2006 YAMAHA MAJESTY 125 check engine light

4. Add the recommended final gear
oil to the brim of the filler hole.
5. Install the oil filler bolt, and then
tighten it to the specified torque.
6. Check the final gear case for oil
leakage. If oil is leaking, check for
the cause.
EAU20070
Coolant
1. Maximum level
2. Minimum level
The coolant level should be checked
before each ride. In addition, the coo-
lant must be changed at the intervals
specified in the periodic maintenance
and lubrication chart.
EAUS1080
To check the coolant level
1. Place the vehicle on a level surfa-
ce and hold it in an upright posi-
tion.
NOTE:
The coolant level must be chec-
ked on a cold engine since the
level varies with engine tempera-
ture.
Make sure that the vehicle is
positioned straight up when
checking the coolant level. A
slight tilt to the side can result in
a false reading.
1. Coolant tank cap
2. Check the coolant level through
the check window.
NOTE:
The coolant should be between the
minimum and maximum level marks.
1
1
2
Recommended final gear oil:
Shaft drive gear oil (Part No.:
9079E-SH001-00)
Oil quantity:
0,15 L (0,033 US qt) (0,132 Imp.qt)
Tightening torque:
Final gear oil drain bolt:
22 Nm (2,2 m•kgf, 15,91 ft•lbf)
6
PERIODIC MAINTENANCE AND MINOR REPAIR
6-10
5XL-F8199-E3.qxd 19/09/2005 16:26 Página 39

3. If the coolant is at or below the
minimum level mark, remove the
front cowling by removing the
screws.
4. Open the reservoir cap, and then
add coolant to the maximum
level mark.
ECA10470
CAUTION
If coolant is not available, use
distilled water or soft tap water
instead. Do not use hard water
or salt water since it is harmful
to the engine.
If water has been used instead
of coolant, replace it with coo-
lant as soon as possible, other-
wise the engine may not be
sufficiently cooled and the coo-
ling system will not be protec-
ted against frost and corrosion.
If water has been added to the
coolant, have a Yamaha dealer
check the antifreeze content of
the coolant as soon as possi-
ble, otherwise the effective-
ness of the coolant will be
reduced.
5. Close the reservoir cap, and then
install the front cowling by insta-
lling the screws.
EAUM1320
Air filter and V-belt case air
filter elements
The air filter and the V-belt case air fil-
ter elements should be cleaned at the
intervals specified in the periodic
maintenance and lubrication chart.
Clean both filter elements more fre-
quently if you are riding in unusually
wet or dusty areas.Cleaning the air filter element
1. Air filter case cover
2. Screw (x 1)
1. Place the scooter on the centers-
tand.
2. Remove the air filter case cover
by removing the screws.
3. Pull the air filter element out.
1. Air filter
4. Lightly tap the air filter element to
remove most of the dust and dirt,
1
1
2
Coolant reservoir capacity:
0,45 L (0,099 US qt) (0,396 Imp.qt)
6
PERIODIC MAINTENANCE AND MINOR REPAIR
6-11
5XL-F8199-E3.qxd 19/09/2005 16:26 Página 40

AAcceleration and deceleration ...................5-2
Adjusting the brake lever free play ..........6-15
Adjusting the carburetor ..........................6-12
Adjusting the rear shock absorber
assemblies ...............................................3-8
Air filter and V-belt case air filter
elements ................................................6-11
BBattery......................................................6-18
Battery voltage/fuel gauge .........................3-3
Braking .......................................................5-2
CCare............................................................7-1
Clock ..........................................................3-4
Controls and Instruments ..........................2-3
Coolant.....................................................6-10
Changing the brake fluid..........................6-16
Checking and lubricating the cables .......6-16
Checking and lubricating the centerstand
and sidestand ........................................6-17
Checking the brake fluid level .................6-15
Checking the front and rear brake pads..6-15
Checking the front fork ............................6-17
Checking the spark plug ............................6-6
Checking the steering ..............................6-17
Checking the throttle cable free play.......6-12
Checking the wheel bearings ..................6-18
EEngine oil ...................................................6-7
FFinal gear oil...............................................6-9
Front brake lever ........................................3-5
Front storage compartment .......................3-7Fuel ............................................................3-6
Fuel tank cap .............................................3-6
HHandlebar switches ...................................3-4
IIdentification numbers ...............................9-1
Indicator lights ...........................................3-1
LLeft view .....................................................2-1
MMain switch ................................................3-1
Model label ................................................9-2
OOwner’s tool kit ..........................................6-1
PParking .......................................................5-3
Periodic maintenance and lubrication
chart .........................................................6-2
Pre-operation check list .............................4-2
RRear brake lever .........................................3-6
Removing and installing cowlings and
panels ......................................................6-5
Replacing a front turn signal light bulb....6-21
Replacing the fuse ...................................6-20
Replacing the headlight bulb or a front
turn signal light bulb ..............................6-20
Replacing the license plate light bulb......6-21
Replacing the tail/brake light bulb or a
rear turn signal light bulb.......................6-22
Right view ..................................................2-2
SSeat ............................................................3-7
Sidestand ...................................................3-8Sidestand switch operation check ............3-9
Speedometer unit ......................................3-3
Starting a cold engine ................................5-1
Starting off .................................................5-2
Storage.......................................................7-3
Storage compartment ................................3-7
TTires .........................................................6-13
Troubleshooting .......................................6-23
Troubleshooting chart ..............................6-24
INDEX
5XL-F8199-E3.qxd 19/09/2005 16:26 Página 62