2007 CHEVROLET COBALT brake

At Least Once a Month
Tire Ination Check
Inspect your vehicle’s tires and make sure they
are inated to the correct pressures. Do not forget
to check the spare tire. SeeInation - Tire
Pressure on page 347. Check to make sure the
spare tire is stored securely. SeeChanging a Flat
Tire on page 358.
Tire Wear Inspection
Tire rotation may be required for high mileage
highway drivers prior to the Engine Oil Life System
service notication. Check the tires for wear
and, if necessary, rotate the tires. SeeTire
Inspection and Rotation on page 349.
At Least Once a Year
Starter Switch Check
{CAUTION:
When you are doing this inspection, the
vehicle could move suddenly. If the vehicle
moves, you or others could be injured.
1. Before you start, be sure you have enough
room around the vehicle.
2. Firmly apply both the parking brake and the
regular brake. SeeParking Brake on
page 123.
Do not use the accelerator pedal, and be
ready to turn off the engine immediately if it
starts.
3. On automatic transaxle vehicles, try to start
the engine in each gear. The vehicle should
start only in PARK (P) or NEUTRAL (N). If the
vehicle starts in any other position, contact
your GM Goodwrench
®dealer for service.
403

On manual transaxle vehicles, put the shift
lever in NEUTRAL, push the clutch pedal
down halfway, and try to start the engine. The
vehicle should start only when the clutch
pedal is pushed down all the way to the oor.
If the vehicle starts when the clutch pedal
is not pushed all the way down, contact your
GM Goodwrench
®dealer for service.
Automatic Transaxle Shift Lock Control
System Check
{CAUTION:
When you are doing this inspection, the
vehicle could move suddenly. If the
vehicle moves, you or others could be
injured.
1. Before you start, be sure you have enough
room around the vehicle. It should be parked
on a level surface.2. Firmly apply the parking brake. SeeParking
Brake on page 123.
Be ready to apply the regular brake
immediately if the vehicle begins to move.
3. With the engine off, turn the ignition to RUN,
but do not start the engine. Without applying
the regular brake, try to move the shift
lever out of PARK (P) with normal effort. If the
shift lever moves out of PARK (P), contact
your GM Goodwrench
®dealer for service.
Ignition Transaxle Lock Check
While parked, and with the parking brake set, try
to turn the ignition to LOCK in each shift lever
position.
With an automatic transaxle, the ignition
should turn to LOCK only when the shift lever
is in PARK (P). The ignition key should
come out only in LOCK.
With a manual transaxle, the ignition key
should come out only in LOCK.
Turn the steering wheel to the left and to the right. It
should only lock when turned to the right. Contact
your GM Goodwrench
®dealer if service is required.
404

Parking Brake and Automatic Transaxle
Park (P) Mechanism Check
{CAUTION:
When you are doing this check, your
vehicle could begin to move. You or
others could be injured and property
could be damaged. Make sure there is
room in front of your vehicle in case it
begins to roll. Be ready to apply the
regular brake at once should the vehicle
begin to move.Park on a fairly steep hill, with the vehicle facing
downhill. Keeping your foot on the regular
brake, set the parking brake.
To check the parking brake’s holding ability:
With the engine running and transaxle in
NEUTRAL (N), slowly remove foot pressure
from the regular brake pedal. Do this until the
vehicle is held by the parking brake only.
To check the PARK (P) mechanism’s holding
ability: With the engine running, shift to
PARK (P). Then release the parking brake
followed by the regular brake.
Contact your GM Goodwrench
®dealer if service is
required.
Underbody Flushing Service
At least every spring, use plain water to ush any
corrosive materials from the underbody. Take
care to clean thoroughly any areas where mud and
other debris can collect.
405

Recommended Fluids and
Lubricants
Fluids and lubricants identied below by name,
part number, or specication can be obtained from
your dealer/retailer.
Usage Fluid/Lubricant
Engine Oil
(2.2L and 2.4L
L4 engines)Engine oil which meets GM
Standard GM6094M and displays
the American Petroleum Institute
(API) Certied for Gasoline Engines
starburst symbol. To determine the
proper viscosity for your vehicle’s
engine, seeEngine Oil on page 293.
Engine Oil
(2.0L L4
Supercharged
engine)The engine requires a special engine
oil meeting GM Standard GM4718M.
Oils meeting this standard can be
identied with the American
Petroleum Institute (API) Certied for
Gasoline Engines starburst symbol.
However, not all synthetic API oils
with the starburst symbol will meet
this GM standard. You should look
for and use only an oil that meets
GM Standard GM4718M. For the
proper viscosity, seeEngine Oil on
page 293.
Usage Fluid/Lubricant
Engine Cooling
System50/50 mixture of clean, drinkable
water and use only DEX-COOL
®
Coolant. SeeEngine Coolant on
page 302.
Intercooler
System
(2.0L L4
Supercharged
engine)50/50 mixture of clean, drinkable
water and use only DEX-COOL
®
Coolant.
Hydraulic Brake
SystemDelco
®Supreme 11 Brake Fluid or
equivalent DOT-3 brake uid.
Hydraulic
Clutch SystemDelco
®Supreme 11 Brake Fluid or
equivalent DOT-3 brake uid.
Windshield
WasherGM Optikleen
®Washer Solvent.
Parking Brake
Cable GuidesChassis Lubricant
(GM Part No. 12377985, in
Canada 88901242) or lubricant
meeting requirements of NLGI #2,
Category LB or GC-LB.
Manual
Transmission
(2.2L and 2.4L
L4 engines)Manual Transmission Fluid
(GM Part No. U.S. 88861800, in
Canada 88861801).
406

Reporting Safety Defects to
General Motors
In addition to notifying NHTSA (or Transport
Canada) in a situation like this, we certainly
hope you will notify General Motors. Please
call the Chevrolet Customer Assistance Center
at 1-800-222-1020, or write:
Chevrolet Motor Division
Chevrolet Customer Assistance Center
P.O. Box 33170
Detroit, MI 48232-5170
In Canada, please call us at 1-800-263-3777
(English) or 1-800-263-7854 (French).
Or, write:
General Motors of Canada Limited
Customer Communication Centre, CA1-163-005
1908 Colonel Sam Drive
Oshawa, Ontario L1H 8P7
Service Publications Ordering
Information
Service Manuals
Service Manuals have the diagnosis and repair
information on engines, transmission, axle
suspension, brakes, electrical, steering, body, etc.
Transmission, Transaxle, Transfer
Case Unit Repair Manual
This manual provides information on unit
repair service procedures, adjustments, and
specications for GM transmissions, transaxles,
and transfer cases.
430

Event Data Recorders
Some information about your vehicle’s performance
and how it is driven may be recorded on various
modules if a crash occurs. Some people refer to
these modules asevent data recorders (EDRs).
These modules may record several seconds of
pre-crash and crash data, such as data related
toengine speed, brake application, throttle
position, vehicle speed, yaw rate, steering
wheel angle, lateral acceleration, safety belt
usage, airbag readiness, airbag performance
andthe severity of the collision.Unlike the ight
data recorders on airplanes, these modules do
not record sounds or conversations.To retrieve this data, special equipment and access
to the vehicle or the module that stores the data
are required. Certain data may also be sent to or
retrieved by OnStar®(see below). GM will not
access this information or share it with others
except: with the consent of the vehicle owner or, if
the vehicle is leased, with the consent of the lessee;
in response to an official request of police or similar
government office; as part of GM’s defense of
litigation through the discovery process; or, as
required by law. Data that GM collects or receives
may also be used for GM research needs or may
be made available to others for research purposes,
where a need is shown and the data is not tied to a
specic vehicle or vehicle owner.
Others may be able to retrieve this data if they
have access to the vehicle and have the special
equipment necessary to download the data.
433

A
Accessories and Modications..................... 280
Adding Equipment to Your
Airbag-Equipped Vehicle............................ 83
Additives, Fuel............................................ 284
Add-On Electrical Equipment....................... 383
Air Cleaner/Filter, Engine............................. 300
Air Conditioning........................................... 158
Airbag
Passenger Status Indicator....................... 168
Readiness Light....................................... 167
Airbag System............................................... 68
What Will You See After an Airbag
Inates?................................................. 76
When Should an Airbag Inate?................. 73
Where Are the Airbags?............................. 71
Airbag Systems
Adding Equipment to Your
Airbag-Equipped Vehicle......................... 83
How Does an Airbag Restrain?.................. 75
Passenger Sensing System....................... 77
Servicing Your Airbag-Equipped Vehicle..... 82
What Makes an Airbag Inate?.................. 75
Antenna, Fixed Mast................................... 224Antenna, XM™ Satellite Radio
Antenna System....................................... 224
Anti-Lock Brake System.............................. 231
Anti-Lock Brake, System Warning Light....... 172
Appearance Care
Aluminum or Chrome-Plated Wheels........ 378
Care of Safety Belts................................ 376
Chemical Paint Spotting........................... 381
Cleaning Exterior Lamps/Lenses.............. 377
Cleaning the Inside of Your Vehicle.......... 373
Fabric/Carpet........................................... 374
Finish Care.............................................. 377
Finish Damage......................................... 380
Instrument Panel, Vinyl, and
Other Plastic Surfaces.......................... 376
Leather.................................................... 375
Sheet Metal Damage............................... 380
Tires........................................................ 379
Underbody Maintenance........................... 380
Vehicle Care/Appearance Materials.......... 381
Washing Your Vehicle.............................. 377
Weatherstrips........................................... 376
Windshield and Wiper Blades................... 378
Ashtray....................................................... 157
435

Audio System.............................................. 192
Audio Steering Wheel Controls................. 222
Care of Your CD Player........................... 224
Care of Your CDs.................................... 224
Fixed Mast Antenna................................. 224
Radio with CD................................197, 202
Setting the Time...................................... 194
Theft-Deterrent Feature............................ 222
Understanding Radio Reception............... 223
XM™ Satellite Radio Antenna System...... 224
Automatic Door Lock................................... 100
Automatic Transaxle
Fluid........................................................ 301
Operation................................................. 118
B
Battery........................................................ 321
Electric Power Management..................... 155
Run-Down Protection............................... 156
Before Leaving on a Long Trip.................... 250
Boost Gage................................................. 180Brake
Emergencies............................................ 233
Parking.................................................... 123
Brakes........................................................ 318
System Warning Light.............................. 171
Braking....................................................... 230
Braking in Emergencies............................... 233
Break-In, New Vehicle................................. 111
Bulb Replacement....................................... 331
Back-Up Lamps....................................... 335
Center High-Mounted
Stoplamp (CHMSL)............................... 333
Halogen Bulbs......................................... 331
Headlamp Aiming..................................... 328
Headlamps, Front Turn Signal,
Sidemarker, and Parking Lamps........... 331
License Plate Lamps................................ 336
Replacement Bulbs.................................. 337
Taillamps and Turn Signal Lamps............. 334
Taillamps, Turn Signal, Stoplamps and
Back-up Lamps..................................... 334
Buying New Tires........................................ 351
436