2006 MERCEDES-BENZ CLK350 check engine

456 Practical hintsJump starting
If the battery is discharged, the engine can
be started with jumper cables and the bat-
tery of another vehicle. Observe the follow-
ing:

Jump starting should only be performed
when the engine and catalytic convert-
er are cold.


Do not start the engine if the battery is
frozen. Let the battery thaw out first.


Only jump start from batteries with the
same voltage rating (12 V). Jump start-
ing with a more powerful battery could
damage the vehicle’s electrical system,
which will not be covered by the
Mercedes-Benz Limited Warranty.


Only use jumper cables with sufficient
cross-section and insulated terminal
clamps.


Always make sure the jumper cables
are not on or near pulleys, fans or other
parts that move when an engine is
started or running.
Warning!
G
Failure to follow these directions will cause
damage to the electronic components, and
can lead to a battery explosion and severe
injury or death.
Never lean over batteries while connecting
or jump starting, you might get injured.
Battery fluid contains sulfuric acid. Do not
allow this fluid to come in contact with eyes,
skin or clothing. In case it does, immediately
flush affected area with water, and seek
medical help if necessary.
A battery will also produce hydrogen gas,
which is flammable and very explosive. Keep
flames or sparks away from battery, avoid
improper connection of jumper cables,
smoking, etc.
Attempting to jump start a frozen battery
can result in it exploding, causing personal
injury.
Read all instructions before proceeding.
!Avoid repeated and lengthy starting at-
tempts.
Do not attempt to start the engine us-
ing a battery quick charge unit.
If the engine does not run after several
unsuccessful starting attempts, have it
checked at the nearest authorized
Mercedes-Benz Center.
Excessive unburned fuel generated by
repeated failed starting attempts may
damage the catalytic converter and
may present a fire risk.
Make sure the jumper cables do not
have loose or missing insulation.
Make sure the cable clamps do not
touch any other metal part while the
other end is still attached to a battery.

457 Practical hints
Jump starting
The battery is located on the right side of
the engine compartment. For jump start-
ing, use the terminals in front of the bat-
tery.
Make sure the two vehicles do not
touch.

Turn off all electrical consumers.

Apply parking brake.

Shift gear selector lever to positionP.

Open the hood (
page 321).

Flip up cover from positive under hood
terminal2 in front of the filter box
(page 454).1Positive terminal of charged battery
2Positive under hood terminal in front of
discharged battery
3Negative under hood terminal in front
of discharged battery
4Negative terminal of charged battery

Connect the positive terminal1 of the
charged battery with the positive under
hood terminal 2 in front of the filter
box with the jumper cable. Clamp cable
to charged battery1 first.

Start engine of the vehicle with the
charged battery and run at idle speed.

Connect the negative terminal4 of
the charged battery with the negative
under hood terminal 3 in front of the
filter box with the jumper cable. Clamp
cable to charged battery4 first.

Start the engine of the disabled vehi-
cle.
You can now turn on the electrical con-
sumers. Do not turn on the lights under
any circumstances.

Remove the jumper cables first from
the negative terminals3 and4 and
then from the positive terminals2
and1.
You can now turn on the lights.

Have the battery checked at the near-
est authorized Mercedes-Benz Center.
Warning!
G
Keep flames or sparks away from battery.
Do not smoke.
Observe all safety instructions and precau-
tions when handling automotive batteries
(page 328).
!Never invert the terminal connections.
!Do not tow-start the vehicle.

484 Technical dataFuels, coolants, lubricants, etc.Coolants
The engine coolant is a mixture of water
and anticorrosion / antifreeze, which
provides:

Corrosion protection


Freeze protection


Boiling protection (by increasing the
boiling point)
The cooling system was filled at the factory
with a coolant providing freeze protection
to approximately -22°F (-30°C) and
corrosion protection.
If the antifreeze mixture is effective
to -22°F (-30°C), the boiling point of the
coolant in the pressurized cooling system
is reached at approx. 266°F (130°C).The coolant solution must be used
year-round to provide the necessary corro-
sion protection and increase boil-over pro-
tection. Refer to Maintenance Booklet for
replacement interval.
Coolant system design and coolant used
determine the replacement interval. The
replacement interval published in the
Maintenance Booklet is only applicable if
MB 325.0 Anticorrosion/Antifreeze solu-
tion or other Mercedes-Benz approved
products of equal specification (see Facto-
ry Approved Service Products pamphlet)
are used to renew the coolant concentra-
tion or bring it back up to the proper level.To provide important corrosion protection,
the solution must be at least 45% anticor-
rosion/antifreeze (equivalent to freeze
protection to approx. -22°F [-30°C]). If you
use a solution that is more than 55% anti-
corrosion/antifreeze (freeze protection to
approx. -49°F [-45°C]), the engine temper-
ature will increase due to the lower heat
transfer capability of the solution. There-
fore, do not use more than this amount of
anticorrosion/antifreeze.
If the coolant level is low, water and MB
Anticorrosion /Antifreeze should be used
to bring it up to the proper level (have cool-
ing system checked for signs of leakage).
Please make sure the mixture is in accor-
dance with label instructions.
The water in the cooling system must meet
minimum requirements, which are usually
satisfied by normal drinking water. If you
are not sure about the water quality,
consult an authorized Mercedes-Benz
Center.

485 Technical data
Fuels, coolants, lubricants, etc.
Anticorrosion/antifreeze
Your vehicle contains a number of alumi-
num parts. The use of aluminum compo-
nents in motor vehicle engines
necessitates that anticorrosion/antifreeze
coolant used in such engines be specifical-
ly formulated to protect the aluminum parts. (Failure to use such anticorro-
sion/antifreeze coolant will result in a sig-
nificantly shortened service life.)
Therefore, the following product is strongly
recommended for use in your vehicle:
Mercedes-Benz 325.0 Anticorrosion/Anti-
freeze agent.Before the start of the winter season (or
once a year in hot southern regions), you
should have the anticorrosion/antifreeze
concentration checked. The coolant is also
regularly checked each time you bring your
vehicle to an authorized Mercedes-Benz
Center for service.
Anticorrosion/antifreeze quantityModel
Approx. freeze protection–35°F (–37°C)
–49°F (–45°C)
CLK 350
3.75 US qt (3.55 l)
4.1 US qt (3.9 l)
CLK 500
6.4 US qt (6.0 l)
7.0 US qt (6.6 l)
CLK 55 AMG
6.4 US qt (6.0 l)
7.0 US qt (6.6 l)

494 IndexAutomatic transmission 166
Accelerator position 170
Emergency operation
(Limp Home Mode) 180
Gear ranges 171
Gear selector lever 48, 166
Gear selector lever position 166, 168
Gear selector lever,
One-touch gearshifting 173
Gear shifting malfunctions 180
Kickdown 170
Manual (One touch) gearshifting 173
Manual shift program 178
One-touch gearshifting, Steering
wheel gearshift control 174
Shift program mode
selector switch 172, 178
Starting engine 48
Transmission fluid level 326
Automatic Transmission Fluid see ATF
B
Backrest
Seat, Multicontour* 121
Seat, Power 38Backup lamps
Messages in display 406
Replacing bulbs 438, 439
Bar 355
BAS 88, 487
Batteries, SmartKey
Changing 436
Checking battery condition 99
Batteries, SmartKey with KEYLESS-GO*
Changing 437
Checking battery condition 105
Battery, Vehicle 328, 453
Charging 455
Connecting 455
Disconnecting 454
Installing 455
Jump starting 456
Messages in display 395
Removing 454
Bead 355
Beverage holder see Cup holder
Bi-Xenon headlamps* see Headlamps
Block heater (Canada only) 360
Bolts, Spare wheel 418
Brake Assist System see BASBrake fluid 481
Checking 320
Messages in display 396
Brake lamp
Cleaning lenses 369
High mounted 439
Messages in display 404
Replacing bulbs 439, 443
Brake pads
Messages in display 396
Brakes 308
High-performance brake system
(CLK 55 AMG only) 309
Warning lamp 375
Break-in the vehicle 306
Bulbs, replacing see Replacing bulbs
C
CAC 487
California retail buyers and lessees,
Important notice for 11
Call priority (Tele Aid) 294
Can holder see Cup holder
CAN system 487
Capacities and
recommended fuels/lubricants 479
Cargo area see Trunk

498 IndexEngine coolant see Coolant
Engine oil 322, 481
Adding 325, 481
Additives 481
Changing 325, 481
Checking level 320
Checking level (Dipstick) 324
Consumption 322
Filler cap 326
Filler neck 326
Messages in display 323, 401
Viscosity 488
Engine oil level 320, 323
ESP
®
25, 89, 488
Messages in display 387–388
Warning lamp 378
ETD 72, 488
Safety guidelines 66
Exterior rear view mirrors 43, 181
Parking position 161, 183F
Filler cap, Engine oil 326
Filler neck, Engine oil 326
First aid kit 413
Flat tire 446
Jacking up the vehicle 447
Lowering the vehicle 451
Minispare wheel 416
Mounting the spare wheel 447
Preparing the vehicle 446
Flexible Service System see FSS
(Canada vehicles)
Floormats* 287
Fluids
Brake fluid 320, 481
Engine coolant 327, 484
Engine oil 322, 481
Transmission fluid 326
Windshield washer and headlamp
cleaning* system 329, 486
Fog lamps 131, 439
Messages in display 405
Replacing bulbs 438, 439, 443
Front air bags 67
Front lamps see HeadlampsFront passenger front air bag 63, 67
Messages in display 389–392
Front passenger front
air bag off indicator lamp 27, 81, 381
FSS (Canada vehicles) 361, 488
Fuel 319, 479
Additives 483
Automatic transmission fluid 479
Brake fluid 479
Capacities 479
Capacities, Fuel tank 480
Engine coolant 480
Engine oil 479
Filling the tank 318
Fuel display 25
Fuel filler flap and cap 318, 421
Fuel filler flap and cap, Multifunction
display messages 400
Fuel reserve warning lamp 379
Power steering fluid 479
Premium
unleaded gasoline 319, 480, 482
Requirements, Octane rating 482
Technical data 479
Fuel cap
Message in display 376

501 Index
K
Key, Mechanical 419
Key, SmartKey 96
Batteries 99, 105
Battery check lamp 98, 104
Changing batteries 436
Factory setting 98, 99
Ignition 34
Locking/unlocking 32, 60, 96
Locking/unlocking, Global setting 98
Locking/unlocking,
Selective setting 98
Loss of 100, 106
Message in display 403, 404
Opening and closing
the power windows 252
Opening and closing the soft top 260
Positions in starter switch 34
Remote control 96
SmartKey with KEYLESS-GO* 100
Starting the engine 49
Turning off the engine 58
Unlocking/opening trunk lid 99
Key, SmartKey with KEYLESS-GO*
Changing batteries 437KEYLESS-GO* 100, 489
Batteries in SmartKey 105
Battery check lamp, SmartKey 104
Factory setting 103, 105
Ignition 36
Important notes 102
Lock button 60
Locking/unlocking 33, 60, 100
Locking/unlocking,
Global setting 103, 104
Locking/unlocking, Global
with lock button on trunk lid 105
Locking/unlocking,
Selective setting 104
Loss of key 106
Messages in display 403, 404
Remote control 100
Start/stop button 35
Starting the engine 49
Turning off the engine 59
Unlocking/opening trunk lid 106
Kickdown 170, 489
Kilopascal 356L
Labels 468
Certification 468
Emission control information 468
Vacuum line routing diagram 468
Lamp sensor
Messages in display 405
Lamps, exterior 438
Light sensor 405
Messages in display 404–408
Lamps, indicator and warning
ABS 25, 374
Battery (SmartKey) 98, 104
Brakes 25, 375
Center console 381–382
CHECK ENGINE 376
Coolant 377
Coolant temperature 25, 137
Distance warning 25
Engine diagnostics 376
Engine malfunction 25, 376
ESP
®
25, 378
Fog lamps 130
Front passenger front air bag off 68
Front passenger front
air bag off indicator lamp 381

503 Index
MOExtended490
MOExtended system* 452
MON 319, 489
Motor Octane Number see MON
Multicontour seat* see
Seats, Multicontour*
Multifunction display 140, 490
Changing settings see
Control system menus and
Control system submenus
Displaying gear range 171
Selecting language 151
Symbol messages 395–412
Text messages 385–393
Multifunction display messages 383
ABS 385
Battery 395
Brake fluid 396
Brake lamp 404
Brake pads 396
Check engine 397
Coolant 397–399
Display 400
Doors 400
Engine 397
Engine coolant 397–399Engine oil 323, 401
ESP
®
387, 388
Fog lamps 405
Front passenger
front air bag 389–392
Fuel cap 400
Fuel reserve tank 403
Gear selector lever 393
Headlamps 404–408
Hood 403
Key, SmartKey 403
KEYLESS-GO* 403
Lamp sensor 405
Lamps 404
Lamps, exterior 404–408
License plate lamp 405
Parking brake 396
Parking lamps 406
Roll bars 408
Seat belts 409
Soft top 410
SRS 409
Steering gear oil 410
Tele Aid 409
Telephone* 411
Trunk 412Turn signals 407
Windshield washer fluid 412
Multifunction
steering wheel 26, 140, 490
Button operation 140
N
Navigation system* 146
See separate
COMAND* operating instructions
Net, Parcel 280
Neutral gear position 168
New vehicle break-in 306
Night security illumination 129
Normal occupant weight 356
Number, vehicle identification (VIN) 468