2007 BMW MOTORRAD G 650 XCHALLENGE coolant level

General view, left side1Adjuster for damping char-
acteristic, front suspen-
sion (compression stage)
( 39)
2Air Damping System
( 34)
3Power socket
OE
( 60)
4Adjuster for damping char-
acteristic, rear suspension
( 40)
5Fore-and-aft tilt indicator
( 35)
6Coolant-level indicator
( 71)
211zGeneral views

Fuel down to reserve
Warning light for fuel down
to reserve lights up.
Lack of fuel can result in
the engine misfiring and
cutting out unexpectedly. Mis-
firing can damage the catalytic
converter; a hazardous situation
can result if the engine cuts out
unexpectedly.
Do not run the fuel tank dry.
Possible cause: The fuel tank
contains no more than the re-
serve quantity of fuel.
Reserve fuel
2l
Refuelling ( 52)Insufficient engine oil
pressure
Warning light for oil pres-
sure shows.
The oil pressure in the lube-oil
system is too low. Stop immedi-
ately and switch off the engine if
the warning light shows.
The insufficient oil pres-
sure warning does not fulfil
the function of an oil gauge. The
only way of checking whether
the oil level is correct is to check
with the oil dipstick.
Possible cause: Engine-oil level
too low.
Check the engine oil level
( 65)
If the oil level is too low:
Top up the engine oil ( 67)
If the engine oil level is correct:
Riding when engine-oil
pressure is low can result
in engine damage.Do not continue your journey.
Have the fault rectified as
quickly as possible by a
specialist workshop, preferably
an authorised BMW Motorrad
dealer.
Coolant temperature too high
Warning light for coolant
temperature shows.
Continuing to ride when the
engine is overheated could
result in engine damage.
You must comply with the in-
structions below.
Possible cause: Coolant level too
low.
Check the coolant level ( 71)
If the coolant level is too low:
Topping up coolant ( 72)
Possible cause: Radiator fan de-
fective.
322zStatus indicators

Brake fluid level, rear
DOT4 brake fluid
Do not permit the brake fluid
level to drop below the MIN
mark. (Brake-fluid reservoir
horizontal)
If the brake fluid level drops be-
low the permitted level:
Have the defect rectified as
quickly as possible by a spe-
cialist workshop, preferably
an authorised BMW Motorrad
dealer.
CoolantChecking coolant levelMake sure the ground is level
and firm and hold the motor-
cycle upright.
Read off the coolant level on
scale1on the coolant expan-
sion tank.Coolant, specified level
Between MIN and MAX
marks on the expansion tank
If the coolant level is too low:
Top up the coolant.
If the coolant level is too high:
Seek the advice of a specialist
workshop, preferably an author-
ised BMW Motorrad dealer.
871zMaintenance

Topping up coolantPull cover of radiator cap1for-
ward to remove.
Open cap of the expansion
tank for coolant2.Top up the coolant to the spe-
cified level.
Close the cap of the expansion
tank for coolant.
Seat the cover of the radiator
cap in holders3. In this pro-
cess, guide the top edge of the
cover behind the bottom edge
of centre trim panel4.
ClutchChecking clutch-lever
playPull the clutch lever until resist-
ance is perceptible.
Measure clutch-lever playA.
Clutch-lever play
2...3 mm (Engine cold)
Clutch-lever play is out of toler-
ance:
Adjust clutch-lever play ( 73)
872zMaintenance

A
Abbreviations and symbols, 6
ABS
Engineering details, 55
Fuses, 13, 85
Self-diagnosis, 48
Switching off and on, 15, 33
Warnings, 23
Accessories
Notes, 60
Power socket, 60
Air Damping System, 34
Adjusting air pressure, 34, 35
Air pressure and
temperature, 35
Fore-and-aft tilt indicator, 11,
35
Periods of disuse, 36
Air filter, 14
Replacing, 92
Auxiliary stand, 81
B
Battery
Charging, 97
Maintenance instructions, 96Removing and installing, 98
Technical data, 117
Voltmeter, 20, 30
BMW Motorrad service, 122
BMW Motorrad Service
Card, 122
Brake fluid
Checking level, 69
Reservoir, front, 13
Reservoir, rear, 13
Brake pads
Running in, 49
Test, 68
Brakes
Notes, 50
Technical data, 114
Test, 67
Bulbs
Notes on replacement, 86
Replacing low-beam headlight
bulb, 86
Replacing number-plate light
bulbs, 91
Replacing rear light, 91
Replacing side-light bulb, 89Replacing turn indicator
bulb, 90
Technical data, 118
C
Care, 103
Chain
Adjusting tension, 74
Checking tension, 74
Checking wear, 75
Lubricating, 73
Checklist, 46
Clock, 20
Adjusting, 17, 29
Clutch
Adjusting play, 73
Checking play, 72
Technical data, 112
Confirmation of maintenance
work, 124
Coolant
Checking level, 71
Fore-and-aft tilt indicator, 11
Topping up, 72
12131zIndex

Coolant temperature
Warning, 22
D
Damping
Adjusting, 11, 13
Dimensions, 119
Display, 28
Overview, 20
Selecting readings, 17, 28
E
Electrics
Technical data, 117
Emergency off switch (kill
switch), 16, 32
Engine
Starting, 16, 46
Technical data, 110
Engine oil
Checking level, 65
Filler neck, 14
Oil dipstick, 14
Technical data, 111
Topping up, 67Engine oil pressure
Warning, 22
Equipment, 7
F
Frame
Technical data, 118
Front-wheel stand, 82
Fuel
Filler neck, 13
Refuelling, 52
Technical data, 4, 111
Warning, 22
Fuses, 14, 84
ABS, 85
G
General views
Display, 20
Headlight, 18
Instrument cluster, 17
Left handlebar fitting, 15
Left side, 11
Right handlebar fitting, 16
Right side, 13
Status indicators, 20Telltale lights, 20
Underneath the seat, 14
Warnings, 20
H
Handlebar fitting, left
Overview, 15
Handlebar fitting, right
Overview, 16
Headlight
Beam throw, 41
Driving on right/driving on
left, 41
General views, 18
Replacing low-beam headlight
bulb, 86
Replacing side-light bulb, 89
Headlight flasher, 15, 31
High-beam headlight, 18
Switch, 15
Telltale light, 20
Horn, 15
I
Idle
Telltale light, 20
12132zIndex