2006 MITSUBISHI LANCER IX charging

CHARGING SYSTEM
ENGINE ELECTRICAL16-17
>>B<< ROTOR INSTALLATION
AK202779
Wire
AB
Remove the br ush holding wire af ter the rotor ha s
been inst
alled.
INSPECTION
M1161 0017 0015 2
ROTO R
AK202735
1. Measure th e resist a n ce b e tween the two slip rings
of the rot o r coil to check t he co ntinu i ty between
th em.
Repla c e th e r o to r if th e resist ance is no t within the
st
a ndard valu e range .
St andard va lue: 3 − 5 Ω
2.Check t he co ntinu i ty between the slip rings and
core.
AK202736
3. If cont inuity is pre s ent, repla c e th e rotor .
STA T OR
AK202716
1.Check t he co ntinu i ty between coil le ads.
If there is no con t inuity , replace the st a t or .
AK202717
2.Check t he co ntinu i ty between coil and core .
If there is no con t inuity , replace the st a t or .
RECTIFIER ASSEBMLY
AK202803
1.Check t he co ndition o f the (+) h eat sink by
checkin g contin uity be twe en t he (+) heat sink and
e a ch o f the st a t or coil lead conn ecting termina l s.
If cont inuity is pre s ent for both terminals, the
d
i ode is shorte d. Repla c e th e rectifie r assembly .

AK202802
CHARGING SYSTEM
ENGINE ELECTRICAL16-18
2.Check t he co ndition of the (−) heat sink by
checkin
g
con
t
inuity b
e
tween th e (
−) he at sink and
ea
ch o
f
the st
a
t
or co
il lead conne
cting termina l s.
If con t inu i ty is p r ese n t in bot h d i re ctio ns, the dio de
is shorted.
Re place the rectifier assembly .
AK202804
3.Check t he co ndition of the diode t r io by testing
continuity of ea ch o f the th ree diodes using a
circuit tester con necte d to both sides of the dio de.
Co nnect in a p o la rity a nd then reverse the polarity
fo r each test.
If continuity exist s or no cont inuity exist s for bo th
po
larities, the d i ode is d e fective . Repla c e th e
rectifier assembly if a
n y o f the d i odes is defe c tive.
BRUSH
AK202808
Protrusion
length
AB
1.Measure the lengt h of the prot rusion o f the bru s h.
Replace the b r ush if the protrusion lengt h is
shorter than th e limit .
Limit: 2 mm mini mum
2.Unsolde r the lead o f the br ush. The bru s h will
come out, b e coming ready for removal.
AK202834
Solder
AB
3.I n st all a ne w b r ush b y pu sh in g it int o the h o lde r a s
shown in the d r awing a nd soldering th e lea d .

90-1
GROUP 90
CIRCUIT DIAGRAMS
CONTENTS
J/B . . . . . . . . . . . . . . . . . . . . . . . . . . .90-4
J/C
J/C . . . . . . . . . . . . . . . . . . . . . . . . . 90-6
J/C . . . . . . . . . . . . . . . . . . . . . . . . . 90-12
CENTRALIZED JUNCTION
POWER DISTRIBUTION SYSTEM
POWER DISTRIBUTION SYSTEM
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 90-24
POWER DISTRIBUTION SYSTEM
. . . . . . . . . . . . . . . . . . . . . . . . . . . . 90-30
STARTING SYSTEM
STARTING SYSTEM . . . . . . . . . . . . 90-36
STARTING SYSTEM . . . . . . . . . . . . 90-37
IGNITION SYSTEM
IGNITION SYSTEM <4 G1-M/T (LHD)> . . . 90-38
IGNITION SYSTEM <4G1-M/T (RHD)> . . . 90-39
IGNITION SYSTEM <4G1-A/T (LHD)> . . . . 90-40
IGNITION SYSTEM <4G1-A/T (RHD)> . . . 90-41
IGNITION SYSTEM <4G6-M/T (LHD)> . . . 90-42
IGNITION SYSTEM <4G6-M/T (RHD)> . . . 90-43
IGNITION SYSTEM <4G6-A/T (LHD)> . . . . 90-44
CHARGING SYSTEM
CHARGING SYSTEM . . . . . . . . . . . 90-46
CHARGING SYSTEM . . . . . . . . . . . 90-47
ENGINE CONTROL SYSTEM
ENGINE CONTROL SYSTEM
<4G1-M/T (LHD)> . . . . . . . . . . . . . . . . . . . . 90-48
ENGINE CONTROL SYSTEM
<4G1-M/T (RHD)> . . . . . . . . . . . . . . . . . . . . 90-54
ENGINE CONTROL SYSTEM
<4G1-A/T (LHD)> . . . . . . . . . . . . . . . . . . . . 90-60
ENGINE CONTROL SYSTEM
<4G1-A/T (RHD)> . . . . . . . . . . . . . . . . . . . . 90-66
ENGINE CONTROL SYSTEM
<4G6-M/T (LHD)> . . . . . . . . . . . . . . . . . . . . 90-72
ENGINE CONTROL SYSTEM
<4G6-M/T (RHD)> . . . . . . . . . . . . . . . . . . . . 90-78
ENGINE CONTROL SYSTEM
<4G6-A/T (LHD)> . . . . . . . . . . . . . . . . . . . . 90-84
COOLING SYSTEM
COOLING SYSTEM . . . . . . . . . . . . 90-90
COOLING SYSTEM . . . . . . . . . . . . 90-91
INVECS-II 4A/T
INVECS-II 4A/T <4G1 (LHD)> . . . . . . . . . . . 90-92
INVECS-II 4A/T <4G1 (RHD)> . . . . . . . . . . 90-98
INVECS-II 4A/T <4G6 (LHD)> . . . . . . . . . . . 90-104
HEADLAMP
HEADLAMP . . . . . . . . . . . . . . . . . . 90-110
HEADLAMP . . . . . . . . . . . . . . . . . . 90-114
Continued on next page

J/C
CIRCUIT DIAGRAMS90-10
J/C (CONTINUED)
·FRONT FOG
LAMP ·FRONT FOG
LAMP
FRONT FOG
LAMP
·TURN-SIGNAL
LAMP AND HAZARD
WARNING LAMP ·HEADLAMP
WASHER ·ROOM LAMP AND
LUGGAGE
COMPARTMENT
LAMP
·ROOM LAMP,
PERSONAL LAMP
AND LUGGAGE
ROOM LAMP
·TAIL LAMP,
POSITION LAMP,
LICENCE PLATE
LAMP AND LIGHTING
MONITOR BUZZER
·WINDSHIELD WIPER
AND WASHER·WINDSHIELD
WIPER AND
WASHER
WINDSHIELD
WIPER AND
WASHER
DIAGNOSIS
CONNECTOR·METER AND
GAUGE
·METER AND
GAUGE METER AND
GAUGESPARE
CONNECTOR
(FOR AUDIO)
SPARE
CONNECTOR
(FOR FRONT
FOG LAMP)·SPARE
CONNECTOR
(FOR FRONT
FOG LAMP) CLOCK(FUSE )
23
(FUSE )2
RELAY
BOX
·REAR FOG
LAMP
·REAR WIPER AND
WASHER ·ABS
·BRAKE
WARNING LAMP
·CHARGING
SYSTEM
·ENGINE
CONTROL
SYSTEM
·FUEL WARNING
LAMP
·INVECS-II
4A/T
·SUPPLEMENTAL
RESTRAINT
SYSTEM (SRS) ·OIL PRESSURE
WARNING LAMP J/B
(FUSE )
11J/B ACCESSORY
SOCKET
REMOTE
CONTROLLED
MIRROR

CENTRALIZED JUNCTION
CIRCUIT DIAGRAMS90-20
PASSENGER COMPARTMENT
AC207745
(Connected directly to battery positive terminal)
Front of vehicle26
AF
No.Power supply circuitNameRated
capacity (A)Housing
colourLoad circuit
1Ignition switch (IG1)Fuse10RedCapacitor and ignition coil
27.5BrownABS warning lamp, brake warning
lamp, charging warning lamp, check
engine warning lamp, column switch,
combination meter, ETACS-ECU, low
fuel warning lamp, oil pressure
warning lamp, SRS air bag warning
lamp, SRS-ECU and vehicle speed
sensor
37.5BrownA/T control relay, combination meter,
engine-A/T-ECU, ETACS-ECU, input
shaft speed sensor, output shaft
speed sensor, rear combination lamp
and SRS-ECU
4−−−
5Ignition switch (IG2)7.5BrownA/C compressor relay, A/C-ECU,
blower relay, rear window defogger
relay, front-ECU, heated seat relay,
heater control unit and outside/inside
air selection damper control motor
6Rear window
defogger relay7.5BrownRemote controlled mirror
7Ignition switch (ACC)20YellowFront-ECU and windshield wiper
motor
8Ignition switch (IG1)7.5BrownEngine-A/T-ECU, engine-ECU, fuel
pump relay (1) and fuel pump relay (2)
9Ignition switch (ACC)15BlueCigarette lighter
10−−−
117.5BrownAccessory socket relay and Remote
controlled mirror
12Ignition switch (IG2)7.5BrownABS-ECU
13Ignition switch (ACC)−−−
1415BlueETACS-ECU and rear wiper motor

POWER DISTRIBUTION SYSTEM
CIRCUIT DIAGRAMS90-24
POWER DISTRIBUTION SYSTEM
POWER DISTRIBUTION SYSTEM M1901000402002
·CENTRAL DOOR
LOCKING SYSTEM
·CLOCK
·FRONT FOG LAMP
·FUEL WARNING
LAMP
·HEADLAMP
·HEADLAMP
LEVELLING SYSTEM
·INVECS-II 4A/T
·KEY REMINDER
BUZZER
·METER AND GAUGE
·POWER WINDOWS
·REAR FOG LAMP
·REAR WIPER AND
WASHER·ROOM LAMP AND
LUGGAGE COM-
PARTMENT LAMP
·ROOM LAMP,
PERSONAL LAMP
AND LUGGAGE
ROOM LAMP
·SPARE CONNECTOR
(FOR AUDIO)
·TAIL LAMP, POSITION
LAMP, LICENCE PLATE
LAMP AND LIGHTING
MONITOR BUZZER
·TURN-SIGNAL LAMP
AND HAZARD
WARNING LAMP
·WINDSHIELD WIPER
AND WASHERENGINE
CONTROL
SYSTEM
INVECS-II
4A/TTURN-SIGNAL
LAMP AND
HAZARD
WARNING LAMP
CHARGING
SYSTEMACCESSORY
SOCKET
·ABS
·INVECS-II
4A/T
·STOP LAMP·AUTOMATIC AIR
CONDITIONER
·HEATER
·MANUAL AIR
CONDITIONER
·COOLING
SYSTEM
·ENGINE
CONTROL
SYSTEM
·IGNITION SYSTEM
·IMMOBILIZER
SYSTEM
·INVECS-II 4A/THORN ·AUTOMATIC AIR
CONDITIONER
·COOLING SYSTEM
·MANUAL AIR
CONDITIONERABS
·CENTRAL DOOR
LOCKING SYSTEM
·POWER WINDOWS CHARGING
SYSTEMSTARTING
SYSTEM
BATTERY
RELAY
BOX FUSIBLE
LINK
HEATED
SEAT

POWER DISTRIBUTION SYSTEM
CIRCUIT DIAGRAMS90-26
POWER DISTRIBUTION SYSTEM (CONTINUED)
RELAY BOX
IGNITION
SWITCHRELAY
BOX
·CLOCK
·ROOM LAMP AND LUGGAGE
COMPARTMENT LAMP
·ROOM LAMP
AND LUGGAGE
COMPARTMENT
LAMP·ROOM LAMP, PERSONAL LAMP
AND LUGGAGE ROOM LAMP
·ROOM LAMP,
PERSONAL LAMP
AND LUGGAGE
ROOM LAMP·SPARE CONNECTOR
(FOR AUDIO)
STARTING
SYSTEM
IGNITION
SYSTEM·ENGINE
CONTROL
SYSTEM ·ENGINE CONTROL
SYSTEM
·INVECS-II
4A/T ·INVECS-II 4A/T
·INVECS-II 4A/T·BACK-UP LAMP
·METER AND
GAUGE
·REAR WIPER AND
WASHER
·SUPPLEMENTAL
RESTRAINT SYSTEM
(SRS)
·SUPPLEMENTAL
RESTRAINT
SYSTEM (SRS)·WINDSHIELD
WIPER AND WASHER ·ABS
·BRAKE WARNING
LAMP
·CENTRAL DOOR
LOCKING SYSTEM
·CHARGING
SYSTEM
·ENGINE CONTROL
SYSTEM
·FRONT
FOG LAMP
·FUEL WARNING
LAMP
·HEADLAMP
·HEADLAMP
WASHER
·KEY REMINDER
BUZZER
·METER AND
GAUGE
·OIL PRESSURE
WARNING LAMP
·POWER WINDOWS·REAR FOG LAMP
·REAR WIPER
AND WASHER
·TAIL LAMP,
POSITION LAMP,
LICENCE PLATE
LAMP AND LIGHTING
MONITOR BUZZER
·TURN-SIGNAL LAMP
AND HAZARD
WARNING LAMP
·WINDSHIELD
WIPER AND WASHER
4FUSIBLE
LINK

POWER DISTRIBUTION SYSTEM
CIRCUIT DIAGRAMS90-30
POWER DISTRIBUTION SYSTEM
M1901000402013
·CENTRAL DOOR
LOCKING SYSTEM
·CLOCK
·FRONT FOG LAMP
·FUEL WARNING
LAMP
·HEADLAMP
·HEADLAMP
LEVELLING SYSTEM
·INVECS-II 4A/T
·KEY REMINDER
BUZZER
·METER AND GAUGE
·POWER WINDOWS
·REAR FOG LAMP
·REAR WIPER AND
WASHER·ROOM LAMP AND
LUGGAGE COM-
PARTMENT LAMP
·ROOM LAMP,
PERSONAL LAMP
AND LUGGAGE
ROOM LAMP
·SPARE CONNECTOR
(FOR AUDIO)
·TAIL LAMP, POSITION
LAMP, LICENCE PLATE
LAMP AND LIGHTING
MONITOR BUZZER
·TURN-SIGNAL LAMP
AND HAZARD
WARNING LAMP
·WINDSHIELD WIPER
AND WASHERENGINE
CONTROL
SYSTEM
INVECS-II
4A/TTURN-SIGNAL
LAMP AND
HAZARD
WARNING LAMP
CHARGING
SYSTEMACCESSORY
SOCKET
·ABS
·INVECS-II
4A/T
·STOP LAMP·AUTOMATIC AIR
CONDITIONER
·HEATER
·MANUAL AIR
CONDITIONER
·COOLING
SYSTEM
·ENGINE
CONTROL
SYSTEM
·IGNITION SYSTEM
·IMMOBILIZER
SYSTEM
·INVECS-II 4A/THORN ·AUTOMATIC AIR
CONDITIONER
·COOLING
SYSTEM
·MANUAL AIR
CONDITIONERABS
POWER
WINDOWS STARTING
SYSTEM
BATTERY
RELAY
BOX FUSIBLE
LINK
RELAY
BOX
CHARGING
SYSTEM