 100, 1,000 and 6,000 Miles
(160, 1 600 and 10 000 km)
For vehicles with dual wheels, check dual wheel
nut torque. For proper torque, seeCapacities
and Specications on page 398.
411

At Each Fuel Fill
It is important to perform these underhood checks
at each fuel ll.
Engine Oil Level Check
Check the engine oil level and add the proper oil
if necessary. SeeEngine Oil (Gasoline Engine)
on page 303for further details.
Notice:It is important to check the engine
oil regularly and keep it at the proper
level. Failure to keep the engine oil at the
proper level can cause damage to the engine
not covered by your warranty.
Engine Coolant Level Check
Check the engine coolant level and add
DEX-COOL®coolant mixture if necessary. See
Engine Coolant on page 312for further details.
Windshield Washer Fluid Level Check
Check the windshield washer fluid level in
the windshield washer fluid reservoir and add
the proper fluid if necessary.
At Least Once a Month
Tire Ination Check
Inspect your vehicle’s tires and make sure they
are inflated to the correct pressures. Do not forget
to check the spare tire. SeeInation - Tire
Pressure on page 354. Check to make sure the
spare tire is stored securely. SeeChanging a Flat
Tire on page 366.
Tire Wear Inspection
Tire rotation may be required for high mileage
highway drivers prior to the Engine Oil Life System
service notification. Check the tires for wear
and, if necessary, rotate the tires. SeeTire
Inspection and Rotation on page 356.
412

Recommended Fluids
and Lubricants
This maintenance section applies to vehicles with
a gasoline engine. If your vehicle has a diesel
engine, see the maintenance schedule section in
the DURAMAX
®Diesel Engine Supplement.
Fluids and lubricants identified below by name,
part number, or specification can be obtained
from your dealer/retailer.
Usage Fluid/Lubricant
Engine OilEngine oil which meets GM
Standard GM6094M and displays
the American Petroleum Institute
Certified for Gasoline Engines
starburst symbol. To determine the
proper viscosity for your vehicle’s
engine, seeEngine Oil (Gasoline
Engine) on page 303.
Engine Coolant50/50 mixture of clean, drinkable
water and use only DEX-COOL
®
Coolant. SeeEngine Coolant
on page 312.
Usage Fluid/Lubricant
Hydraulic Brake
SystemDelco
®Supreme 11 Brake Fluid or
equivalent DOT-3 brake fluid.
Windshield
WasherGM Optikleen
®Washer Solvent.
Parking Brake
Cable GuidesChassis Lubricant
(GM Part No. U.S. 12377985, in
Canada 88901242) or lubricant
meeting requirements of NLGI #2,
Category LB or GC-LB.
Power Steering
SystemGM Power Steering Fluid
(GM Part No. U.S. 89021184,
in Canada 89021186).
Automatic
TransmissionDEXRON
®-VI Automatic
Transmission Fluid.
Key Lock
CylindersMulti-Purpose Lubricant, Superlube
(GM Part No. U.S. 12346241,
in Canada 10953474).
415

Normal Maintenance Replacement Parts
Replacement parts identified below by name, part number, or specification can be obtained by your
GM dealer.
Part GM Part Number ACDelco®Part Number
Engine Air Cleaner/Filter 15153904 A1621C
Engine Oil Filter
4300 V6 25010792 PF47
4800 V8, 5300 V8, 5300 V8 Flexible Fuel, 6000 V8 89017524 PF48
Spark Plugs
4300 V6 12607234 41-993
4800 V8, 5300 V8, 5300 V8 Flexible Fuel, 6000 V8 12571164 41-985
Wiper Blades
22 inches (56.0 cm)15153642 —
417

Driving
At Night................................................... 244
City.......................................................... 249
Defensive................................................. 228
Drunken................................................... 229
Freeway................................................... 250
Hill and Mountain Roads.......................... 254
In Rain and on Wet Roads...................... 246
Rocking Your Vehicle to Get it Out.......... 260
Winter...................................................... 256
Dual Tire Operation..................................... 355
E
EDR ............................................................ 441
Electrical System
Add-On Equipment................................... 393
Engine Compartment Fuse Block............. 395
Floor Console Fuse Block........................ 394
Fuses and Circuit Breakers...................... 393
Headlamp Wiring..................................... 393
Windshield Wiper Fuses........................... 393
Engine
Air Cleaner/Filter...................................... 308
Change Engine Oil Light.......................... 183
Check and Service Engine Soon Light..... 178
Coolant.................................................... 312Engine (cont.)
Coolant Heater......................................... 123
Coolant Temperature Gage...................... 178
Drive Belt Routing.................................... 418
Engine Compartment Overview................ 302
Exhaust................................................... 132
Fan Noise................................................ 323
Fuel Regulator......................................... 123
Oil ........................................................... 303
Oil Life System........................................ 306
Overheating............................................. 315
Reduced Power Light............................... 184
Running While Parked............................. 133
Starting.................................................... 122
Entry Lighting.............................................. 158
Event Data Recorders................................. 442
Exit Lighting................................................ 158
Extender, Safety Belt..................................... 40
Exterior Lamps............................................ 155
F
Filter
Engine Air Cleaner................................... 308
Finish Damage............................................ 389
Fixed Mast Antenna.................................... 226
Flashers, Hazard Warning........................... 146
449

Flash-to-Pass.............................................. 149
Flat Tire...................................................... 365
Flat Tire, Changing...................................... 366
Flat Tire, Storing......................................... 380
Fluid
Automatic Transmission............................ 309
Power Steering........................................ 323
Windshield Washer.................................. 324
Front Axle................................................... 338
Fuel............................................................ 292
Additives.................................................. 294
California Fuel.......................................... 293
E85 (85% Ethanol)................................... 295
Filling a Portable Fuel Container.............. 299
Filling Your Tank...................................... 297
Fuels in Foreign Countries....................... 296
Gage....................................................... 186
Gasoline Octane...................................... 293
Gasoline Specifications............................ 293
Regulator................................................. 123
Fuses
Engine Compartment Fuse Block............. 395
Floor Console Fuse Block........................ 394
Fuses and Circuit Breakers...................... 393
Windshield Wiper..................................... 393G
Gage
Check Gages Warning Light..................... 185
Engine Coolant Temperature.................... 178
Fuel......................................................... 186
Oil Pressure............................................. 182
Speedometer........................................... 168
Voltmeter Gage........................................ 175
Gasoline
Octane..................................................... 293
Specifications........................................... 293
GM Mobility Reimbursement Program.......... 429
H
Hazard Warning Flashers............................ 146
Headlamp Wiring......................................... 393
Headlamps.................................................. 340
Bulb Replacement.................................... 340
Daytime Running Lamps.......................... 156
Exterior Lamps......................................... 155
Flash-to-Pass........................................... 149
Front Turn Signal, Sidemarker and
Parking Lamps..................................... 342
450

Headlamps (cont.)
Halogen Bulbs......................................... 340
High/Low Beam Changer......................... 149
On Reminder........................................... 156
Heater......................................................... 160
Highbeam On Light..................................... 185
Highway Hypnosis....................................... 253
Hill and Mountain Roads............................. 254
Hood
Checking Things Under............................ 300
Release................................................... 300
Horn............................................................ 146
How to Use This Manual................................ 4
How to Wear Safety Belts Properly............... 22
I
Ignition Positions......................................... 120
Infants and Young Children, Restraints.......... 44
Inflation - Tire Pressure............................... 354
Instrument Panel
Overview.................................................. 144
Instrument Panel (I/P)
Brightness................................................ 157
Cluster..................................................... 167
J
Jump Starting.............................................. 330
K
Keyless Entry System................................. 104
Keys........................................................... 102
L
Labeling, Tire Sidewall................................. 347
Lamps
Dome....................................................... 157
Dome Lamp Override............................... 157
Reading................................................... 158
LATCH System
Child Restraints......................................... 54
Light
Airbag Off................................................ 170
Airbag Readiness..................................... 169
Anti-Lock Brake System Warning............. 176
Brake System Warning............................. 175
Change Engine Oil................................... 183
Charging System..................................... 174
Check Gages Warning............................. 185
Cruise Control.......................................... 184
451

Manual Windows......................................... 115
Mirrors
Automatic Dimming Rearview with
Compass and Temperature Display....... 134
Manual Rearview Mirror........................... 134
Outside Camper-Type Mirrors................... 136
Outside Convex Mirror............................. 138
Outside Heated Mirrors............................ 139
Outside Manual Mirror.............................. 136
Outside Power Mirrors............................. 138
MyGMLink.com............................................ 427
N
Navigation System, Privacy......................... 443
New Vehicle Break-In.................................. 119
Noise Control System, Tampering................ 338
Normal Maintenance Replacement Parts..... 417
O
Odometer.................................................... 168
Odometer, Trip............................................ 168
Off-Road Recovery...................................... 241
Oil
Change Engine Oil Light.......................... 183
Engine..................................................... 303Oil (cont.)
Pressure Gage......................................... 182
Oil, Engine Oil Life System......................... 306
Older Children, Restraints............................. 41
Online Owner Center................................... 427
OnStar, Privacy........................................... 443
Other Warning Devices................................ 146
Outlet Adjustment........................................ 162
Outlets
Accessory Power..................................... 158
Outside
Camper-Type Mirrors................................ 136
Convex Mirror.......................................... 138
Heated Mirrors......................................... 139
Manual Mirror.......................................... 136
Power Mirrors.......................................... 138
Owner Checks and Services....................... 411
Owners, Canadian.......................................... 3
P
Paint, Damage............................................ 389
Park (P)
Shifting Into............................................. 129
Shifting Out of......................................... 130
453