2007 BMW 3 SERIES Sulev

California Emission Warranty Parts
List
The following components are covered for
defects by the California Emission Control Sys-
tem Limited Warranty for a period of 7 years or
70,000 miles, whichever comes first:
Component 328i 335i
CATALYTIC
CONVERTER••
CYLINDER HEAD
COVER GASKET••
ENGINE CONTROL
MODULE••
EXHAUST
MANIFOLD GASKET••
EXHAUST
MANIFOLD
W/CATALYST•
EXHAUST PIPE
W/CATALYST••
FUEL FILLER NECK••
FUEL TANK••
HIGH PRESSURE
FUEL PUMP•
INTAKE MANIFOLD••
INTAKE MANIFOLD
ADJUSTER UNIT•
OXYGEN SENSOR••
THROTTLE BODY•
TORQUE
CONVERTER••
TRANSMISSION
CONTROL MODULE••
TURBOCHARGER•
VALVETRONIC
SENSOR••
VANOS (VVT)
ADJUSTMENT UNIT••
Notice
The National Traffic Motor Vehicle Safety Act of
1966 requires manufacturers to be in a position
to contact the vehicle owners when a correction
of a product defect becomes necessary. Please
fill in the attached postcard if you change your
address or purchase a used BMW.
Tire Warranty Statement
Tires are warranted by their respective manufac-
turer as detailed in the applicable tire manufac-
turers warranty statements. Instructions for
proper tire care and maintenance are contained
in the Owners Manual. Should you experience
difficulty in obtaining warranty service from a tire
manufacturer, your authorized BMW center will
assist you in resolving the difficulty.
California Emission Warranty —
SULEV (PZEV)
Certain 2007 328i models are certified to Califor-
nia’s stringent Super Ultra Low Emission Vehicle
(SULEV) standards and also qualify as a Partial
Zero Emission Vehicle (PZEV) under the Califor-
nia Air Resources Board Zero Emission Vehicle
program. In addition to very low tailpipe and zero-
evaporative emissions, this PZEV certification
includes a unique warranty when the vehicle is
registered in California, Massachusetts, Maine,
New York, Connecticut, Rhode Island or Vermont.
SULEV(PZEV) models registered in Oregon and
Washington are covered by the California Emis-
sions Warranty; this coverage is described begin-
ning on page 37.
The emission certification standard can be veri-
fied on the Vehicle Emission Control Information
label located in the engine compartment. A rep-
resentative label is shown on page 1.
40

Summary of BMW Limited Warranties for SULEV(PZEV) Models
* The California Emissions Control System Limited Warranty applies to all 2007 U.S. specification BMW
SULEV (PZEV) vehicles sold, leased, and/or registered in California, Maine, Massachusetts, New York,
Connecticut, Rhode Island or Vermont.
41

California Emission Control
Warranty Statement SULEV
(PZEV)* Your Warranty Rights and
Obligations
The California Air Resources Board and BMW of
North America (BMW NA) are pleased to explain
the emission control system warranty on your
2007 vehicle. In California, new motor vehicles
must be designed, built and equipped to meet
the States stringent anti-smog standards. BMW
NA must warrant the emission control system on
your vehicle for the periods of time listed below
provided there has been no abuse, neglect or
improper maintenance of your vehicle.
Your emission control system may include parts
such as the fuel injection system, the ignition
system, catalytic converter, and engine com-
puter. Also included may be hoses, belts, con-
nectors and other emission-related assemblies.
Where a warrantable condition exists, BMW NA
will repair your vehicle at no cost to you including
diagnosis, parts and labor.
Manufacturers Warranty Coverage:
– For 15 years or 150,000 miles whichever
occurs first:
1. If your vehicle fails a Smog Check inspection,
all necessary repairs and adjustments will be
made by BMW NA to ensure that your vehicle
passes the inspection. This is your emission
control system PERFORMANCE
WARRANTY.
2. If any emission-related part on your vehicle is
defective, the part will be repaired or replaced
by BMW NA. This is your emission control
system DEFECTS WARRANTY.
Owners Warranty Responsibilities:
– As the vehicle owner, you are responsible for
the performance of the required maintenance
listed in your Owners Manual. BMW NA recom-
mends that you retain all receipts covering
maintenance on your vehicle, but BMW NA
cannot deny warranty solely for the lack of
receipts or for your failure to ensure the perfor-
mance of all scheduled maintenance.
– You are responsible for presenting your vehicle
to an authorized BMW center as soon as a
problem exists. The warranty repairs should be
completed in a reasonable amount of time, not
to exceed 30 days.
– As the vehicle owner, you should also be aware
that BMW NA may deny your warranty cover-
age if your vehicle or part has failed due to
abuse, neglect, improper maintenance or unap-
proved modifications.
If you have any questions regarding your war-
ranty rights and responsibilities, you should
contact:
BMW of North America, LLC
Customer Relations and Services Department
PO. Box 1227
Westwood, N.J. 07675-1227
Telephone: 1 800 831-1117
Website:
www.bmwusa.com
or the
California Air Resources Board
9528 Telstar Avenue
El Monte, CA 91731
*-The California Emissions Control System Lim-
ited Warranty SULEV (PZEV) applies to all 2007
U.S. specification BMW SULEV (PZEV) vehicles
sold, leased, and/or registered in California,
Maine, Massachusetts, New York, Connecticut,
Rhode Island or Vermont. SULEV(PZEV) models
registered in Oregon or Washington have differ-
ent emissions warranty coverage; please refer to
the California Emissions Warranty section begin-
ning on page 43.
42

California Emission Control
System Limited Warranty SULEV
(PZEV)*
This warranty applies to California certified vehi-
cles distributed by BMW of North America (BMW
NA) or sold through the BMW NA European
Delivery Program, registered and operated pri-
marily in California.
BMW NA warrants to the original purchaser and
each subsequent owner that the vehicle is:
a. designed, built and equipped so as to con-
form with the applicable California Air
Resources Board emission standards.
b. free from defects in materials and workman-
ship which cause any part that can affect
emissions to fail to conform with applicable
requirements or to fail a California Smog
Check test or EPA approved short test for a
period of 15 years or 150,000, whichever
occurs first.
c. free from defects in materials and workman-
ship in emission related parts for a period of
15 years or 150,000, whichever occurs first.
This warranty begins on the date of first retail
sale, or the date the vehicle is first placed in ser-
vice as a demonstrator or company vehicle,
whichever is earlier.
To obtain service under this warranty, the vehicle
must be brought, upon failure of a Smog Check
test or upon discovery of the defect, to the work-
shop of any authorized BMW center, during nor-
mal business hours. The BMW center will honor
or deny your claim within 30 days. If the claim is
denied, the BMW center will notify you in writing
of the reason(s). The BMW center is required by
law to honor the claim if notice is not given to the
owner within 30 days.
The BMW center will, without charge for parts or
labor (including diagnosis), either adjust, repair or
replace the defective part and other parts
affected by the failure of the warranted part, if
any. If your vehicle failed the California Smog
Check test or an EPA approved short test, then
BMW NA will repair your vehicle so that it will
pass this test. Items that require scheduledreplacement are warranted up to the replace-
ment interval specified in the Service section of
this Statement. BMW NA may repair a part in lieu
of replacing it when performing warranty repairs.
Parts for which replacements are made become
the property of BMW NA.
A repair performed as the result of a smog check
test failure due to a defect in a part, which is war-
ranted for 15 years/150,000, is covered.
In all cases, a reasonable time, not to exceed 30
days, must be allowed for a warranty repair to be
completed, after the car is received by the BMW
center.
It is the owners responsibility to have all required
maintenance services performed (at the owners
expense), as prescribed in the maintenance
schedule for the BMW Emission Control System.
Service intervals are computed by the service
interval indicator and displayed on the instrument
panel.
However, BMW NA will not deny your warranty
repair claims solely because you do not have
maintenance records or you did not perform the
required maintenance unless BMW NA demon-
strates that such lack of required maintenance is
a direct cause of the emission control system
failure. The instructions for required maintenance
and use can be found in the Owners Manual and
in the Service section of this Statement.
*The California Emissions Control System Lim-
ited Warranty SULEV(PZEV) applies to all 2007
U.S. specification BMW SULEV(PZEV) vehicles
sold, leased, and/or registered in California,
Maine, Massachusetts, Connecticut, Rhode
Island or Vermont.
It is strongly recommended that any replacement
parts used for maintenance, repair or replace-
ment of emission control systems be genuine
BMW Service Parts or BMW Authorized
Remanufactured Parts. Without invalidating this
warranty, the owner may elect to have mainte-
nance, repair or replacement of the emission
control systems performed by any automotive
repair establishment, or elect to use parts other
than BMW Authorized Remanufactured or genu-
ine BMW Service Parts. However, the cost of
such service or parts will not be covered under
this warranty, except in emergency situations. In
an emergency situation, where an authorized
43