2006 TOYOTA RAV4 transmission

’06 Rav4_U (L/O 0601)
366
2005 RAV4 from Jan. ’06 Prod. (OM42620U)
When jacking up your vehicle with the
jack, position the jack correctly as
shown in the illustrations.
CAUTION
When jacking, be sure to observe the
following to reduce the possibility of
death or serious injury:
Follow jacking instructions.
Do not put any part of your body
under the vehicle supported by the
jack. Personal injury may occur.
Do not start or run the engine while
your vehicle is supported by the
jack.
Stop the vehicle on a level firm
ground, firmly set the parking brake
and put the transmission in “P”.
Block the wheels on the opposite
side of the jack up point if neces-
sary.
Make sure to set the jack properly
in the jack point. Raising the ve-
hicle with jack improperly posi-
tioned will damage the vehicle or
may allow the vehicle to fall off the
jack and cause personal injury.
Never get under the vehicle when
the vehicle is supported by the jack
alone; use vehicle support stands.
Do not raise the vehicle with some-
one in the vehicle.
When raising the vehicle, do not
place any objects on top of or un-
derneath the jack.
NOTICE
Make sure to place the jack correctly,
or your vehicle may be damaged.

’06 Rav4_U (L/O 0601)
395
2005 RAV4 from Jan. ’06 Prod. (OM42620U)
COOLING SYSTEMTotal capacity, L(qt., lmp. qt.):2.4 L 4 −cylinder (2AZ −FE) engine
6.8 (7.2, 5.9)
3.5 L V6 (2GR −FE) engine
Without towing package 8.9 (9.4, 7.8)
With towing package
9.3 (9.8, 8.2)
Coolant type:
“Toyota Super Long Life Coolant” is
used in your Toyota vehicle at factory
fill. In order to avoid technical problems,
only use “Toyota Super Long Life
Coolant” or similar high quality ethylene
glycol based non −silicate, non −amine,
non− nitrite, and non− borate coolant with
long− life hybrid organic acid technology.
(Coolant with long −life hybrid organic
acid technology is a combination of low
phosphates and organic acids.)
Do not use plain water alone.
Please contact your Toyota dealer for
further details. BATTERY
Open voltage
∗
at 20 C (68 F):
12.6—12.8 V Fully charged
12.2—12.4 V Half charged
11.8—12.0 V Discharged
∗: Voltage that is checked 20 minutes af-
ter the key is removed with all the lights
turned off
Charging rates: 5 A max.
AUTOMATIC TRANSAXLE
Fluid capacity (drain and refill), L (qt.,
Imp. qt.): Up to 3.5 (3.7, 3.1)
Fluid type: Toyota Genuine ATF Type WS
Change automatic transmission fluid only
as necessary.
Generally, it is necessary to change
automatic transmission fluid only if your
vehicle is driven under one of the Special
Operating Conditions listed in your
“Scheduled Maintenance Guide” or
“Owner ’s Manual Supplement”. When
changing the automatic transmission fluid,
use only “Toyota Genuine ATF Type WS”
(ATF JWS3324 or NWS9638) to aid in
assuring optimum transaxle performance. Notice: Using automatic transmission
fluid other than “Toyota Genuine ATF
Type WS” may cause deterioration in
shift quality, locking up of your trans-
mission accompanied by vibration, and
ultimately damage the automatic trans-
mission of your vehicle.
Please contact your Toyota dealer for fur-
ther details.
TRANSFER
(fourwheel drive models)
Oil capacity, L (qt., Imp. qt.):
0.5 (0.5, 0.4)
Oil type: Hypoid gear oil API GL −5
Recommended oil viscosity: Above −18 C (0 F)
SAE 90
Below −18 C (0 F)
SAE 80W −90

’06 Rav4_U (L/O 0601)
400
2005 RAV4 from Jan. ’06 Prod. (OM42620U)
INSTRUMENT PANEL1. SHTR 15 A: Seat heaters
2. WIP 25 A: Windshield wipers
3. RR WIP 15 A: Rear window wiper
4. WSH 15 A: Windshield washer, rear
window washer
5. ECUIG1 10 A: Electric cooling fan,
anti −lock brake system, traction control
system, vehicle stability control system,
“AUTO LSD” system, downhill assist
control system, hill −start assist control
system, active torque control 4WD sys-
tem, tire pressure monitor system, au-
tomatic transmission shift lock system,
air conditioning system, main body
ECU, electric moon roof, stop/tail
lights, windshield wiper de −icer, electric
power steering system, clock, AC in-
verter
6. ECUIG2 10 A: Air conditioning sys-
tem, rear window defogger
7. OBD 7.5 A: On−board diagnosis sys-
tem 8. STOP 10 A:
Stop/tail lights, high
mounted stoplight, automatic transmis-
sion shift lock system, multiport fuel
injection system/sequential multiport
fuel injection system, anti −lock brake
system, traction control system, vehicle
stability control system, “AUTO LSD”
system, downhill assist control system,
hill −start assist control system
9. DOOR 25 A: Main body ECU, power
door lock system
10. ACCB 25 A: “ACC”, “CIG” fuses
11. 4WD 7.5 A: Active torque control 4WD
system
12. FR FOG 15 A: Front fog lights
13. AM1 7.5 A: Starting system
14. TAIL 10 A: Tail lights, parking lights,
license plate light, front fog lights, rear
side marker lights
15. PANEL 7.5 A: Clock, instrument panel
lights, audio system
16. GAUGE1 10 A: Buck−up lights, charg-
ing system
17. D FR DOOR 20 A: Power window
(front doors)
18. RL DOOR 20 A: Power window (rear
left door)

’06 Rav4_U (L/O 0601)
401
2005 RAV4 from Jan. ’06 Prod. (OM42620U)
19. RR DOOR 20 A: Power window (rear
right door)
20. S/ROOF 25 A: Electric moon roof
21. CIG 15 A: No circuit
22. ACC 7.5 A: Audio system, power out-
lets, power rear view mirror control,
automatic transmission shift lock sys-
tem, main body ECU, clock, rear seat
entertainment system
23. MIR HTR 10 A: Outside rear view mir-
ror heaters
24. PWR OUTLET 15 A: Power outlets
25. RR FOG 10 A: No circuit
26. IGN 7.5 A: SRS airbag system, multi-
port fuel injection system/sequential
multiport fuel injection system, front
passenger occupant classification sys-
tem, starting system
27. GAUGE2 7.5 A: Meters and gauges
28. DEF 30 A: Rear window defogger,
“MIR HTR” fuses
29. P/SEAT 30 A: Power seat
30. POWER 30 A: Power windows

’06 Rav4_U (L/O 0601)
406
2005 RAV4 from Jan. ’06 Prod. (OM42620U)
A
“ABS” warning light127
. . . . . . . . . . . . . . . . . . .
“AUTO LSD” system 151
. . . . . . . . . . . . . . . . . .
Active torque control 4WD system 148 . . . . .
Adding washer fluid 386
. . . . . . . . . . . . . . . . . .
Adjustment
Front seats 36,37
. . . . . . . . . . . . . . . . . . . . . .
Rear/second seat 39
. . . . . . . . . . . . . . . . . . .
Seat belt 53
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Air conditioning filter 252
. . . . . . . . . . . . . . . . . .
Air conditioning system
Automatic air conditioning system 244 . . . .
Manual air conditioning system 238 . . . . . .
Airbags 64,71,81
. . . . . . . . . . . . . . . . . . . . . . . .
Aluminum wheel precautions 380
. . . . . . . . . .
Anti −glare inside rear view mirror 110 . . . . . .
Anti −theft steering column lock 140 . . . . . . . .
Appearance care
Cleaning the interior 349
. . . . . . . . . . . . . . . .
Protecting your Toyota from corrosion 346
. . . . . . . . . . . . . . . . . . .
Washing and waxing 347
. . . . . . . . . . . . . . . .
Armrest 51
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Audio system 170
. . . . . . . . . . . . . . . . . . . . . . . .
Audio system
AUX 188
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Audio/video system 191
. . . . . . . . . . . . . . . . . .
Audio/video system operating tips 229 . . . . . .
Automatic air conditioning system 244 . . . . . . Automatic transmission
Driving with an automatic transmission 141,145
. . . . . . . . . . . . . . . . .
Shift lock override button 342
. . . . . . . . . . . .
Shift pattern 141,145
. . . . . . . . . . . . . . . . . . .
Shifting speed 141,145
. . . . . . . . . . . . . . . . .
Automatic transmission fluid temperature warning light 127 . . . . . . .
AUX 188
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Auxiliary box 259,260
. . . . . . . . . . . . . . . . . . . .
Auxiliary catch, Engine hood 27
. . . . . . . . . . .
B
Back door 26
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Battery
Checking battery condition 382
. . . . . . . . . .
Gas caution 382
. . . . . . . . . . . . . . . . . . . . . . .
Handling safety 382
. . . . . . . . . . . . . . . . . . . .
Recharging precautions 384
. . . . . . . . . . . . .
Winter driving tips 309
. . . . . . . . . . . . . . . . . .
Before starting the engine 306
. . . . . . . . . . . . .
Bottle holders 263
. . . . . . . . . . . . . . . . . . . . . . . .
Brake pad wear limit indicators 287 . . . . . . . .
Brake system 283
. . . . . . . . . . . . . . . . . . . . . . . .
Brake system warning light 127
. . . . . . . . . . . .
Brakes
Fluid level 371
. . . . . . . . . . . . . . . . . . . . . . . . .
Pad wear limit indicators 287
. . . . . . . . . . . .
Parking 165
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Break −in tips 277
. . . . . . . . . . . . . . . . . . . . . . . .
Brightness control 116
. . . . . . . . . . . . . . . . . . . .
C
Carbon monoxide caution 281
. . . . . . . . . . . . .
Cargo and luggage
Capacity 300
. . . . . . . . . . . . . . . . . . . . . . . . . .
Capacity and distribution 302
. . . . . . . . . . . .
Stowage precautions 301
. . . . . . . . . . . . . . .
Cargo net 269
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Certification label 289
. . . . . . . . . . . . . . . . . . . .
Charging system warning light 127
. . . . . . . . .
Checking and replacing fuses 384
. . . . . . . . .
Checking and replacing the air conditioning filter 252
. . . . . . . . . . . . . . . . . . .
Checking brake fluid 371
. . . . . . . . . . . . . . . . . .
Checking the engine oil level 368
. . . . . . . . . .
Checking the radiator and
condenser 371
. . . . . . . . . . . . . . . . . . . . . . . . .
Child restraint
Child restraint system 86
. . . . . . . . . . . . . . .
Installation 88
. . . . . . . . . . . . . . . . . . . . . . . . .
Installation with child restraint lower anchorages 104
. . . . . . . . . . . . . . . .
Precautions 85
. . . . . . . . . . . . . . . . . . . . . . . .
Types of child restraint system 87 . . . . . . . .
Using a top strap 100
. . . . . . . . . . . . . . . . . . .
Cleaning the interior 349
. . . . . . . . . . . . . . . . . .
Clock 256
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cold weather
Operation 309
. . . . . . . . . . . . . . . . . . . . . . . . .
Compact disc changer 170
. . . . . . . . . . . . . . . .
Compact disc changer controller 170 . . . . . . .
Compact disc player 170
. . . . . . . . . . . . . . . . . .
Condenser
Checking the condenser 371
. . . . . . . . . . . .
Console box
Rear 261
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

’06 Rav4_U (L/O 0601)
407
2005 RAV4 from Jan. ’06 Prod. (OM42620U)
Controls, Instrument panel2,7
. . . . . . . . . . . .
Cooling system
Coolant level 370
. . . . . . . . . . . . . . . . . . . . . .
Engine overheating 324
. . . . . . . . . . . . . . . . .
Radiator and reservoir 370
. . . . . . . . . . . . . .
Radiator cap 324
. . . . . . . . . . . . . . . . . . . . . . .
Winter driving tips 309
. . . . . . . . . . . . . . . . . .
Corrosion prevention 346
. . . . . . . . . . . . . . . . .
Cruise control 166
. . . . . . . . . . . . . . . . . . . . . . .
Cup holder
Front 262
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear 262
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
D
Defogger
Outside rear view mirror 122 . . . . . . . . . . . .
Rear window 122
. . . . . . . . . . . . . . . . . . . . . . .
Dimmer switch, Headlight 114
. . . . . . . . . . . . .
Dinghy towing 311
. . . . . . . . . . . . . . . . . . . . . . .
Directional signals 114
. . . . . . . . . . . . . . . . . . .
Do −it−yourself maintenance
Parts and tools 364
. . . . . . . . . . . . . . . . . . . . .
Service precautions 363
. . . . . . . . . . . . . . . .
Does your vehicle need repairing? 357 . . . . .
Doors
Back door 26
. . . . . . . . . . . . . . . . . . . . . . . . . .
Side doors 22
. . . . . . . . . . . . . . . . . . . . . . . . .
Downhill assist control system 156
. . . . . . . . .
Driver ’s seat belt reminder buzzer 127 . . . . . .
Driver ’s seat belt reminder light 127 . . . . . . . .
Driving
Automatic transmission 141,145
. . . . . . . . .
Driving tips 306
. . . . . . . . . . . . . . . . . . . . . . . . Driving tips
Driving tips in various conditions 307 . . . . .
Driving with an automatic transmission 141,145
. . . . . . . . . . . . . . . . .
Economical driving 317
. . . . . . . . . . . . . . . . .
Good driving practice 141,145
. . . . . . . . . . .
Winter driving tips 309
. . . . . . . . . . . . . . . . . .
During
Break −in 277
. . . . . . . . . . . . . . . . . . . . . . . . . .
DVD player 191
. . . . . . . . . . . . . . . . . . . . . . . . . .
E
Economical driving
Saving money on both fuel and repairs 317 . . . . . . . . . . . . . . . . . . . . . .
Electric moon roof 30 . . . . . . . . . . . . . . . . . . . . .
Electric power steering system 287 . . . . . . . .
Electric power steering system warning light 127 . . . . . . . . . . . . . . . . . . . . . . .
Electrical system
Battery 382,384 . . . . . . . . . . . . . . . . . . . . . . . .
Fuse locations 362 . . . . . . . . . . . . . . . . . . . . .
Fuses 384 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Emergency flasher switch 115 . . . . . . . . . . . . .
Emergency, In case of
Blown fuse 384 . . . . . . . . . . . . . . . . . . . . . . . .
Emergency flasher switch 115 . . . . . . . . . . .
Flat tire 325 . . . . . . . . . . . . . . . . . . . . . . . . . . .
If you cannot increase engine speed 323 . . . . . . . . . . . . . . . . . . . .
If you cannot shift automatic transmission selector lever 342 . . . . . . . .
If you lose your keys 343 . . . . . . . . . . . . . . . . If your engine stalls while driving 323
. . . . .
If your vehicle becomes stuck 337 . . . . . . .
If your vehicle needs to be towed 337 . . . . .
If your vehicle will not start 320 . . . . . . . . . .
Jump starting 321 . . . . . . . . . . . . . . . . . . . . . .
Overheating 324 . . . . . . . . . . . . . . . . . . . . . . .
Towing 337 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Emissions Inspection and
Maintenance (I/M) programs 358 . . . . . . . . .
Engine
Before starting the engine 306 . . . . . . . . . . .
Checking the coolant level 370 . . . . . . . . . .
Emission control device 280 . . . . . . . . . . . . .
Engine compartment 360 . . . . . . . . . . . . . . .
Exhaust gas caution 281 . . . . . . . . . . . . . . . .
Hood release 27 . . . . . . . . . . . . . . . . . . . . . . .
Identification number 290 . . . . . . . . . . . . . . .
Oil consumption 282 . . . . . . . . . . . . . . . . . . . .
Oil level 368 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Overheating 324 . . . . . . . . . . . . . . . . . . . . . . .
Starting procedure 306 . . . . . . . . . . . . . . . . .
Three −way catalytic converters 280 . . . . . .
Engine coolant
Temperature gauge 124 . . . . . . . . . . . . . . . . .
Winter driving tips 309 . . . . . . . . . . . . . . . . . .
Engine coolant temperature gauge 124 . . . . .
Engine immobilizer system 15 . . . . . . . . . . . . .
Engine oil
Winter driving tips 309 . . . . . . . . . . . . . . . . . .
Engine oil replacement reminder light 127 . . . . . . . . . . . . . . . . . . . . . .
Exhaust gas caution 281 . . . . . . . . . . . . . . . . . .

’06 Rav4_U (L/O 0601)
409
2005 RAV4 from Jan. ’06 Prod. (OM42620U)
L
Light bulbs386
. . . . . . . . . . . . . . . . . . . . . . . . . .
Light bulbs
Back −up light 389
. . . . . . . . . . . . . . . . . . . . . .
Front fog light 389
. . . . . . . . . . . . . . . . . . . . . .
Front side marker light 389
. . . . . . . . . . . . . .
Front turn signal light 389
. . . . . . . . . . . . . . .
Headlight 388
. . . . . . . . . . . . . . . . . . . . . . . . . .
License plate light 390
. . . . . . . . . . . . . . . . . .
Parking light 389
. . . . . . . . . . . . . . . . . . . . . . .
Rear side marker light 389
. . . . . . . . . . . . . .
Rear turn signal light 389
. . . . . . . . . . . . . . .
Light, Interior
Interior light 117
. . . . . . . . . . . . . . . . . . . . . . .
Personal light 117
. . . . . . . . . . . . . . . . . . . . . .
Light, Luggage compartment 118
. . . . . . . . . .
Load capacity 300
. . . . . . . . . . . . . . . . . . . . . . . .
Lock
Back door 26
. . . . . . . . . . . . . . . . . . . . . . . . . .
Side doors 22
. . . . . . . . . . . . . . . . . . . . . . . . .
Steering column 140
. . . . . . . . . . . . . . . . . . .
Low engine oil pressure
warning light 127
. . . . . . . . . . . . . . . . . . . . . . .
Low fuel level warning light 127
. . . . . . . . . . . .
Low windshield washer fluid level warning light 127
. . . . . . . . . . . . . . . . . .
Luggage compartment light 118
. . . . . . . . . . . .
Luggage cover 264
. . . . . . . . . . . . . . . . . . . . . . .
Luggage storage box 260
. . . . . . . . . . . . . . . . .
M
Maintenance
Do −it−yourself maintenance 363 . . . . . . . . .
Does your vehicle need repairing? 357 . . . . . . . . . . . . . . . . . . . . . . .
General maintenance 355 . . . . . . . . . . . . . . .
Maintenance requirements 354 . . . . . . . . . .
Parts and tools 364 . . . . . . . . . . . . . . . . . . . . .
Where to go for service 354 . . . . . . . . . . . . .
Malfunction indicator lamp 358 . . . . . . . . . . . .
Malfunction indicator lamp
Emissions Inspection and Maintenance (I/M) programs 127 . . . . . . .
Service reminder indicator 127 . . . . . . . . . .
Manual air conditioning system 238 . . . . . . . .
Maximum allowable speed
Automatic transmission 141,145 . . . . . . . . .
Mirror
Anti −glare inside rear view 110 . . . . . . . . . .
Mirrors
Folding rear view 110 . . . . . . . . . . . . . . . . . . .
Outside rear view 108 . . . . . . . . . . . . . . . . . .
Power rear view 109 . . . . . . . . . . . . . . . . . . . .
Vanity 111 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Moon roof 30 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
N
New vehicle break −in 277 . . . . . . . . . . . . . . . . .
O
Odometer 125
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Off −road driving precautions 308
. . . . . . . . . .
Oil
Consumption 282
. . . . . . . . . . . . . . . . . . . . . .
Viscosity and grade 368
. . . . . . . . . . . . . . . .
Oil consumption 282
. . . . . . . . . . . . . . . . . . . . .
Open door warning light 127
. . . . . . . . . . . . . . .
Operation in foreign countries 279
. . . . . . . . .
Outside temperature display 126
. . . . . . . . . . .
Overheating, Engine 324
. . . . . . . . . . . . . . . . . .
Overheating, Engine coolant 124
. . . . . . . . . .
Overview
Engine compartment 360
. . . . . . . . . . . . . . .
P
Parking brake
Operation 165 . . . . . . . . . . . . . . . . . . . . . . . . .
Reminder light 165 . . . . . . . . . . . . . . . . . . . . .
Polishing 347 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Positioning the jack 365 . . . . . . . . . . . . . . . . . .
Power outlet 256,257 . . . . . . . . . . . . . . . . . . . . .
Power rear view mirror control 109 . . . . . . . . .
Power steering 287 . . . . . . . . . . . . . . . . . . . . . . .
Power window switches 24 . . . . . . . . . . . . . . . .
Preloaders
(seat belt pretensioners) 62 . . . . . . . . . . . . .
Pretensioners
(seat belt pretensioners) 62 . . . . . . . . . . . . .
Protecting your Toyota
from corrosion 346 . . . . . . . . . . . . . . . . . . . . .