2006 JEEP GRAND CHEROKEE torque

CAUTION!
Using a transmission fluid other than the manufac-
turer’s recommended fluid may cause deterioration
in transmission shift quality and/or torque converter
shudder. Using a transmission fluid other than the
manufacturer’s recommended fluid will result in
more frequent fluid and filter changes. Refer to
Fluids, Lubricants, and Genuine Parts for correct
fluid type.
Fluid Level Check
NOTE:If equipped with a dipstick, use the following
procedure. If your vehicle has a capped dipstick tube, it
is sealed and should not be tampered with. Your autho-
rized dealer has the proper tools to ensure that the fluid
level is set properly.Check the fluid level while the transmission is at normal
operating temperature. This occurs after at least 15 miles
(25 km) of driving. At normal operating temperature the
fluid cannot be held comfortably between the fingertips.
To check the automatic transmission fluid level properly,
the following procedure must be used:
1. Operate the engine at idle speed and normal operating
temperature.
2. The vehicle must be on level ground.
3. Fully apply the parking brake and press the brake
pedal.
4. Place the gear selector momentarily in each gear
position ending with the lever in P (Park).
5. Remove the dipstick, wipe it clean and reinsert it until
seated.
372 MAINTAINING YOUR VEHICLE

Special Additives
The manufacturer recommends against the addition of
any additives to the transmission. Exception to this
policy is the use of special dyes to aid in detecting fluid
leaks.
Transfer Case
Fluid Level Check
Inspect the transfer case for fluid leaks. If a fluid leak is
found, the transfer case fluid level can be checked by
removing the filler plug located on the back side of the
transfer case. The fluid level should be at the bottom edge
of the filler plug hole when the vehicle is in a level
position.
Adding Fluid
Add fluid at the filler hole until it runs out of the hole
when the vehicle is in a level position.
Drain
First remove fill plug, then remove drain plug. Recom-
mended tightening torque for drain and fill plugs is
15–25 ft. lbs (20–34 N·m).
CAUTION!
When installing plugs, do not overtighten. You could
damage them and cause them to leak.
Selection of Lubricant
Use only manufacturer’s recommended fluid, refer to
Fluids, Lubricants, and Genuine Parts for correct fluid
type.
374 MAINTAINING YOUR VEHICLE

Front/Rear Axle Fluid
Front Axle Fluid Level Check
Lubricant should be to the bottom of the oil fill hole.
Rear Axle Fluid Level Check
Lubricant should be 1/2”(1 cm) below the oil fill hole.
Adding Fluid
Add lubricant only at the fill hole and only to the level
specified above.
Selection of Lubricant
Use only manufacturer’s recommended fluid, refer to
Fluids, Lubricants, and Genuine Parts for correct fluid
type.
Maintenance After Off-Pavement Driving
After extended operation in mud, sand or water, or
similar dirty conditions, have your brake discs, brake
linings, and axle joints inspected and cleaned as soon as
possible. This will prevent any abrasive material from
causing excessive wear or unpredictable braking action.
Following off-pavement usage, completely inspect the
underbody of your vehicle. Check tires, body structure,
steering, suspension and exhaust system for damage.
Check threaded fasteners for looseness, particularly on
the chassis, drivetrain components, steering and suspen-
sion. Retighten, if required, to torque values specified in
the Service Manual. Also check for accumulations of
vegetation or brush that could become a fire hazard, or
conceal damage to fuel lines, brake hoses, axle pinion
seals, and propeller shafts.
MAINTAINING YOUR VEHICLE 375
7

ABS (Anti-Lock Brake System)............181,269
Adding Washer Fluid..................... 171
Adjustable Pedals....................... 146
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . 358
Air Conditioner Maintenance............... 359
Air Conditioning........................ 233
Air Conditioning, Operating Tips............ 237
Air Conditioning Refrigerant............... 360
Air Conditioning System.................. 233
Air Filter.............................. 358
Air Pressure, Tires....................... 288
Airbag................................ 41
Airbag Deployment....................... 53
Airbag Light.......................56,70,181
Airbag Maintenance....................... 55
Alarm (Security Alarm).................24,182
Alarm System (Security Alarm)............... 24
Alignment and Balance................... 293
Alterations/Modifications, Vehicle............. 8Antenna, Satellite Radio................... 230
Antifreeze (Engine Coolant)................ 392
Anti-Lock Brake System (ABS)............131,269
Anti-Lock Warning Light.................. 181
Anti-Theft System.....................24,182
Appearance Care........................ 376
Auto Down Power Windows................ 29
Automatic Dimming Mirror................. 79
Automatic Door Locks..................... 19
Automatic Headlights.................... 122
Automatic Temperature Control (ATC)......... 238
Automatic Transmission................254,371
Adding Fluid......................... 373
Fluid and Filter Changes................. 371
Fluid Level Check...................... 372
Fluid Type........................... 371
Special Additives...................... 374
Torque Converter...................... 260
Autostick............................. 256
424 INDEX

Tire Identification Number (TIN)............. 282
Tire Markings.......................... 279
Tire Safety Information.................... 279
Tires ............................70,287,421
Air Pressure.......................... 288
Alignment and Balance.................. 293
Chains.............................. 300
Changing............................ 330
General Information.................... 287
High Speed.......................... 290
Inflation Pressures..................... 288
Jacking............................. 330
Life of Tires.......................... 292
Load Capacity.....................283,284
Pressure Monitor System (TPMS)........... 294
Pressure Warning Light.................. 183
Quality Grading....................... 421
Radial.............................. 290
Replacement......................... 292Rotation............................. 301
Safety............................70,279
Sizes............................... 280
Spare Tire........................... 331
Spinning............................ 290
Tread Wear Indicators................... 291
Wheel Mounting....................... 335
Tongue Weight/Trailer Weight.............. 313
Torque Converter Clutch.................. 260
Tow Hooks, Emergency................... 338
Tow/Haul Indicator Light................. 184
Towing............................308,339
Disabled Vehicle....................... 339
Guide.............................. 312
Recreational.......................... 320
Weight.............................. 312
Traction Control......................... 132
Traction Control Light.................... 182
Trailer Towing.......................... 308
INDEX 439
10