2006 SAAB 9-2X battery

11 - 4 0
Maintenance and service
Battery
1) Cap
2) Upper level
3) Lower levelIt is unnecessary to periodically check the
battery fluid level or periodically refill with
distilled water.
However, if the battery fluid level is below
the lower level, remove the cap. Fill to the
upper level with distilled water.

Before beginning work on or near
any battery, be sure to extinguish
all cigarettes, matches, and light-
ers. Never expose a battery to an
open flame or electric sparks. Bat-
teries give off a gas which is high-
ly flammable and explosive.

For safety, in case an explosion
does occur, wear eye protection
or shield your eyes when working
near any battery. Never lean over
a battery.

Do not let battery fluid contact
eyes, skin, fabrics, or paint be-
cause battery fluid is a corrosive
acid. If battery fluid gets on your
skin or in your eyes, immediately
flush the area with water thor-
oughly. Seek medical help imme-
diately if acid has entered the
eyes.
If battery fluid is accidentally
swallowed, immediately drink a
large amount of milk or water, and
seek medical attention immediate-
ly.

To lessen the risk of sparks, re-
move rings, metal watchbands,
and other metal jewelry. Never al-
low metal tools to contact the pos-
itive battery terminal and anything
connected to it WHILE you are at
the same time in contact with any
other metallic portion of the vehi-
cle because a short circuit will re-
sult.

Keep everyone including children
away from the battery.

Charge the battery in a well-venti-
lated area.

Battery posts, terminals and relat-
ed accessories contain lead and
lead compounds, chemicals
known to the State of California to
cause cancer and reproductive
harm. Batteries also contain other
chemicals known to the State of
California to cause cancer. Wash
hands after handling.
Never use more than 10 amperes
when charging the battery because
it will shorten battery life.
UPPER LEVELLOWER LEVELLOWER LEVEL
1
2
3
B00382
A1910BE-A-GSAAB.book Page 40 Tuesday, September 6, 2005 8:37 AM
ProCarManuals.com

Maintenance and service
11 - 4 7
11
– CONTINUED –
1. Remove the air intake duct mounting
bolt, then remove the air intake duct.
2. Remove the bulb cover by turning it
counterclockwise.3. Push the retainer spring in the direction
of the arrow to remove it from the hook.
4. Pull the bulb out of the electrical con-
nector. Replace the bulb with a new one.
5. Set the retainer spring securely.
6. Reconnect the electrical connector.7. Install the bulb cover.

Left-hand low beam light bulb

High beam light bulbs
0
1. Remove the bulb from the headlight
assembly by turning it counterclockwise.
B00485B00486
700092B00488
Replacement of the left-hand low
beam light bulb requires removal of
the battery and is thus dangerous. It
must be performed by a Saab deal-
er.
B00489
A1910BE-A-GSAAB.book Page 47 Tuesday, September 6, 2005 8:37 AM
ProCarManuals.com

Maintenance and service
11 - 4 9
11
– CONTINUED –
3. Hold the end of the parking light and re-
move the parking light.
4. Pull the bulb out of the socket. Install a
new bulb.5. Fit the bulb socket into the headlight
assembly.
6. Install the bulb cover.

Left-hand side

Front turn signal light and
front side marker light bulbs
Right-hand side
It may be difficult to replace the bulbs.
Have your Saab dealer replace the bulbs
if necessary.

Left-hand side
1. Turn the steering wheel fully to the left.2. Undo the three clips at the bottom of
the undercover beside the front-left wheel.
3. Undo the hook at the top of the under-
cover beside the front-left wheel.
B00490B00491
Replacement of the left-hand park-
ing light bulb requires removal of
the battery and is thus dangerous. It
must be performed by a Saab deal-
er.
B00492B00493
A1910BE-A-GSAAB.book Page 49 Tuesday, September 6, 2005 8:37 AM
ProCarManuals.com

Specifications
12-3
– CONTINUED –
12
Engine

Electrical system
AT: Automatic transmission
MT: Manual transmissionEngine model
EJ253 (2.5-liter, SOHC, non-turbo)
EJ255 (2.5-liter, DOHC, turbo)
Engine type
Horizontally opposed, liquid cooled 4 cylinder, 4-stroke gasoline engine
Displacement cc (cu-in)
2,457 (150)
Bore  Stroke in (mm)
3.9  3.1 (99.5  79.0)
Compression ratio
10.0 : 1
8.4 : 1
Firing order
1 – 3 – 2 – 4
Battery type and capacity (5HR)
MT
55D23L (12V-48AH)
AT
75D23L (12V-52AH)
Alternator
Turbo engine
12V-110A
Non-turbo
engine
12V-90A
Spark plugs
Turbo
engine
ILFR6B (NGK)
Non-turbo engine
FR5AP-11 (NGK)
A1910BE-A-GSAAB.book Page 3 Tuesday, September 6, 2005 8:37 AM
ProCarManuals.com

14-2
Index
A
ABS (Anti-lock Brake System) .......................................... 7-16
Warning light ....................................................... 3-12, 7-17
Accessories ............................................................. 5-2, 11-43
Accessory power outlet ...................................................... 6-6
Active head restraint ........................................................... 1-4
Air cleaner element ......................................................... 11-15
Air conditioner operation .................................................... 4-7
Air filtration system ........................................................... 4-12
Air flow selection ................................................................ 4-2
Alarm system .................................................................... 2-13
All-Wheel Drive warning light ( AWD AT vehicles) ........... 3-14
Aluminum wheels ............................................................ 11-35
Antenna system ................................................................. 5-2
Anti-lock Brake System (ABS) .......................................... 7-16
Arming the system ............................................................ 2-13
Ashtray ............................................................................... 6-7
AT OIL TEMPerature warning light ................................... 3-12
Audio Systems ................................................................... 5-3
Automatic climate control system ....................................... 4-7
Automatic transmission (AT) ............................................ 7-10
Capacities .................................................................... 12-4
Fluid ............................................................................ 11-20
Selector lever ................................................................ 7-11
Shift lock release ......................................................... 7-13
Temperature warning light ........................................... 3-12
Automatic/Emergency Locking Retractor (A/ELR) ........... 1-10
B
Battery ............................................................................. 11-40
Jump starting ................................................................. 9-8
Replacement (Remote keyless entry system) ............... 2-9Brake
Booster ...................................................................... 11-27
Fluid ........................................................................... 11-25
Pad and lining ............................................................ 11-29
Pedal .......................................................................... 11-27
Brake pedal
Free play .................................................................... 11-27
Reserve distance ....................................................... 11-28
Brake system .................................................................... 7-15
Warning light ................................................................ 3-13
Braking ............................................................................. 7-15
Breaking-in of new brake pads and linings ................ 11-29
Tips .............................................................................. 7-15
Bulb
Chart ............................................................................ 12-9
Replacing ................................................................... 11-44
C
Capacities ......................................................................... 12-4
Cargo
Area cover ..................................................................... 6-9
Area light ............................................................. 6-2, 11-52
Tie-down hooks ............................................................ 6-10
Catalytic converter .............................................................. 8-3
Center
Console .......................................................................... 6-4
Vents .............................................................................. 4-3
Changing
Flat tire ........................................................................... 9-4
Oil and oil filter ............................................................. 11-8
Charge warning light ......................................................... 3-11A1910BE-A-GSAAB.book Page 2 Tuesday, September 6, 2005 8:37 AM
ProCarManuals.com

14-6
Index
Power
Door locking switches .................................................... 2-6
Steering ....................................................................... 7-15
Steering fluid ............................................................... 11-24
Windows ...................................................................... 2-17
Preparing to drive ............................................................... 7-6
Printed antenna .................................................................. 5-2
R
Rear
Combination lights ...................................................... 11-50
Differential gear oil ...................................................... 11-23
Gate ............................................................................. 2-19
Seats ............................................................................. 1-6
Rear seat
Folding down ................................................................. 1-7
Rear window
Defogger button ........................................................... 3-23
Wiper and washer switch ............................................. 3-22
Recommended
Automatic transmission fluid ....................................... 11-21
Brake fluid .................................................................. 11-26
Clutch fluid .................................................................. 11-27
Oil grade and viscosity .............. 11-11, 11-20, 11-22, 11-23
Power steering fluid .................................................... 11-25
Spark plugs ................................................................. 11-18
Remote keyless entry system ............................................ 2-7
Replacement
Brake pad and lining ................................................... 11-29
Wiper blades ............................................................... 11-36
Replacing
Air cleaner element ..................................................... 11-16Battery (remote keyless entry system) .......................... 2-9
Lost transmitters (keyless entry system) ..................... 2-10
Replacing bulbs .............................................................. 11-44
Cargo area ................................................................. 11-52
Dome light .................................................................. 11-52
Front turn signal light ................................................. 11-49
Headlight .................................................................... 11-46
License plate light ...................................................... 11-52
Map light .................................................................... 11-52
Rear combination lights ............................................. 11-50
Rocking the vehicle ............................................................ 8-9
Roof crossbar ................................................................... 8-12
S
Seat
Fabric ........................................................................... 10-5
Heater ............................................................................ 1-5
Seatbelt ................................................................................. 4
Extender ...................................................................... 1-18
Maintenance ................................................................ 1-17
Pretensioners ............................................................... 1-19
Safety tips ...................................................................... 1-8
Warning light and chime ....................................... 1-10, 3-9
Seatbelts ............................................................................. 1-8
Selector lever .................................................................... 7-11
Position indicator ......................................................... 3-14
Shift lock release .............................................................. 7-13
Side vents ........................................................................... 4-3
Snow tires ........................................................................... 8-9
Sounding a panic alarm ...................................................... 2-8
Spark plugs ..................................................................... 11-18
Specifications ................................................................... 12-2A1910BE-A-GSAAB.book Page 6 Tuesday, September 6, 2005 8:37 AM
ProCarManuals.com