NOTE:
Consult a Yamaha dealer for advice
on what products to use.
EAU26300
Storage
Short-term
Always store your scooter in a cool,
dry place and, if necessary, protect it
against dust with a porous cover.
ECA10820
CAUTION
Storing the scooter in a poorly
ventilated room or covering it
with a tarp, while it is still wet,
will allow water and humidity to
seep in and cause rust.
To prevent corrosion, avoid
damp cellars, stables (because
of the presence of ammonia)
and areas where strong chemi-
cals are stored.
Long-term
Before storing your scooter for seve-
ral months:
1. Follow all the instructions in the
“Care” section of this chapter.2. Drain the carburetor float cham-
ber by loosening the drain bolt;
this will prevent fuel deposits
from building up. Pour the drai-
ned fuel into the fuel tank.
3. Fill up the fuel tank and add fuel
stabilizer (if available) to prevent
the fuel tank from rusting and the
fuel from deteriorating.
4. Perform the following steps to
protect the cylinder, piston rings,
etc. from corrosion.
a. Remove the spark plug cap and
spark plug.
b. Pour a teaspoonful of engine oil
into the spark plug bore.
c. Install the spark plug cap onto
the spark plug, and then place
the spark plug on the cylinder
head so that the electrodes are
grounded. (This will limit sparking
during the next step.)
d. Turn the engine over several
times with the starter. (This will
coat the cylinder wall with oil.)
e. Remove the spark plug cap from
the spark plug, and then install
the spark plug and the spark plug
cap.
EWA10950
s s
WARNING
To prevent damage or injury from
sparking, make sure to ground the
spark plug electrodes while turning
the engine over.
5. Lubricate all control cables and
the pivoting points of all levers
and pedals as well as of the
sidestand/centerstand.
6. Check and, if necessary, correct
the tire air pressure, and then lift
the scooter so that both of its
wheels are off the ground. Alter-
natively, turn the wheels a little
every month in order to prevent
the tires from becoming degra-
ded in one spot.
7. Cover the muffler outlet with a
plastic bag to prevent moisture
from entering it.
8. Remove the battery and fully
charge it. Store it in a cool, dry
place and charge it once a
month. Do not store the battery in
an excessively cold or warm pla-
ce [less than 0 °C (30 °F) or more
than 30 °C (90 °F)]. For more
7
SCOOTER CARE AND STORAGE
7-3
5XL-F8199-E3.qxd 19/09/2005 16:26 Página 56
AAcceleration and deceleration ...................5-2
Adjusting the brake lever free play ..........6-15
Adjusting the carburetor ..........................6-12
Adjusting the rear shock absorber
assemblies ...............................................3-8
Air filter and V-belt case air filter
elements ................................................6-11
BBattery......................................................6-18
Battery voltage/fuel gauge .........................3-3
Braking .......................................................5-2
CCare............................................................7-1
Clock ..........................................................3-4
Controls and Instruments ..........................2-3
Coolant.....................................................6-10
Changing the brake fluid..........................6-16
Checking and lubricating the cables .......6-16
Checking and lubricating the centerstand
and sidestand ........................................6-17
Checking the brake fluid level .................6-15
Checking the front and rear brake pads..6-15
Checking the front fork ............................6-17
Checking the spark plug ............................6-6
Checking the steering ..............................6-17
Checking the throttle cable free play.......6-12
Checking the wheel bearings ..................6-18
EEngine oil ...................................................6-7
FFinal gear oil...............................................6-9
Front brake lever ........................................3-5
Front storage compartment .......................3-7Fuel ............................................................3-6
Fuel tank cap .............................................3-6
HHandlebar switches ...................................3-4
IIdentification numbers ...............................9-1
Indicator lights ...........................................3-1
LLeft view .....................................................2-1
MMain switch ................................................3-1
Model label ................................................9-2
OOwner’s tool kit ..........................................6-1
PParking .......................................................5-3
Periodic maintenance and lubrication
chart .........................................................6-2
Pre-operation check list .............................4-2
RRear brake lever .........................................3-6
Removing and installing cowlings and
panels ......................................................6-5
Replacing a front turn signal light bulb....6-21
Replacing the fuse ...................................6-20
Replacing the headlight bulb or a front
turn signal light bulb ..............................6-20
Replacing the license plate light bulb......6-21
Replacing the tail/brake light bulb or a
rear turn signal light bulb.......................6-22
Right view ..................................................2-2
SSeat ............................................................3-7
Sidestand ...................................................3-8Sidestand switch operation check ............3-9
Speedometer unit ......................................3-3
Starting a cold engine ................................5-1
Starting off .................................................5-2
Storage.......................................................7-3
Storage compartment ................................3-7
TTires .........................................................6-13
Troubleshooting .......................................6-23
Troubleshooting chart ..............................6-24
INDEX
5XL-F8199-E3.qxd 19/09/2005 16:26 Página 62
