2006 Lancia Thesis fuel pressure

239
In an emergency, the flap can be
released by pulling wire B(fig. 216)
on the right-hand side of the boot
inside the service compartment.
To open the compartment flap,
turn the catch C(fig. 217) to 1using
the ignition key and lower it.IMPORTANT The airtight seal of
the cap may lead to a slight increase
of pressure in the tank. A hissing
sound when the cap is removed is
therefore quite normal.
The cap is equipped with a device
which fastens it to the flap so that it
cannot be misplaced D(fig. 218).
While you are filling up, fasten the
cap to the device inside the flap as
shown in the figure.
Do not put naked flames
or lighted cigarettes near
the fuel filler hole as there
is a danger of fire. Do not bend too
close to the hole either so as not to
breathe in harmful vapours.REFUELLING
To guarantee full tank filling, carry
out two refuelling operations after the
first click of the fuel delivery gun. Avoid
further topping up operations that
could cause damages to the fuel system.
IMPORTANTRefuelling shall always
be performed with engine off and igni-
tion key to STOP. If the engine is off
but the key is to MAR, a wrong fuel
level could temporarily be indicated.
This is due to the internal system con-
trol logic and cannot be considered as
a system malfunctioning.
fig. 217
L0A0303b
fig. 218
L0A0014b
fig. 216
L0A0015b

260
CONTAINING RUNNING COSTS AND
POLLUTION
Some suggestions which may help
you to keep the running costs of the
car down and lower the amount of
toxic emissions released into the
atmosphere are given below.
GENERAL CONSIDERATIONS
Car maintenance
The overall state of the car is an
important factor which has a
marked influence over fuel con-
sumption and driving comfort and
on the life span of your car. For this
reason care should be taken to main-
tain your car by carrying out the
necessary checks and regulations in
accordance with the specifications
given in the “Service Schedule” (see
sections: spark plugs, air cleaners,
timing...).Tyres
Tyre pressure should be checked at
least once every four weeks: if the
pressure is too low fuel consumption
increases as the resistance to the
rolling movement of the tyre is
greater. In this state, tyre wear is
increased and handling suffers,
which will effect safety.
Unnecessary loads
Do not travel with too much load in
the boot. The weight of the car (in
town traffic above all), and its trim
greatly effect consumption and sta-
bility.Roof rack/ski rack
Remove the roof or ski racks from
the car as soon as they are no longer
needed. These accessories reduce the
aerodynamic penetration of the car
and will increase consumption.
When transporting particularly
large objects, use a trailer, where
possible.
Electrical devices
Use electrical devices for the neces-
sary time only. The heated rear win-
dow, fog lights, windscreen wipers,
heater fan require large amounts of
electricity and increasing the request
for power will also increase fuel con-
sumption (up to +25% when driving
in towns).
Climate control system
The climate control system is an
additional load which greatly effects
the engine leading to higher con-
sumption (up to +20% in average).
When the temperature outside
allows, use the air vents where pos-
sible.

312
SERVICE SCHEDULE
20 40 60 80 100 120 140 160 180 thousands of kilometres
ççççç çççç
ççççç çççç
ççççç çççç
çç çç
ççççç çççç
ççççç çççç
çç
çç çç
ççççç çççç
çç
çç çç
ççççç çççç
ççççç ççççCheck tyre conditions and wear; adjust pressure, if required
Check primary and secondary battery charge status
Check wear of windscreen/rear window blades
Check rear disc brake pad wear
Inspect conditions of: underbody protection and outside
bodywork, piping (exhaust - fuel lines - brake lines), rubber parts
(boots, sleeves, bushings, etc.), brake and fuel line hoses
Check for bonnet and boot lock cleanness, lever cleanness
and lubrication
Sight check for conditions of Poly-V accessory drive belt
Check diesel engine smokiness in exhaust
Replace fuel filter (JTD versions)
Check fuel evaporation system operation
Replace air cleaner cartridge (petrol versions)
Replace air cleaner cartridge (JTD versions)
Check and top up fluids (engine coolant, brakes,
hydraulic clutch, power steering, windscreen washer, battery, etc.)

314
ADDITIONAL
CHECKS
Every 1,000 kmor before long
trips, check and top up as necessary:
– engine coolant level
– brake/hydraulic clutchfluid
level
– power steering fluid level
– windscreen/rear window and
headlight washer fluid level
– tyre pressure and conditions.
Every 3,000 kmcheck the engine
oil level and top up as necessary.
You are recommended to use FL
Seleniaproducts that are designed
and produced specifically for LAN-
CIA cars (see “Capacities” in
“Technical Specifications”).
ANNUAL
INSPECTION
SCHEDULE
The following annual inspection
schedule is recommended for
cars travelling less than 20,000
km a year (e.g. approximately
10,000 km). The schedule
includes the following opera-
tions:
1) Check tyre condition and wear
and adjust pressure (including spare
wheel)
2) Check wear on windscreen/rear
window blades
3) Check rear disc brake pad con-
ditions and wear
4) Inspect conditions of: under-
body protection and outside body-
work, piping (exhaust - fuel lines -
brake lines), rubber parts (boots -
sleeves - bushings, etc.), brake and
fuel line hoses5) check for bonnet and boot lock
cleanness, lever cleanness and lubri-
cation
6) Check primary and secondary
battery charge status
7) Check conditions of various con-
trol belts
8) Check and top up fluid levels
(engine coolant, brakes, windscreen
washer, battery, etc.)
9) Change engine oil
10) Replace engine oil filter
11) Replace dust/pollen filter.

Fiat Auto S.p.A.
Quality - Assistenza Tecnica - Ingegneria Assistenziale
Largo Senatore G. Agnelli, 5 - 10040 Volvera - Torino (Italia)
Print n. 603.45.954 - XI/2006 - 2ndEdition
COLD TYRE INFLATION PRESSURE (bar) (snow tyres excluded)
ENGINE OIL CHANGE
5.505.50 5.0
FUEL CAPACITIES
5.90
75
1075
1075
1075
10 215/60 R16 95W
215/60 ZR16 95W
225/50 R17 94W (*)
225/50 ZR17 94W (*)
2.3
2.3 215/60 R16 95W
215/60 ZR16 95W
225/50 R17 94W (*)
225/50 ZR17 94W (*)
2.3
2.3 215/60 R16 95W
215/60 ZR16 95W
225/50 R17 94W (*)
225/50 ZR17 94W (*)
2.3
2.3215/60 R16 95W
215/60 ZR16 95W
225/50 R17 94W (*)
225/50 ZR17 94W (*)
2.3
2.3
2.0 TB 2.4 2.4 CAE 2.4 JTD 20VCAE 3.2 V6 CAE
Front and rear
tyres
Reduced load bar
Full load bar
(*) Tyres that cannot be fitted with chains.
0.3 bar should be added to the values given if the pressure is measured while the tyre is hot.
2.0 TB 2.4 - 2.4 CAE 2.4 JTD 20VCAE 3.2 V6 CAE
Engine oil (quantity for
periodical remplacement -
sump and filter) litres
#Dispose of waste oil properly.
2.0 TB 2.4 - 2.4 CAE 2.4 JTD 20VCAE 3.2 V6 CAE
Tank capacity litres
Reserve litres
Refuel petrol engines with unleaded petrol with octane rating (RON) no lower than 95 only.
Refuel diesel engines with diesel fuel for motor vehicles (EN590 specifications) only.