2007 CHEVROLET CORVETTE air filter

How to Inspect the Engine
Air Cleaner/Filters (7.0L V8 Engine)
To inspect the air cleaner/lters, remove the lters
from the vehicle and lightly shake the lters to
release loose dust and dirt. If the lters remain
caked with dirt, new lters are required.
To inspect or replace the engine air cleaner/lters,
do the following:
1. Remove the screws holding the lter element
in place.
2. Pull on latches found on either side of the lter.3. Inspect or replace the lter. SeeNormal
Maintenance Replacement Parts on page 445.
4. Reverse Steps 1 and 2 to replace the
air cleaner/lter cover.
{CAUTION:
Operating the engine with the
air cleaner/lter off can cause you or
others to be burned. The air cleaner not
only cleans the air; it helps to stop ames
if the engine backres. If it is not there
and the engine backres, you could be
burned. Do not drive with it off, and be
careful working on the engine with the
air cleaner/lter off.
Notice:If the air cleaner/lter is off, a backre
can cause a damaging engine re. And, dirt
can easily get into your engine, which will
damage it. Always have the air cleaner/lter
in place when you are driving.
344

All cleaning agents should be ushed promptly
and not allowed to dry on the surface, or they
could stain. Dry the nish with a soft, clean
chamois or an all-cotton towel to avoid surface
scratches and water spotting.
Notice:If you drive your vehicle through an
automatic car wash that does not have enough
clearance for the wide rear tires and wheels,
you could damage your vehicle. Verify with the
manager of the car wash that your vehicle
will t before entering the car wash or use a
touchless car wash.
High pressure car washes may cause water to
enter the vehicle.
If you are cleaning your vehicle with the hood open,
take care not to spray water directly into either
end of the air cleaner/lter housing as this could
damage your vehicle’s engine. SeeEngine Air
Cleaner/Filter on page 342for more information.
Cleaning Exterior Lamps/Lenses
Use only lukewarm or cold water, a soft cloth
and a car washing soap to clean exterior lamps
and lenses. Follow instructions underWashing
Your Vehicle on page 411.
Finish Care
Occasional waxing or mild polishing of the vehicle
by hand may be necessary to remove residue
from the paint nish. Approved cleaning products
can be obtained from your dealer. SeeVehicle
Care/Appearance Materials on page 417.
Notice:Machine compounding or aggressive
polishing on a basecoat/clearcoat paint
nish may damage it. Use only non-abrasive
waxes and polishes that are made for a
basecoat/clearcoat paint nish on your vehicle.
The vehicle has a basecoat/clearcoat paint
nish. The clearcoat gives more depth and gloss
to the colored basecoat. Always use waxes
and polishes that are non-abrasive and made
for a basecoat/clearcoat paint nish.
Foreign materials such as calcium chloride and
other salts, ice melting agents, road oil and
tar, tree sap, bird droppings, chemicals from
industrial chimneys, etc., can damage the vehicle’s
nish if they remain on painted surfaces. Wash
the vehicle as soon as possible. If necessary, use
non-abrasive cleaners that are marked safe for
painted surfaces to remove foreign matter.
412

Capacities and Specications
The following approximate capacities are given in English and metric conversions.
SeeRecommended Fluids and Lubricants on page 443for more information.
ApplicationCapacities
English Metric
Air Conditioning Refrigerant R134aFor the air conditioning system refrigerant
charge amount, see the refrigerant
caution label located under the hood.
See your dealer for more information.
Cooling System 12.6 qt 11.9 L
Engine Oil with Filter
6.0 L V8 Engine 5.5 qt 5.2 L
6.0 L V8 Engine Performance Package (Z51) 6.0 qt 5.7 L
7.0 L V8 Engine 8.0 qt 7.6 L
Fuel Tank 18.0 gal 68.0 L
Transmission Fluid
Automatic Transmission
(Pan Removal and Filter Replacement)6.5 qt 6.2 L
Manual Transmission – Base 3.6 qt 3.5 L
426

Scheduled Maintenance
Service MaintenanceIMaintenanceII
Change engine oil and lter. SeeEngine Oil on page 333. Reset oil life system.
SeeEngine Oil Life System on page 340.An Emission Control Service.••
Visually check for any leaks or damage.See footnote (g).••
Inspect engine air cleaner lter. If necessary, replace lter. SeeEngine Air
Cleaner/Filter on page 342.See footnote (k).•
Check tire ination pressures and tire wear. SeeTires on page 378.••
Inspect brake system.See footnote (a).••
Check engine coolant and windshield washer uid levels and add uid as
needed.••
Perform any needed additional services. See “Additional Required Services” in
this section.••
Inspect suspension and steering components.See footnote (b).•
Inspect engine cooling system.See footnote (c).•
Inspect wiper blades.See footnote (d).•
Inspect restraint system components.See footnote (e).•
Lubricate body components.See footnote (f).•
Replace passenger compartment air lter.See footnote (j).•
435

Additional Required Services
The following services should be performed at the rst maintenance service (IorII) after the indicated
miles (kilometers) shown for each item.
Additional Required Services
Service and Miles (Kilometers)25,000
(40 000)50,000
(80 000)75,000
(120 000)100,000
(160 000)125,000
(200 000)150,000
(240 000)
Inspect fuel system for damage or leaks.• •••••
Inspect exhaust system for loose or
damaged components.• •••••
Replace engine air cleaner lter. See
Engine Air Cleaner/Filter on page 342.•••
Change automatic transmission uid and
lter (severe service).See footnote (h).•••
Change automatic transmission uid and
lter (normal service).•
Replace spark plugs and inspect spark
plug wires.An Emission Control Service.•
Engine cooling system service (or every
ve years, whichever occurs rst).
An Emission Control Service. See
footnote (i).•
Inspect engine accessory drive belt.
An Emission Control Service. See
footnote (l).•
436

Normal Maintenance Replacement Parts
Replacement parts identied below by name, part number, or specication can be obtained from your
GM dealer.
Part GM Part NumberAC Delco®
Part Number
Engine Air Cleaner/Filter
6.0L V8 10342024 A2945C
7.0L V8 15776148 A3077C
Engine Oil Filter
6.0L V8 89017524 PF48
7.0L V8 89017524 PF48
Passenger Compartment Air Filter Element 10345066 CF131C
Spark Plug
6.0L V8 12571164 41-985
7.0L V8 12571165 41-104
Windshield Wiper Blade
20.7 inches (52.5 cm)
Driver’s Side 12335960 —
Passenger’s Side 12335961 —
445

A
Accessories and Modications..................... 319
Active Handling System............................... 283
Active Handling System Light...................... 198
Adding Equipment to Your
Airbag-Equipped Vehicle............................ 65
Additives, Fuel............................................ 323
Add-On Electrical Equipment....................... 418
Air Cleaner/Filter, Engine............................. 342
Air Conditioning........................................... 179
Airbag
Passenger Status Indicator....................... 192
Readiness Light....................................... 191
Airbag System............................................... 50
What Will You See After an
Airbag Inates?...................................... 58
When Should an Airbag Inate?................. 55
Where Are the Airbags?............................. 53
Airbag Systems
Adding Equipment to Your
Airbag-Equipped Vehicle......................... 65
How Does an Airbag Restrain?.................. 57
Passenger Sensing System....................... 59
Servicing Your Airbag-Equipped Vehicle..... 64
What Makes an Airbag Inate?.................. 57Antenna, Diversity Antenna System............. 272
Antenna, XM™ Satellite Radio
Antenna System....................................... 272
Anti-Lock Brake System.............................. 279
Anti-Lock Brake, System Warning Light....... 197
Appearance Care
Aluminum or Chrome-Plated Wheels........ 414
Care of Safety Belts................................ 411
Cargo Cover and Convenience Net.......... 411
Chemical Paint Spotting........................... 416
Cleaning Exterior Lamps/Lenses.............. 412
Cleaning the Inside of Your Vehicle.......... 407
Coated Moldings...................................... 409
Convertible Top........................................ 414
Fabric/Carpet........................................... 409
Fiberglass Springs................................... 416
Finish Care.............................................. 412
Finish Damage......................................... 415
Instrument Panel, Vinyl, and Other
Plastic Surfaces.................................... 410
Leather.................................................... 410
Removable Roof Panel............................ 413
Tires........................................................ 415
Underbody Maintenance........................... 416
Vehicle Care/Appearance Materials.......... 417
Washing Your Vehicle.............................. 411
473

Climate Control System
Air Filter, Passenger Compartment........... 186
Dual Automatic......................................... 179
Outlet Adjustment..................................... 186
Clock.......................................................... 245
Clutch, Hydraulic......................................... 346
Collision Damage Repair............................. 463
Compass............................................108, 110
Competitive Driving, Racing or Other........... 292
Control of a Vehicle..................................... 278
Convenience Net......................................... 132
Convertible Top..................................139, 146
Coolant
Engine Temperature Gage........................ 199
Heater, Engine........................................... 93
Surge Tank Pressure Cap........................ 350
Cooling System........................................... 353
Courtesy Lamps.......................................... 173Cruise Control............................................. 164
Cupholder(s)................................................ 130
Customer Assistance Information
Courtesy Transportation........................... 461
Customer Assistance for Text
Telephone (TTY) Users ......................... 456
Customer Assistance Offices.................... 456
Customer Satisfaction Procedure.............. 452
GM Mobility Reimbursement Program...... 457
Reporting Safety Defects to
General Motors..................................... 468
Reporting Safety Defects to the
Canadian Government.......................... 467
Reporting Safety Defects to the
United States Government.................... 467
Roadside Assistance Program.................. 458
Service Publications Ordering
Information........................................... 468
476