2006 SUBARU OUTBACK brake pads replacement

Driving tips
8-7
– CONTINUED –ground from under your tires, resulting in
possible loss of traction and even vehicle
rollover.
y Always check your brakes for effective-
ness immediately after driving in sand,
mud or water. Do this by driving slowly
and stepping on the brake pedal. Repeat
that process several times to dry out the
brake discs and brake pads.
y Do not drive or park over or near flam-
mable materials such as dry grass or fall-
en leaves, as they may burn easily. The
exhaust system is very hot while the en-
gine is running and right after engine
stops. This could create a fire hazard.
y After driving through tall grass, mud,
rocks, sand, rivers, etc., check that there
is no grass, bush, paper, rags, stones,
sand, etc. adhering to or trapped on the
underbody. Clear off any such matter from
the underbody. If the vehicle is used with
these materials trapped or adhering to the
underbody, a mechanical breakdown or
fire could occur.
y Secure all cargo carried inside the vehi-
cle and make certain that it is not piled
higher than the seatbacks. During sudden
stops or jolts, unsecured cargo could be
thrown around in the vehicle and cause in-
jury. Do not pile heavy loads on the roof.
Those loads raise the vehicle’s center of
gravity and make it more prone to tip over. y If you must rock the vehicle to free it
from sand or mud, depress the accelera-
tor pedal slightly and move the selector le-
ver back and forth between “D” and “R” re-
peatedly. Do not race the engine. For the
best possible traction, avoid spinning the
wheels when trying to free the vehicle.
y When the road surface is extremely
slippery, you can obtain better traction by
starting the vehicle with the transmission
in 2nd than 1st (both for MT and AT).
y Never equip your vehi cle with tires larg-
er than those specified in this manual.
y Wash the vehicle’s underbody after off-
road driving. Suspension components are
particularly prone to dirt buildup, so they
need to be washed thoroughly.
y Frequent driving of an AWD vehicle un-
der hard-driving condit ions such as rough
roads or off roads will necessitate more
frequent replacement of engine oil, brake
fluid and transmission oil than that speci-
fied in the maintenance schedule de-
scribed in the “Warranty and Maintenance
Booklet”.
Remember that damage done to your
SUBARU while operating it off-road and
not using common sense precautions
such as those listed above is not eligible
for warranty coverage. Winter driving
„ Operation during cold weath-
er Carry some emergency equipment, such
as tire chains, a window scraper, a bag of
sand, flares, a small shovel, and jumper
cables.
Check the battery and cables. Cold tem-
peratures reduce battery capacity. The
battery must be in good condition to pro-
vide enough power for cold winter starts.
Use an engine oil of proper grade and vis-
cosity for cold weather. Heavy summer oil
will cause harder starting.
Keep the door locks from freezing by 800015

Maintenance and service
Replacement of brake pad and lining ............... 11-31Breaking-in of new brake pads and linings ......... 11-32
Parking brake stroke .......................................... 11-32
Tires and wheels ................................................ 11-33 Types of tires .......................................................... 11-33
Tire pressure monitoring system (TPMS)
(if equipped) .......................................................... 11-33
Tire inspection ........................................................ 11-34
Tire pressures and wear ........................................ 11-35
Wheel balance ........................................................ 11-37
Wear indicators ....................................................... 11-37
Tire rotation ............................................................. 11-37
Tire replacement ..................................................... 11-38
Wheel replacement ................................................. 11-38
Aluminum wheels ............................................... 11-39
Windshield washer fluid .................................... 11-39
Replacement of wiper blades ............................ 11-41 Windshield wiper blade assembly ........................ 11-41
Windshield wiper blade rubber ............................. 11-42
Rear window wiper blade assembly ..................... 11-42
Rear window wiper blade rubber .......................... 11-43
Battery ................................................................. 11-44
Fuses ................................................................... 11-45
Main fuse ............................................................. 11-47
Installation of accessories ................................ 11-47
Replacing bulbs .................................................. 11-48
Headlight ................................................................. 11-49
Parking light ............................................................ 11-50
Front turn signal light ............................................ 11-50
Front fog light (if equipped) ................................... 11-50 Rear combination lights ......................................... 11-51
Backup light (Station wagon) ................................ 11-52
License plate light .................................................. 11-53
Dome light ............................................................... 11-53
Map light .................................................................. 11-54
Door step light ........................................................ 11-54
Cargo area light (Station wa gon) .......................... 11-55
Trunk light (Sedan) ................................................. 11-55
High mount stop light (Sedan) .............................. 11-56

Maintenance and service
11 - 3 1
– CONTINUED –Clutch pedal (Manual trans-
mission vehicles) Check the clutch pedal free play and re-
serve distance according to the mainte-
nance schedule in the “Warranty and
Maintenance Booklet”.
„ Checking the clutch functionCheck the clutch engagement and disen-
gagement.
1. With the engine idling, check that there
are no abnormal noises when the clutch
pedal is depressed, and that shifting into
1st or reverse feels smooth.
2. Start the vehicle by releasing the pedal
slowly to check that the engine and trans-
mission smoothly couple without any sign
of slippage. „ Checking the clutch pedal
free play
1) 0.16 – 0.51 in (4.0 – 13.0 mm)
Lightly press the clutch pedal down with
your finger until you feel resistance, and
check the free play.
If the free play is not within proper specifi-
cation, contact your SUBARU dealer. Replacement of brake pad
and lining
The right front disc brake and the right rear
disc brake have audible wear indicators
on the brake pads. If the brake pads wear
close to their service limit, the wear indica-
tor makes a very audible scraping noise
when the brake pedal is applied.
If you hear this scraping noise each time1 B00323
If you continue to drive despite the
scraping noise from the audible
brake pad wear indicator, it will re-
sult in the need for costly brake ro-
tor repair or replacement.
700040

14-2 Index
A
ABS (Anti-lock Brake System) ....... ...................... ............. 7-26
Warning light ....................................................... 3-20, 7-27
Accessories .................................................................... 11-47
Accessory power outlet .............. ........................................ 6-8
Active head restraint .. ..................................................... .... 1-6
Air cleaner element ........................................................ 11-17
Air conditioner .............. .................................................. .... 4-7
Air filtration system ........................................................... 4-13
Air flow selection ..................... ........................................... 4-2
Alarm system .................................................................... 2-14
All-Wheel Drive warning light (AT vehicles) ..................... 3-22
Aluminum wheels ......... .................................... .............. 11-39
Antenna system ................................................................. 5-2
Anti-lock Brake System (ABS) .... ......................... ............. 7-26
Arming the system ........ ....................................... ............. 2-15
Armrest ............................................................................. 1-10
Ashtray ............................................................................... 6-9
AT OIL TEMPerature warning light .................................. 3-18
Audio control button ......................................................... 5-39
Audio set ............................................................................ 5-3
Auto-dimming mirror/compass ...... ................................... 3-40
Automatic climate control system .. ................................. .... 4-7
Automatic transmission
4-speed ....................................................................... 7-11
5-speed ....................................................................... 7-17
Capacities .................................................................... 12-4
Fluid ........................................................................... 11-22
Manual mode .............. ............................ ............ 7-14, 7-20
Selector lever ...................................................... 7-12, 7-18
Shift lock release ................................................ 7-16, 7-23
Temperature warning light (AT OIL TEMP) ................. 3-18 Automatic/Emergency Locking Retractor (A/ELR) ............ 1-13
B
Battery ............................................................................ 11-44
Jump starting ............................................................... 9-10
Replacement (Remote keyless en try system) .... ........... 2-7
Brake
Booster ...................................................................... 11-30
Fluid ........................................................................... 11-28
Pad and lining ............................................................ 11-32
Pedal .......................................................................... 11-30
Brake pedal
Free play .................................................................... 11-30
Reserve distance ....................................................... 11-30
Brake system ......... ........................................................ ... 7-25
Warning light ................................................................ 3-20
Braking ............................................................................. 7-25
Tips .............................................................................. 7-25
Breaking
Breaking-in of new brake pads and linings ................ 11-32
Bulb
Chart ............................................................................ 12-9
Replacing ................................................................... 11-48
C
Capacities ........... ........................................................ ...... 12-4
Cargo area
Cover ........................................................................... 6-12
Light ............................................................................... 6-2
Tie-down hooks ........................................................... 6-15
Catalytic converter .................... .......................................... 8-3