2006 TOYOTA TUNDRA engine oil

’06 TUNDRA_U (L/O 0508)
447
2006 TUNDRA from Oct. ’06 Prod. (OM 34458U)
Use only spark plugs of the speci-
fied type. Using other types will
cause engine damage, loss of per-
formance or radio noise.
 Do not reuse iridiumtipped spark
plugs by cleaning or regapping.
 Do not overfill automatic transmis-
sion fluid, or the transmission
could be damaged.
 Do not drive with the air cleaner
filter removed, or excessive engine
wear could result. Also backfiring
could cause a fire in the engine
compartment.
 Be careful not to scratch the glass
surface with the wiper frame.
 When closing the engine hood,
check to see that you have not for-
gotten any tools, rags, etc.Here is a list of parts and tools you will
need to perform do− it−yourself mainte-
nance. Remember all Toyota parts are de-
signed in metric sizes, so your tools must
be metric.
CHECKING THE ENGINE OIL LEVEL
Parts (if level is low):
“Toyota Genuine Motor Oil” or equiva-
lent
See Section 7 −2 for details about en-
gine oil selection.
Tools:
Rag or paper towel
Funnel (only for adding oil)
CHECKING THE ENGINE COOLANT
LEVEL
Parts (if level is low):
“Toyota Super Long Life Coolant” or
similar high quality ethylene glycol
based non −silicate, non −amine, non− ni-
trite, and non −borate coolant with long −
life hybrid organic acid technology.
“Toyota Super Long Life Coolant” is a
mixture of 50% coolant and 50% deion-
ized water (for the U.S.A.) or 55%
coolant and 45% deionized water (for
Canada). Tools:
Funnel (only for adding coolant)
CHECKING BRAKE FLUID
Parts (if level is low):
SAE J1703 or FMVSS No.116 DOT 3
brake fluid
Tools:
Rag or paper towel
Funnel (only for adding fluid)
CHECKING POWER STEERING FLUID
Parts (if level is low):
Automatic transmission fluid
DEXRON II or III
Tools:
Rag or paper towel
Funnel (only for adding fluid)
CHECKING BATTERY CONDITION
Tools:
Warm water
Baking soda
Grease
Conventional wrench (for terminal
clamp bolts)
Parts and tools

’06 TUNDRA_U (L/O 0508)
449
2006 TUNDRA from Oct. ’06 Prod. (OM 34458U)
DOITYOURSELF MAINTENANCE
Engine and Chassis
Checking the engine oil level 450
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Checking the engine coolant level 452
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Checking the radiator and condenser 453
. . . . . . . . . . . . . . . . . . . . . . . . .
Checking brake fluid 453
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . .
Checking power steering fluid 455
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Checking tire inflation pressure 456
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Checking and replacing tires 459
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rotating tires 461
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . . .
Installing snow tires and chains 462
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Replacing wheels 463
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . .
Aluminum wheel precautions 464
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
SECTION 7 2

’06 TUNDRA_U (L/O 0508)
450
2006 TUNDRA from Oct. ’06 Prod. (OM 34458U)
Low level Full level
Add oil O.K. Too full
4.0 L V6 (1GRFE) engine
Low level Full level
Add oil O.K. Too full
4.7 L V8 (2UZFE) engine
With the engine at operating tempera-
ture and turned off, check the oil level
on the dipstick. 1. To get a correct reading, the vehicle should be on level ground. After turning
off the engine, wait a few minutes for
the oil to drain back into the bottom of
the engine.
2. Pull the dipstick out, hold a rag under the end and wipe it clean.
3. Reinsert the dipstick—push it in as far as it will go, or the reading will not be
correct.
4. Pull the dipstick out and look at the oil level while holding a rag under the
end.
CAUTION
Be careful not to touch the hot ex-
haust manifold.
NOTICE
Be careful not to drop engine oil on
the vehicle components.
If the oil level is below or only slightly
above the low level, add engine oil of
the same type as already in the engine.
Remove the oil filler cap and add engine
oil in small quantities at a time, checking
the dipstick. We recommend that you use
a funnel when adding oil.
The approximate quantity of oil needed to
raise the level between low and full on the
dipstick is indicated as follows:1.5 L (1.6 qt., 1.3 lmp. qt.)
For the engine oil capacity, see “Service
specifications” in Section 8.
When the level reaches within the correct
range, install the filler cap hand− tight.
NOTICE
Be careful not to spill engine oil on
the vehicle components.
 Avoid overfilling, or the engine
could be damaged.
 Check the oil level on the dipstick
once again after adding the oil.
Checking the engine oil level

’06 TUNDRA_U (L/O 0508)
451
2006 TUNDRA from Oct. ’06 Prod. (OM 34458U)
Engine oil selection
“Toyota Genuine Motor Oil” is used in
your Toyota vehicle. Use Toyota approved
“Toyota Genuine Motor Oil” or equivalent
to satisfy the following grade and
viscosity.
Oil grade:
ILSAC multigrade engine oil
Recommended viscosity: SAE 5W −30
Outside temperature
SAE 5W30 is the best choice for good
fuel economy and good starting in cold
weather.
If SAE 5W30 is not available, SAE
10W30 may be used. However, it
should be replaced with SAE 5W30 at
the next oil change.
Oil identification mark
The ILSAC (International Lubricant Stan-
dardization and Approval Committee) Certi-
fication Mark is added to some oil con-
tainers to help you select the oil you
should use.

’06 TUNDRA_U (L/O 0508)
452
2006 TUNDRA from Oct. ’06 Prod. (OM 34458U)
To ensure excellent lubrication perfor-
mance for your engine, “Toyota Genuine
Motor Oil” is available, which has been
specifically tested and approved for all
Toyota engines.
Please contact your Toyota dealer for fur-
ther details about “Toyota Genuine Motor
Oil”. Look at the seethrough coolant reser-
voir when the engine is cold. The cool-
ant level is satisfactory if it is between
the “F” and “L” lines on the reservoir.
If the level is low, add the coolant. (For
the coolant type, see “Coolant type
selection” described below.)
The coolant level in the reservoir will vary
with engine temperature. However, if the
level is on or below the “L” line, add
coolant. Bring the level up to the “F” line.
If the coolant level drops within a short
time after replenishing, there may be a
leak in the system. Visually check the
radiator, hoses, radiator cap and drain
cock and water pump.
If you can find no leak, have your Toyota
dealer test the cap pressure and check
for leaks in the cooling system.
CAUTION
To prevent burning yourself, do not
remove the radiator cap when the en-
gine is hot.
Coolant type selection
Use of improper coolants may damage
your engine cooling system.
Only use “Toyota Super Long Life Coolant”
or similar high quality ethylene glycol
based non
−silicate, non −amine, non− nitrite,
and non− borate coolant with long −life
hybrid organic acid technology. (Coolant
with long −life hybrid organic acid
technology is a combination of low
phosphates and organic acids.)
For the U.S.A.—“Toyota Super Long Life
Coolant” is a mixture of 50% coolant and
50% deionized water. This coolant pro-
vides protection down to about −35 C
( − 31 F).
For the Canada—“Toyota Super Long Life
Coolant” is a mixture of 55% coolant and
45% deionized water. This coolant pro-
vides protection down to about −42 C
( − 44 F).
NOTICE
Do not use plain water alone.
Checking the engine coolant
level

’06 TUNDRA_U (L/O 0508)
488
2006 TUNDRA from Oct. ’06 Prod. (OM 34458U)
ENGINE LUBRICATION
Oil capacity (drain and refill), L (qt., Imp.
qt.):
4.0 L V6 (1GR −FE) engine
With filter 4.5 (4.8, 4.0)
Without filter 4.2 (4.4, 3.7)
4.7 L V8 (2UZ −FE) engine
With filter 6.2 (6.5, 5.5)
Without filter 5.7 (6.0, 5.0)
“Toyota Genuine Motor Oil” is used in
your Toyota vehicle. Use Toyota approved
“Toyota Genuine Motor Oil” or equivalent
to satisfy the following grade and
viscosity.
Oil grade: ILSAC multigrade engine oil Recommended oil viscosity:
SAE 5W −30
Outside temperature
Please contact your Toyota dealer for fur-
ther details.
COOLING SYSTEM
Total capacity, L (qt., Imp. qt.):
With manual transmission 10.4 (11.0, 9.2)
With automatic transmission 4.0 L V6 (1GR −FE) engine
10.3 (10.9, 9.1)
4.7 L V8 (2UZ −FE) engine
Standard and access cab models 12.6 (13.0, 11.1)
Double cab models
12.8 (13.5, 11.3) Coolant type:
“Toyota Super Long Life Coolant” is
used in your Toyota vehicle at factory
fill. In order to avoid technical problems,
only use “Toyota Super Long Life
Coolant” or similar high quality ethylene
glycol based non −silicate, non −amine,
non− nitrite, and non− borate coolant with
long− life hybrid organic acid technology.
(Coolant with long −life hybrid organic
acid technology is a combination of low
phosphates and organic acids.)
Do not use plain water alone.
Please contact your Toyota dealer for
further details.
BATTERY
Open voltage∗ at 20 C (68 F):
12.6—12.8 V Fully charged
12.2—12.4 V Half charged
11.8—12.0 V Discharged
∗: Voltage that is checked 20 minutes af-
ter the key is removed with all the
lights turned off
Charging rates: 5 A max.

’06 TUNDRA_U (L/O 0508)
490
2006 TUNDRA from Oct. ’06 Prod. (OM 34458U)
Recommended oil viscosity:
FrontSAE 75W −90
Rear Standard differential
Synthetic oil SAE 75W −140
Limited− slip differential
Above −18 C (0 F)
SAE 90
Below −18 C (0 F)
SAE 80W or 80W −90
CHASSIS LUBRICATION
(Fourwheel drive models)
Propeller shafts: SpidersLithium base chassis grease, NLGI
No.2
Double cardan joint Molybdenum −disulfide lithium base
chassis grease, NLGI No.2
Slide yokes Lithium base chassis grease, NLGI
No.2 or Molybdenum −disulfide lithium
base chassis grease, NLGI No.2 BRAKES
Minimum pedal clearance when depressed
with the force of 490 N (50 kgf, 110 lbf)
with the engine running, mm (in.):
Without vehicle stability control system95 (3.7)
With vehicle stability control system 80 (3.1)
Pedal free play, mm (in.): 1—6 (0.04—0.24)
Pad wear limit, mm (in.): 1.0 (0.04)
Lining wear limit, mm (in.): 1.0 (0.04)
Parking brake adjustment: Pedal type—when depressed with the
force of 300 N (30.6 kgf, 67.1 lbf)8—10 clicks
Lever type—when pulled with the force
of 200 N (20.4 kgf, 45 lbf) 19—25 clicks
Fluid type: SAE J1703 or FMVSS No.116 DOT 3 STEERING
Wheel free play:
Less than 30 mm (1.2 in.)
Power steering fluid type: Automatic transmission fluid DEXRON II
or III

’06 TUNDRA_U (L/O 0508)
505
2006 TUNDRA from Oct. ’06 Prod. (OM 34458U)
A
“AUTO LSD” system 201
. . . . . . . . . . . . . . . . . .
Access doors 24
. . . . . . . . . . . . . . . . . . . . . . . . .
Adding washer fluid 469
. . . . . . . . . . . . . . . . . .
Adjustment
Front seats 54,55
. . . . . . . . . . . . . . . . . . . . . .
Seat belt 63
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Air conditioning system 306
. . . . . . . . . . . . . . .
Airbags 75,85,92,102,108
. . . . . . . . . . . . . . . .
Aluminum wheel precautions 464
. . . . . . . . . .
Anti −glare inside rear view mirror 156 . . . . . .
Anti −lock brake system
warning light 178
. . . . . . . . . . . . . . . . . . . . . . .
Anti −theft steering column lock 190 . . . . . . . .
Appearance care
Cleaning the interior 431
. . . . . . . . . . . . . . . .
Protecting your Toyota from corrosion 428
. . . . . . . . . . . . . . . . . . .
Washing and waxing 429
. . . . . . . . . . . . . . . .
Armrest 62
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Ashtray 327
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Audio system 218,242
. . . . . . . . . . . . . . . . . . . .
Audio/video system 251
. . . . . . . . . . . . . . . . . .
Audio/video system operating tips 299 . . . . . .
Automatic transmission
Driving with an automatic transmission 191
. . . . . . . . . . . . . . . . . . . . .
Shift pattern 191
. . . . . . . . . . . . . . . . . . . . . . .
Shifting speed 191
. . . . . . . . . . . . . . . . . . . . .
Automatic transmission fluid temperature warning light 178
. . . . . . . . . . .
Auxiliary boxes 335
. . . . . . . . . . . . . . . . . . . . . .
Auxiliary catch, Engine hood 42
. . . . . . . . . . .
B
Back window 38
. . . . . . . . . . . . . . . . . . . . . . . . .
Back window and outside rear view mirror defogger switch 171
. . . . . . . . .
Battery
Checking battery condition 466
. . . . . . . . . .
Gas caution 466
. . . . . . . . . . . . . . . . . . . . . . .
Handling safety 466
. . . . . . . . . . . . . . . . . . . .
Recharging precautions 467
. . . . . . . . . . . . .
Winter driving tips 386
. . . . . . . . . . . . . . . . . .
Before starting the engine 382
. . . . . . . . . . . . .
Brake pad wear limit indicators 364 . . . . . . . .
Brake system 358
. . . . . . . . . . . . . . . . . . . . . . . .
Brake system warning light and buzzer 178
. . . . . . . . . . . . . . . . . . . .
Brakes
Fluid level 453,454
. . . . . . . . . . . . . . . . . . . . .
Pad wear limit indicators 364
. . . . . . . . . . . .
Parking 213
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Break −in tips 351
. . . . . . . . . . . . . . . . . . . . . . . .
Brightness control 164
. . . . . . . . . . . . . . . . . . . .
C
Carbon monoxide caution 355
. . . . . . . . . . . . .
Cargo and luggage
Capacity 376
. . . . . . . . . . . . . . . . . . . . . . . . . .
Capacity and distribution 377
. . . . . . . . . . . .
Stowage precautions 377
. . . . . . . . . . . . . . .
Cargo lamp 168
. . . . . . . . . . . . . . . . . . . . . . . . . .
Cargo net hooks 346
. . . . . . . . . . . . . . . . . . . . .
Cassette player 218
. . . . . . . . . . . . . . . . . . . . . .
Cassette tape holder 342
. . . . . . . . . . . . . . . . .
Center vents 313
. . . . . . . . . . . . . . . . . . . . . . . . . Certification label
365
. . . . . . . . . . . . . . . . . . . .
Charging system warning light 178
. . . . . . . . .
Checking and replacing fuses 468
. . . . . . . . .
Checking brake fluid 453,454
. . . . . . . . . . . . . .
Checking the engine oil level 450
. . . . . . . . . .
Checking the radiator and condenser 453
. . . . . . . . . . . . . . . . . . . . . . . . .
Child restraint
Child restraint system 117
. . . . . . . . . . . . . .
Installation 119,128
. . . . . . . . . . . . . . . . . . . .
Installation with child restraint lower anchorages 146,148,150 . . . . . . . .
Precautions 115
. . . . . . . . . . . . . . . . . . . . . . .
Types of child restraint system 118 . . . . . . .
Using a top strap 138,140,144
. . . . . . . . . . .
Cigarette lighter 327
. . . . . . . . . . . . . . . . . . . . . .
Cleaning the interior 431
. . . . . . . . . . . . . . . . . .
Clock 327
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Coin holder 338,339,340
. . . . . . . . . . . . . . . . . .
Cold weather
Operation 386
. . . . . . . . . . . . . . . . . . . . . . . . .
Compact disc and cassette tape holder
Cassette tape holder 341,342
. . . . . . . . . . .
Compact disc holder 341,342
. . . . . . . . . . . .
Compact disc changer 218
. . . . . . . . . . . . . . . .
Compact disc changer controller 218 . . . . . . .
Compact disc player 218
. . . . . . . . . . . . . . . . . .
Compass 323
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Condenser
Checking the condenser 453
. . . . . . . . . . . .
Console box
Rear 336,337
. . . . . . . . . . . . . . . . . . . . . . . . . .
Controls, Instrument panel 2,7,11
. . . . . . . . . .