2006 Lexus GS430 charging

For detailed information, refer to the description given in each Section\
.
PICTORIAL INDEX
viPage
1
Tachometer 71
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
2 Headlight high beam indicator light 49
. . . . . . . . . . .
3 Turn signal indicator light 49
. . . . . . . . . . . . . . . . . . . .
4 Headlight indicator light 46
. . . . . . . . . . . . . . . . . . . . . .
5 Slip indicator light 425, 428, 429
. . . . . . . . . . . . . . . . . .
6 Fog light indicator light 50
. . . . . . . . . . . . . . . . . . . . . . .
7 Driver’s seat belt reminder light 77
. . . . . . . . . . . . . . .
8 SRS warning light 78
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
9 Open door warning light 81
. . . . . . . . . . . . . . . . . . . . . .
10 Automatic transmission indicator lights 359 . . . . . .
11 Fuel gauge 70
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
12 Fuel filler door indicator 132
. . . . . . . . . . . . . . . . . . . . .
13 Low fuel level warning light 82
. . . . . . . . . . . . . . . . . . .
14 Engine coolant temperature gauge 70
. . . . . . . . . . . .
15 Charging system warning light 79
. . . . . . . . . . . . . . . .
16 Brake system warning light (yellow) 77
. . . . . . . . . . . Page
17 Malfunction indicator lamp
79
. . . . . . . . . . . . . . . . . . .
18 Adaptive frontlighting system off
indicator light 48 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
19 Antilock brake system warning light 80
. . . . . . . . . .
20 Precollision system warning light 82
. . . . . . . . . . . .
21 Brake system warning light (red) 76
. . . . . . . . . . . . . .
22 Master warning light 80
. . . . . . . . . . . . . . . . . . . . . . . . .
23 Electric power steering system warning light 82 . .
24 Multiinformation display 84
. . . . . . . . . . . . . . . . . . . . .
25 Odometer and trip meter 72
. . . . . . . . . . . . . . . . . . . . .
26 Tire pressure warning light 81
. . . . . . . . . . . . . . . . . . .
27 Intuitive parking assist indicator light 373
. . . . . . . .
28 Snow mode indicator light 371
. . . . . . . . . . . . . . . . . . .
29 Cruise control indicator light 398
. . . . . . . . . . . . . . . .
30 Power mode indicator light 371
. . . . . . . . . . . . . . . . . .
31 Damping mode indicator light 424
. . . . . . . . . . . . . . . .

For detailed information, refer to the description given in each Section\
.
PICTORIAL INDEX
viiiPage
1
Tachometer 71
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
2 Headlight high beam indicator light 49
. . . . . . . . . . .
3 Turn signal indicator light 49
. . . . . . . . . . . . . . . . . . . .
4 Tail light indicator light 46
. . . . . . . . . . . . . . . . . . . . . . .
5 Slip indicator light 425, 428, 429
. . . . . . . . . . . . . . . . . .
6 Fog light indicator light 50
. . . . . . . . . . . . . . . . . . . . . . .
7 Driver’s seat belt reminder light 77
. . . . . . . . . . . . . . .
8 SRS warning light 78
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
9 Open door warning light 81
. . . . . . . . . . . . . . . . . . . . . .
10 Automatic transmission indicator lights 359 . . . . . .
11 Fuel gauge 70
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
12 Fuel filler door indicator 132
. . . . . . . . . . . . . . . . . . . . .
13 Low fuel level warning light 82
. . . . . . . . . . . . . . . . . . .
14 Engine coolant temperature gauge 70
. . . . . . . . . . . .
15 Charging system warning light 79
. . . . . . . . . . . . . . . .
16 Brake system warning light (yellow) 77
. . . . . . . . . . . Page
17 Malfunction indicator lamp
79
. . . . . . . . . . . . . . . . . . .
18 Adaptive frontlighting system off
indicator light 48 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
19 Antilock brake system warning light 80
. . . . . . . . . .
20 Precollision system warning light 82
. . . . . . . . . . . .
21 Brake system warning light (red) 76
. . . . . . . . . . . . . .
22 Master warning light 80
. . . . . . . . . . . . . . . . . . . . . . . . .
23 Electric power steering system warning light 82 . .
24 Multiinformation display 84
. . . . . . . . . . . . . . . . . . . . .
25 Odometer and trip meter 72
. . . . . . . . . . . . . . . . . . . . .
26 Tire pressure warning light 81
. . . . . . . . . . . . . . . . . . .
27 Intuitive parking assist indicator light 373
. . . . . . . .
28 Snow mode indicator light 371
. . . . . . . . . . . . . . . . . . .
29 Cruise control indicator light 398
. . . . . . . . . . . . . . . .
30 Power mode indicator light 371
. . . . . . . . . . . . . . . . . .
31 Damping mode indicator light 424
. . . . . . . . . . . . . . . .

GAUGES, METERS AND SERVICE REMINDER INDICATORS
79
(f) Charging System Warning Light
This warning light comes on when the engine switch is
selected in “IG−ON” mode, and goes off when the engine is
started.
When there are problems in the charging system while the
engine is running, the warning light comes on.
NOTICE
When the charging system warning light comes on
while the engine is running, malfunctions such as the
engine drive belt being broken may have occurred. If
the warning light comes on, immediately stop the
vehicle in a safe place and contact your Lexus dealer.
(g) Malfunction Indicator Lamp
This lamp comes on when the engine switch is selected in
“IGON” mode and goes off after the engine starts. This
means that the warning light system is operating properly.
If the lamp remains on, or the lamp comes on while
driving, first check the followings:
 Empty fuel tank
If the fuel tank is empty, refuel immediately.
 Loose fuel tank cap
If the fuel tank cap is loose, securely tighten it.
These cases are temporary malfunctions. The malfunction
indicator lamp will go off after taking several driving trips.
If the lamp does not go off even after several trips, contact your
Lexus dealer as soon as possible.
If the fuel tank is not empty or the fuel tank cap is not
loose...
 There is a problem somewhere in the engine, emission
control system, electronic throttle control system, automatic
transmission electrical system or warning light system itself.
Contact your Lexus dealer as soon as possible to service the
vehicle.
If this lamp comes on and engine speed does not increase
when the accelerator pedal is depressed, there may be a
problem somewhere in the electronic throttle control system.

IN CASE OF AN EMERGENCY
472
CAUTION
When making the connections, to avoid serious injury,
do not lean over the battery or accidentally let the
jumper cables or clamps touch anything except the
correct battery terminals or the ground.
5. Charge the discharged battery with the jumper cables
connected for approximately 5 minutes. At this time, run the
engine in the vehicle with the booster battery at about 2000
rpm with the accelerator pedal lightly depressed.
6. Start your engine in the normal way. After starting, run it at
about 2000 rpm for several minutes with the accelerator pedal
lightly depressed.
7. Carefully disconnect the cables in the exact reverse order:
the negative cable and then the positive cable.
8. Carefully dispose of the battery cover cloths which may now
contain sulfuric acid.
9. If removed, replace all the battery vent plugs.
The engine may not restart even after battery charging or
replacement. If this happens, see “(d) Starting the engine after
a battery discharge”.
If the cause of your battery discharging is not apparent (for
example, lights left on), you should have it checked at your
Lexus dealer. If the first start attempt is not successful...
Check
that the clamp on the jumper cables are tight. Recharge
the discharged battery with the jumper cables connected for
several minutes and restart your engine in the normal way.
If another attempt is not successful, the battery may be
depleted. Have it checked at your Lexus dealer.(d) Starting the engine after a battery discharge
In the event that the battery is discharged, the engine may
not restart even after the battery is recharged or replaced.
For safety reasons, the engine may be disabled when
battery voltage is extremely low. If the engine is disabled,
the start system must be normalized.
To normalized the start system:
1. Shift the transmission to the “P” position and set the engine
switch off.
2. Open and close any of the doors.
3. Start the engine.

ENGINE
522– COOLING SYSTEM
Capacity
10.1 L (10.7 qt., 8.9 lmp.qt.)
Coolant type”Toyota Super Long Life Coolant” or similar high quality ethylene glyco\
l
based non −silicate, non− amine, non−nitrite, and non −borate coolant
with long −life hybrid organic acid technology (Coolant with long −life
hybrid organic acid technology is a combination of low phosphates and
organic acids.)
Do not use plain water alone.
NOTE:
“Toyota Super Long Life Coolant” is used in your Lexus vehicle at factory fil\
l. In order to avoid technical problems, only use ”Toyota
Super Long Life Coolant” or similar high quality ethylene glycol based non −silicate, non −amine, non −nitrite, and non −borate coolant
with long−life hybrid organic acid technology. (Coolant with long −life hybrid organic acid technology is a combination of low
phosphates and organic acids.) Do not use plain water alone. Please contact you\
r Lexus dealer for further details.
– IGNITION SYSTEM
Spark plug – Make DENSO NGK
– Gap
SK20R11
IFR6A11
1.1 mm (0.043 in.)
– ELECTRICAL SYSTEM
Battery – Open voltage at 20 C (68F):
– Charging rates
12.7V Fully charged
12.3V Half charged
11.9V Discharged
[Voltage that is checked 20 minutes after the engine switch is off with all
the lights turned off]
5A max.

ENGINE
525
– COOLING SYSTEM
Capacity
9.1 L (9.6 qt., 8.0 lmp.qt.)
Coolant type”Toyota Super Long Life Coolant” or similar high quality ethylene glyco\
l
based non −silicate, non− amine, non−nitrite, and non −borate coolant
with long −life hybrid organic acid technology (Coolant with long −life
hybrid organic acid technology is a combination of low phosphates and
organic acids.)
Do not use plain water alone.
NOTE:
“Toyota Super Long Life Coolant” is used in your Lexus vehicle at factory fil\
l. In order to avoid technical problems, only use ”Toyota
Super Long Life Coolant” or similar high quality ethylene glycol based non −silicate, non −amine, non −nitrite, and non −borate coolant
with long−life hybrid organic acid technology. (Coolant with long −life hybrid organic acid technology is a combination of low
phosphates and organic acids.) Do not use plain water alone. Please contact you\
r Lexus dealer for further details.
– IGNITION SYSTEM
Spark plug – Make DENSO NGK
– Gap
FK20HBR11
ILFR6D11T
1.1 mm (0.043 in.)
– ELECTRICAL SYSTEM
Battery – Open voltage at 20 C (68F):
– Charging rates
12.7V Fully charged
12.3V Half charged
11.9V Discharged
[Voltage that is checked 20 minutes after the engine switch is off with all
the lights turned off]
5A max.

SECTION 6 – 4
573
SERVICE PROCEDURES AND
SPECIFICATIONS
Electrical components
Specifications574
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
. . . . . .
Checking battery condition 581
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Battery recharging precautions 584
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Checking and replacing the blade type fuses 584
. . . . . . . . . . . . . . . .
Checking the cartridge type fuses 587
. . . . . . . . . . . . . . . . . . . . . . . . . .
Adding washer fluid 589
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
.
Checking the headlight aim 589
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Replacing light bulbs 594
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\

ELECTRICAL COMPONENTS
577
No.FUSEAMPERECIRCUIT
18 FR DOORRH20
Front right door control system
(Power door lock system,
Power rear view mirror control
system, Door courtesy light,
Outside rear view mirror heater,
Power window), Multiplex
communication system
19 RR DOOR RH20Rear right door control system
(Power door lock system, Door
courtesy light, Power window)
20 RR DOOR LH20Rear left door control system
(Power door lock system, Door
courtesy light, Power window)
21 FR DOORLH20
Front left door control system
(Power door lock system,
Power rear view mirror control
system, Door courtesy light,
Outside rear view mirror heater,
Power window)
22 RAD NO.310Audio system
23 HLP LVL7.5Adaptive front lighting system
(AFS), Automatic headlight
leveling control system
No.FUSEAMPERECIRCUIT
24 LHIG10
Charging system, Headlight
cleaners, Exhaust gas sensor,
Rear window defogger, Electric
cooling fans, Rear left door
control system, Front left door
control system, Emergency
flashers, Automatic
transmission, Seat belt
pretensioners, Intuitive parking
assist
25 FR WIP30Windshield wipers and washer
26 PANEL7.5
Steering switch illumination,
Audio system, Glove box light,
Automatic transmission selector
lever illumination, Console box
light, Adaptive variable
suspension switch illumination,
Cigarette lighter illumination, Air
conditioning system, Traction
control off switch illumination,
Driving pattern selector switch,
Seat heater or Heated and
ventilated seat switches,
Register ILL RH, Register ILL
LH, Register ILL CTR
27 FUEL
OPEN10Fuel filler door opener, Trunk lid
opener