2006 MERCEDES-BENZ SL600 power steering

354 Practical hintsWhat to do if …ESP
Unavailable
See Oper. Manual
The ESP
® is deactivated because the
power supply has been interrupted.
The electro-hydraulic brake system is
still functioning normally but without
the ESP® available.

Synchronize the ESP
®. With the vehicle
stationary, turn the steering wheel com-
pletely to the left and then to the right.
If the ESP
® message does not go out:

Continue driving with added caution.

Have the system checked at an authorized
Mercedes-Benz Center as soon as
possible.
Failure to follow these instructions increases
the risk of an accident.
Left display
Right display
Possible cause/consequence
Possible solution
!When sychronizing the ESP
®, make
sure you can turn the steering wheel in
both directions as far as it will go with-
out the wheels hitting any objects, e.g.
a road curb.

422 Practical hintsTowing the vehicleWarning!
G
If circumstances require towing the vehicle
with all wheels on the ground, always tow
with a tow bar if:

the engine will not run


there is a malfunction in the
electro-hydraulic brake system


there is a malfunction in the power sup-
ply or in the vehicle’s electrical system
as that will be necessary to adequately con-
trol the towed vehicle.
Prior to towing the vehicle with all wheels on
the ground, make certain that the SmartKey
is in starter switch position2.
If the SmartKey is left in starter switch
position0 for an extended period of time, it
can no longer be turned in the switch. In this
case, the steering is locked. To unlock, re-
move SmartKey from starter switch and re-
insert.
iTo signal turns while being towed with
the hazard warning flasher in use, turn
SmartKey in starter switch to
position2 and activate the combina-
tion switch for the left or right turn sig-
nal in the usual manner – only the
selected turn signal will operate.
Upon canceling the turn signal, the haz-
ard warning flasher will operate again.
Warning!
G
The brake system requires electrical power
to operate.
A malfunction in the vehicle’s power supply
or electrical system may impair brake sys-
tem operation and switch it into its emer-
gency operation mode. To brake, the driver
must then apply significantly greater brake
pedal pressure and depress the pedal much
further to obtain the expected braking ef-
fect. If necessary, apply full pressure to the
brake pedal. Brakes are only applied to the
front wheels. Stopping distance is in-
creased! Adapt your driving style according-
ly. For more information, see
“Electro-hydraulic brake system”
(page 88).
With the engine not running, there is no
power assistance for the brake and steering
systems. In this case, it is important to keep
in mind that a considerably higher degree of
effort is necessary to brake and steer the ve-
hicle. Adapt your driving accordingly.

431 Technical data
Layout of poly-V-belt drive
Layout of poly-V-belt drive
SL 500
1Automatic belt tensioner
2ABC tandem pump (pump for
power-steering assistance and ABC
chassis)
3Air conditioning compressor
4Crankshaft
5Coolant pump
6Generator (alternator)
7Idler pulley
SL 55 AMGThe SL 55 AMG has two poly-V-belts (belt
one shown in purple/belt two shown in
black).1Idler pulley
2Automatic belt tensioner
3ABC tandem pump (pump for
power-steering assistance and ABC
chassis)
4Air conditioning compressor
5Crankshaft
6Coolant pump
7Generator (alternator)
8Idler pulley
9Automatic belt tensioner
aSupercharger
SL 600, SL 65 AMG
1Automatic belt tensioner
2ABC tandem pump (pump for
power-steering assistance and ABC
chassis)
3Air conditioning compressor
4Crankshaft
5Coolant pump
6Generator (alternator)
7Idler pulley
8Idler pulley
9Idler pulley

445 Technical data
Fuels, coolants, lubricants, etc.
Fuels, coolants, lubricants, etc.
CapacitiesVehicle components and their respective
lubricants must match. Therefore use only
products tested and approved by
Mercedes Benz.Please refer to the Factory Approved Ser-
vice Products pamphlet, or inquire at your
Mercedes-Benz Center.
Model
Capacity
Fuels, coolants, lubricants, etc.
Engine with oil filter
SL 500
SL 600
SL 55 AMG
SL 65 AMG
7.9 US qt (7.5 l)
8.5 US qt (8.0 l)
9.0 US qt (8.5 l)
8.5 US qt (8.0 l)
Approved engine oils
Automatic transmission
SL 500
SL 600
SL 55 AMG
SL 65 AMG
9.2 US qt (8.7 l)
8.0 US qt (7.5 l)
9.1 US qt (8.6 l)
8.0 US qt (7.5 l)
MB Automatic Transmission Fluid
Rear axle
SL 500
SL 600
SL 55 AMG
SL 65 AMG
1.3 US qt (1.2 l)
1.3 US qt (1.2 l)
1.5 US qt (1.4 l)
1.3 US qt (1.2 l)
Hypoid gear oil SAE 85 W 90
Hypoid gear oil SAE 85 W 90
Hypoid gear oil SAE 85 W 90
Hypoid gear oil SAE 75 W 140
Hydraulic system for active body control (ABC)
approx. 4.3 US qt (4.0 l)
MB Hydraulic Fluid
Power steering
approx. 1.1 US qt (1.0 l)
MB Power Steering Fluid (Pentosin
CHF 11S)
Front wheel hubs
approx. 3.0 oz (85 g) each
High temperature roller bearing grease
Brake system
1.1 US qt (1.05 l)
MB Brake Fluid (DOT 4+)

454 Technical termsCAN system
(C
ontroller A
rea N
etwork)
Data bus network serving to control ve-
hicle functions such as door locking or
windshield wiping depending on vehi-
cle settings and/or ambient condi-
tions.
Cockpit
All instruments, switches, buttons and
indicator/warning lamps in the passen-
ger compartment needed for vehicle
operation and monitoring.
Cold tire inflation pressure
(
page 310)
Collapsible tire
An especially compact spare tire that
must be inflated with a provided air
pump before using. It should only be
used to bring the vehicle to the nearest
service station.COMAND
(Co
ckpit Man
agement and
D
ata System)
Information and operating center for
vehicle sound and communications
systems, including the radio, CD
changer and navigation system, as well
as other optional equipment (e.g. tele-
phone).
Control system
The control system is used to call up
vehicle information and to change
component settings. Information and
messages appear in the multifunction
display. The driver uses the buttons on
the multifunction steering wheel to
navigate through the system and to ad-
just settings.
Cruise control
Driving convenience system for auto-
matically maintaining the vehicle speed
set by the driver.
Curb weight
(page 310)Distronic*
A driving convenience cruise control
system which helps the driver maintain
a pre-selected speed:


If there is no vehicle directly ahead,
the system operates in the same
way as conventional cruise control.


If a slower moving vehicle is ahead,
Distronic* will reduce your vehicle
speed to the extent permitted by re-
duced throttle and up to 20% brak-
ing power to maintain the preset
minimum following distance.
DOT
(Department o
f Transportation)
(
page 311)
DTR
(->Distr
onic*)
Electro-hydraulic brake system
Electronically controlled hydraulic
braking system for increased braking
safety and comfort.

457 Technical terms
Overspeed range
Engine speeds within the red marking
on the tachometer dial, see “Tachome-
ter” (
page 133). Avoid this engine
speed range, as it may result in serious
engine damage that is not covered by
the Mercedes-Benz Limited Warranty.
Parktronic (Parking assist)*
System which uses visual and acoustic
signals to assist the driver during park-
ing maneuvers.
Poly-V-belt drive
Drives engine-components (alternator,
AC compressor, etc.) from the engine.Power train
Collective term designating all compo-
nents used to generate and transmit
motive power to the drive axles, includ-
ing


engine


clutch/torque converter


transmission


transfer case


drive shaft


differential


axle shafts/axles
Production options weight
(
page 311)Program mode selector switch
Used to switch the automatic transmis-
sion between standard operation (S)
and comfort operation (C).
SL 55 AMG with steering wheel gear-
shift control and manual shift program:
In addition to S and C (for regular S or
comfort C operation, see above), you
can use MANUAL for manual shift pro-
gram.
PSI
(P
ounds p
er s
quare i
nch)
(
page 312)
Recommended tire inflation pressure
(page 312)
REST
(Residual Engine Heat Utilization)
Feature that uses the engine heat
stored in the coolant to heat the vehi-
cle interior for a short time after the en-
gine has been turned off.

466 IndexEngine oil 274, 447
Adding 276, 445
Additives 447
Checking level 274
Consumption 274
Filler neck 276
Messages in the multifunction
display 275, 369
Recommended engine oils and
filters 447
ESP
®
82, 85, 455
Switch 30
Switching off 86
Switching on 87
Synchronizing 354
Warning lamp 25, 332
ETD 74, 455
Safety guidelines 69
Warning and indictor lamps 341
Exterior lamp switch 123
Exterior rear view mirrors 44, 177
F
Filler neck, Engine oil 276
First aid kit 383Flat tire 399
Preparing the vehicle 399
Spare wheel 383, 404
TIREFIT kit 384, 399
Flexible Service System see FSS
Fluids
Automatic climate control
system 445
Automatic transmission 277, 445
Brake system 271, 445, 447
Capacities 445
Engine coolant 278, 445, 450
Engine oil 274, 445, 447
Power steering 445
Retractable hardtop, Hydraulics 445
Windshield washer and headlamp
cleaning system 445
Fog lamps 126
Messages in the multifunction
display 375, 377
Replacing bulbs 392
Front airbags 70
Front lamps see Headlamps
Front passenger front airbag off indicator
lamp 78
FSS (Canada only) 318, 455Fuel 269
Additives 449
Capacity, Fuel tank 445
Consumption statistics 157
Filler flap 269
Fuel reserve warning lamp 27, 338
Gasoline additives 449
Gauge 27
Premium unleaded gasoline 270,
446, 448
Refuelling 269
Requirements 448
Fuel cap
Messages in the multifunction
display 371
Fuels, coolants, lubricants etc.
Capacities 445
Functions (control system) 137
Fuse chart see Vehicle tool kit
Fuses 425
G
Garage door opener 247
Gasoline see Fuel
GAWR 311, 455

474 IndexSide windows
Automatic closing 194
Automatic opening 193
Closing 192, 193
Closing fully 194
Closing with KEYLESS-GO* 194
Express-close 194
Express-open 193
Opening 192, 193
Opening fully 193
Stopping 194
Synchronizing power windows 194
Sidewall 312, 458, 459
SmartKey 96
Checking the batteries 99
Closing retractable hardtop 200
Global locking 98
Global unlocking 98
Loss of 100
Positions in starter switch 36
Restoring factory settings 98, 104
Selective setting 98
Starting the engine 49
Turning off the engine 60
SmartKey batteries 389
SmartKey positions 36SmartKey with KEYLESS-GO*
Checking the battery 106
Global locking 104
Global unlocking 103
Locking 105
Loss of 106
Messages in display 373
Reprogramming 104
Selective setting 104
Unlocking 100
Snow chains 317
Spare fuses 425
Spare fuses see Vehicle tool kit
Spare tire see Spare wheel 399
Spare wheel 383, 384, 404, 441
Inflating tire 408
Tire inflation pressure 408
Speed settings
Cruise control 206
Speedometer 25
Setting units 149
Sporty driving style 219
SRS 458
Indicator lamp 341
Standing lamps 123, 392
Standing waterDriving instructions 265
Starter battery 279, 413
Starter switch 23, 36
Starter switch positions 36
Starting difficulties 50
Starting position 36
Starting the engine
With the SmartKey 49
With the SmartKey with
KEYLESS-GO* 50
Steering column
In/out adjustment 42
Length adjustment 42
Up/down adjustment 42
Steering wheel
Adjusting 42
Buttons 28
Cleaning 330
Heating* 235
Height adjustment 42
Steering wheel adjustment lever 23
Steering wheel gearshift control 170
SL 55 AMG and SL 65 AMG 172
Vehicles with Sport Package* 170
Stopping
Windows 194