2007 CHEVROLET AVEO check oil

Maintenance Schedule
Introduction
Important: Keep engine oil at the proper level
and change as recommended.
Have you purchased the GM Protection Plan?
The Plan supplements your new vehicle
warranties. See your Warranty and Owner
Assistance booklet or your dealer for details.
Maintenance Requirements
Maintenance intervals, checks, inspections and
recommended fluids and lubricants as prescribed
in this manual are necessary to keep your
vehicle in good working condition. Any damage
caused by failure to follow scheduled maintenance
may not be covered by warranty.
Your Vehicle and the Environment
Proper vehicle maintenance not only helps to keep
your vehicle in good working condition, but also
helps the environment. Improper vehicle
maintenance can even affect the quality of the air
we breathe. Improper fluid levels or the wrong
tire inflation can increase the level of emissions
from your vehicle. To help protect our environment,
and to keep your vehicle in good condition, be
sure to maintain your vehicle properly.
372

Long Trip/Highway Denition
Follow this scheduled maintenanceonlyif none of
the conditions from the Short Trip/City Scheduled
Maintenance are true. Do not use this schedule
if the vehicle is driven in a dusty area or used off
paved roads. Use the Short Trip/City schedule
for these conditions.
Driving a vehicle with a fully warmed engine under
highway conditions will cause engine oil to break
down slower.
Long Trip/Highway Intervals
Every 7,500 Miles (12 500 km):Engine Oil and
Filter Change (or every 12 months, whichever
occurs first). Tire Rotation.
Every 15,000 Miles (25 000 km):Engine Air
Cleaner Filter Inspection. Passenger Compartment
Air Filter Replacement. Drive Belt(s) Inspection.
Every 30,000 Miles (50 000 km):Engine Air
Cleaner Filter Replacement. Spark Plug
Replacement. EVAP System Service. PCV System
Service. Timing Belt Inspection. Brake/Clutch Fluid
Change (or 24 months, whichever occurs first).Every 60,000 Miles (100 000 km):Spark Plug
Wire Replacement. Timing Belt Replacement.
EVAP System Solenoid Valve Replacement.
Every 90,000 Miles (150 000 km):Fuel Filter
Replacement. Engine Oil Pan Drain Plug Washer
Replacement.
Every 150,000 Miles (240 000 km):Cooling
System Service.
These intervals only summarize maintenance
services. Be sure to follow the complete scheduled
maintenance on the following pages.Short Trip/City Scheduled
Maintenance
The services shown in this schedule up to
100,000 miles (166 000 km) should be repeated
after 100,000 miles (166 000 km) at the same
intervals for the life of this vehicle. The services
shown at 150,000 miles (240 000 km) should be
repeated at the same interval after 150,000 miles
(240 000 km) for the life of this vehicle.
SeePart B: Owner Checks and Services on
page 389andPart C: Periodic Maintenance
Inspections on page 394.
376

Footnotes
†The U.S. Environmental Protection Agency or
the California Air Resources Board has determined
that the failure to perform this maintenance item
will not nullify the emission warranty or limit
recall liability prior to the completion of the
vehicle’s useful life. We, however, urge that all
recommended maintenance services be performed
at the indicated intervals and the maintenance
be recorded.
+A good time to check your brakes is during tire
rotation. See Brake System Inspection on page 395.
3,000 Miles (5 000 km)
❑Change engine oil and filter (or every 3 months,
whichever occurs first).An Emission Control
Service.
6,000 Miles (10 000 km)
❑Change engine oil and filter (or every 3 months,
whichever occurs first).An Emission Control
Service.
❑Rotate tires. SeeTire Inspection and Rotation
on page 327for proper rotation pattern and
additional information.(See footnote +.)
9,000 Miles (15 000 km)
❑Change engine oil and filter (or every 3 months,
whichever occurs first).An Emission Control
Service.
12,000 Miles (20 000 km)
❑Change engine oil and filter (or every 3 months,
whichever occurs first).An Emission Control
Service.
❑Rotate tires. SeeTire Inspection and Rotation
on page 327for proper rotation pattern and
additional information.(See footnote +.)
15,000 Miles (25 000 km)
❑Change engine oil and filter (or every 3 months,
whichever occurs first).An Emission Control
Service.
❑Replace passenger compartment air filter.
If you drive regularly under dusty conditions,
the filter may require replacement more often.
❑Inspect engine air cleaner filter. If necessary,
replace the filter. If vehicle is driven in
dusty/dirty conditions, inspect filter at every
engine oil change. SeeEngine Air Cleaner/Filter
on page 281for more information.
❑Inspect drive belt(s).
377

Long Trip/Highway Scheduled
Maintenance
The services shown in this schedule up to
100,000 miles (166 000 km) should be repeated
after 100,000 miles (166 000 km) at the same
intervals for the life of this vehicle. The services
shown at 150,000 miles (240 000 km) should be
repeated at the same interval after 150,000 miles
(240 000 km) for the life of this vehicle.
SeePart B: Owner Checks and Services on
page 389andPart C: Periodic Maintenance
Inspections on page 394.
Footnotes
†The U.S. Environmental Protection Agency or
the California Air Resources Board has determined
that the failure to perform this maintenance item
will not nullify the emission warranty or limit
recall liability prior to the completion of the
vehicle’s useful life. We, however, urge that all
recommended maintenance services be performed
at the indicated intervals and the maintenance
be recorded.
+A good time to check your brakes is during tire
rotation. See Brake System Inspection on page 395.
7,500 Miles (12 500 km)
❑Change engine oil and filter (or every 12 months,
whichever occurs first).An Emission Control
Service.
❑Rotate tires. SeeTire Inspection and Rotation
on page 327for proper rotation pattern and
additional information.(See footnote +.)
15,000 Miles (25 000 km)
❑Change engine oil and filter (or every 12 months,
whichever occurs first).An Emission Control
Service.
❑Replace passenger compartment air filter.
If you drive regularly under dusty conditions,
the filter may require replacement more often.
❑Inspect engine air cleaner filter. SeeEngine Air
Cleaner/Filter on page 281for more information.
❑Rotate tires. SeeTire Inspection and Rotation on
page 327for proper rotation pattern and
additional information.(See footnote +.)
❑Inspect drive belt(s).
384

Part B: Owner Checks and Services
Listed in this part are owner checks and services
which should be performed at the intervals
specified to help ensure the safety, dependability
and emission control performance of your vehicle.
Be sure any necessary repairs are completed at
once. Whenever any fluids or lubricants are added
to your vehicle, make sure they are the proper
ones, as shown in Part D.
At Each Fuel Fill
It is important for you or a service station attendant
to perform these underhood checks at each fuel fill.
Engine Oil Level Check
Check the engine oil level and add the proper oil
if necessary. SeeEngine Oil on page 277for
further details.
Engine Coolant Level Check
Check the engine coolant level and add the proper
coolant mixture if necessary. SeeEngine Coolant
on page 287for further details.
Windshield Washer Fluid Level Check
Check the windshield washer fluid level in the
windshield washer fluid reservoir and add the
proper fluid if necessary. SeeWindshield Washer
Fluid on page 298for further details.
At Least Once a Month
Tire Ination Check
Inspect the tires and make sure the tires are inflated
to the correct pressures. Do not forget to check the
spare tire. SeeInflation - Tire Pressure on page 326.
At Least Twice a Year
Restraint System Check
Make sure the safety belt reminder light and all
your belts, buckles, latch plates, retractors
and anchorages are working properly. Look for
any other loose or damaged safety belt system
parts. If you see anything that might keep a safety
belt system from doing its job, have it repaired.
Have any torn or frayed safety belts replaced.
Also look for any opened or broken airbag
coverings, and have them repaired or replaced.
(The airbag system does not need regular
maintenance.)
389

E
Electrical System
Add-On Equipment................................... 355
Engine Compartment Fuse Block............. 361
Fuses and Circuit Breakers...................... 356
Headlamp Wiring..................................... 355
Instrument Panel Fuse Block................... 357
Power Windows and Other Power
Options................................................. 356
Windshield Wiper Fuses........................... 355
Engine
Air Cleaner/Filter...................................... 281
Check and Service Engine
Soon Light...................................166, 180
Coolant.................................................... 287
Coolant Heater......................................... 110
Coolant Temperature Gage...................... 165
Cooling System Inspection....................... 395
Drive Belt Routing.................................... 370
Engine Compartment Overview................ 276
Exhaust................................................... 122
Oil ........................................................... 277
Overheating............................................. 290
Running While Parked............................. 123
Starting.................................................... 109Event Data Recorders (EDR)...................... 413
Extender, Safety Belt..................................... 40
Exterior Lamps............................................ 144
F
Filter
Engine Air Cleaner................................... 281
Finish Damage............................................ 352
Fixed Mast Antenna.................................... 217
Flashers, Hazard Warning........................... 135
Flash-to-Pass.............................................. 138
Flat Tire...................................................... 335
Flat Tire, Changing...................................... 336
Flat Tire, Storing......................................... 344
Fluid
Manual Transaxle..................................... 285
Power Steering........................................ 297
Windshield Washer.................................. 298
Fog Lamp
Fog .......................................................... 146
Fog Lamp Light..................................170, 185
Fuel............................................................ 266
Additives.................................................. 267
California Fuel.......................................... 267
Filling a Portable Fuel Container.............. 272
427

Light (cont.)
Door Ajar........................................172, 185
Fog Lamp.......................................170, 185
Highbeam On.......................................... 171
Hold Mode......................................165, 180
Low Fuel Warning.................................... 173
Malfunction Indicator.......................166, 180
Oil Pressure....................................169, 184
Passenger Airbag Status Indicator............ 161
Safety Belt Reminder......................160, 175
Safety Belt Reminder Tone...................... 160
Lights
Exterior Lamps......................................... 144
Flash-to-Pass........................................... 138
High/Low Beam Changer......................... 138
On Reminder........................................... 145
Loading Your Vehicle................................... 249
Lockout Protection......................................... 97
Locks
Central Door Unlocking System................. 95
Door.......................................................... 94
Lockout Protection..................................... 97
Rear Door Security Locks.......................... 96
Long Trip/Highway Scheduled
Maintenance............................................ 384
Loss of Control........................................... 232
Low Fuel Warning Light............................... 173
Lumbar
Manual Controls.......................................... 9M
Maintenance, Normal Replacement Parts.... 369
Maintenance Schedule
At Each Fuel Fill...................................... 389
At Least Once a Month............................ 389
At Least Once a Year.............................. 390
At Least Twice a Year.............................. 389
Brake System Inspection.......................... 395
Engine Cooling System Inspection........... 395
Exhaust System Inspection...................... 394
Fuel System Inspection............................ 395
How This Section is Organized................ 373
Introduction.............................................. 372
Long Trip/Highway Scheduled
Maintenance......................................... 384
Maintenance Requirements...................... 372
Part A - Scheduled Maintenance
Services............................................... 374
Part B - Owner Checks and Services...... 389
Part C - Periodic Maintenance
Inspections........................................... 394
Part D - Recommended Fluids and
Lubricants............................................. 396
Part E - Maintenance Record................... 398
Selecting the Right Schedule................... 375
Short Trip/City Scheduled Maintenance..... 376
430