2006 HONDA S2000 catalytic converter

¶¶
This shows how much f uel you have.
It may show slightly more or less
than the actual amount.
This shows the temperature of the
engine’s coolant. During normal
operation, the reading should be in
the middle of the gauge. In severe
driving conditions, such as very hot
weather or a long period of uphill
driving, the reading may reach near
the red mark. If it reaches the red
(Hot) mark, pull saf ely to the side of
the road. See page f or
instructions and precautions on
checking the engine’s cooling
system.This indicator displays the outside
temperature in Fahrenheit (U.S.
models) or Centigrade (Canadian
models).
The temperature sensor is in the
f ront bumper. Theref ore, the
temperature reading can be af f ected
by heat ref lection f rom the road
surf ace, engine heat, and the
exhaust f rom surrounding traf f ic.
This can cause an incorrect
temperature reading when your
speed is under 19 mph (30 km/h).
The sensor delays the indicator
update until it reaches the correct
outside temperature. This may take
several minutes.
If the outside temperature is
incorrectly displayed, you can adjust
it up 5°F in U.S. models ( 3°C in
Canadian models) warmer or cooler.
179
Fuel Gauge T emperature Gauge Outside T emperature Indicator
Gauges
52
Avoid driving with an extremely low
f uel level. Running out of f uel could
cause the engine to misf ire, damaging
the catalytic converter.
——y
y
(yy

Make sure the convertible top and
the windows are closed.
Turn of f the lights.
Place any packages, valuables, etc.,
in the trunk or take them with you.
Lock the doors.
Never park over dry leaves, tall
grass, or other f lammable
materials. The hot three way
catalytic converter could cause
these materials to catch on fire.If the vehicle is f acing uphill, turn
the front wheels away from the
curb, and put the transmission in
f irst gear.
If the vehicle is f acing downhill,
turn the front wheels toward the
curb, and put the transmission in
reverse gear.
Make sure the parking brake is
f ully released bef ore driving away.
Driving with the parking brake
partially set can overheat or
damage the rear brakes.
Resting your f oot on the pedal keeps
the brakes applied lightly, builds up
heat, and reduces their ef f ectiveness.
It also keeps your brake lights on all
the time, conf using drivers behind
you.
Constant application of the brakes
when going down a long hill builds
up heat and reduces their ef f ective-
ness. Use the engine to assist the
brakes by taking your f oot of f the
accelerator and downshif ting to a
lower gear.
Always use the parking brake when
you park your vehicle. Make sure
the parking brake is set f irmly or
your vehicle may roll if it is on an
incline.
Your vehicle is equipped with disc
brakes at all f our wheels. A power
assist helps reduce the ef f ort needed
on the brake pedal. The anti-lock
brake system (ABS) helps you retain
steering control when braking very
hard.
CONT INUED
Parking
Parking T ipsBraking System
Parking, Braking System
Driving
125
——y
y
(y
y

Thediagramsinthissectiongive
you the dimensions and capacities of
your vehicle, and the locations of the
identif ication numbers. It also
includes inf ormation you should
know about your vehicle’s tires and
emissions control systems.................
Identif ication Numbers .194
................................
Specif ications .196
DOT Tire Quality Grading
......................
(U.S. Vehicles) .198
Unif orm Tire Quality ..................................
Grading .198
.................................
Treadwear .198
......................................
Traction .198
.............................
Temperature .199
.................................
Tire Labeling .200 .......................
Emissions Controls .201
.....................
The Clean Air Act .201
Crankcase Emissions Control
....................................
System .201
Evaporative Emissions Control ....................................
System .201
Onboard Ref ueling Vapor ................................
Recovery .201
...
Exhaust Emissions Controls .202
....................
PGM-FI System .202
Ignition Timing Control
................................
System .202
Three Way Catalytic ...........................
Converter .202
....................
Replacement Parts .202
..
Three Way Catalytic Converter .203
..............
State Emissions Testing .204
T echnical Inf ormation
Technical Inf ormation
193
——y


y
(y
y

The emissions control systems are
designed and certif ied to work to-
gether in reducing emissions to
levels that comply with the Clean Air
Act. To make sure the emissions
remain low, you should use only new
Honda replacement parts or their
equivalent f or repairs. Using lower
qualitypartsmayincreasethe
emissions f rom your vehicle.
This system constantly adjusts the
ignition timing, reducing the amount
of HC, CO, and NOx produced.
The emissions control systems are
covered by warranties separate from
the rest of your vehicle. Read your
warranty manual for more informa-
tion.
The exhaust emissions controls
include three systems: PGM-FI,
ignition timing control, and three
way catalytic converter. These three
systems work together to control the
engine’s combustion and minimize
the amount of HC, CO, and NOx that
comes out the tailpipe. The exhaust
emissions control systems are
separate f rom the crankcase and
evaporative emissions control
systems.
The PGM-FI System uses sequential
multiport f uel injection.
It has three subsystems: air intake,
engine control, and f uel control. The
engine control module (ECM) uses
various sensors to determine how
much air is going into the engine. It
then controls how much f uel to inject
under all operating conditions. The three way catalytic converter is
in the exhaust system. Through
chemical reactions, it converts HC,
CO, and NOx in the engine’s exhaust
to carbon dioxide (CO ), nitrogen
(N ), and water vapor.
2
2
Emissions Cont rols
Exhaust Emissions Controls Replacement PartsIgnit ion T iming Cont rol Syst em
PGM-FI System Three Way Catalytic Converter
202
——y


y
(yy

The three way catalytic converter
contains precious metals that serve
as catalysts, promoting chemical
reactions to convert the exhaust
gasses without af f ecting the metals.
The catalytic converter is ref erred to
as a three-way catalyst, since it acts
on HC, CO, and NOx. A replacement
unit must be an original Honda part
or its equivalent.
The three way catalytic converter
must operate at a high temperature
for the chemical reactions to take
place. It can set on f ire any
combustible materials that come
near it. Park your vehicle away from
high grass, dry leaves, or other
f lammables.A defective three way catalytic
converter contributes to air pollution,
and can impair your engine’s per-
f ormance. Follow these guidelines to
protect your vehicle’s three way
catalytic converter.
Always use unleaded gasoline.
Even a small amount of leaded
gasoline can contaminate the
catalyst metals, making the three
way catalytic converter inef f ective. Keep the engine tuned-up.
Have your vehicle diagnosed and
repaired if it is misf iring, back-
f iring, stalling, or otherwise not
running properly.
Three Way Catalytic Converter
Technical Inf ormation
203
THREE WAY CATALYTIC CONVERTER
——y

y
(yy

ÎÎ
CONT INUED
..........
Taillights, Changing Bulbs .156
.
Taking Care of the Unexpected .169
Technical Descriptions
....
DOT Tire Quality Grading .198
.....
Emissions Control Systems .201
Three Way Catalytic
...............................
Converter .203 .......................
Temperature Gauge .52
...................
Tensioners, Seat Belts .18
................
Thef t Protection, Radio .102
..
Three Way Catalytic Converter .203
............................
Time, Setting the .54
....................................
Tire Chains .165
.........
Tire, How to Change a Flat .171
.................................
Tire Labeling .200
...............................................
Tires .161
..............................
Air Pressure .162
...................................
Balancing .163
........................................
Chains .165
.........................
Checking Wear .162
.................
Compact Spare Tire .170
....
DOT Tire Quality Grading .198
......................................
Inf lation .161
..................................
Inspection .162
...................................
Replacing .164
........................
Rotation, Do not .163
...........................................
Snow .165
............................
Specif ications .197
...........................................
Wear .163
...................
Tools, Tire Changing .171
Shif ting
..............
Manual Transmission .123
Side Turn Signal, Bulb ..............................
Replacement .155
...............................
Signaling Turns .57
.....................................
Snow Tires .165
..................................
Sound System .86
Spare Tire ......................................
Inf lating .162
............................
Specif ications .197
....................................
Spark Plugs .196
................................
Specif ications .196
................................
Speed Control .103
................................
Speed Limiter .124
..........
SRS, Additional Inf ormation .20
...
Additional Safety Precautions .27
.............................
Airbag Service .27
......
Airbag System Components .20
How the SRS Indicator
.......................................
Works .25
How Your Front Airbags .........................................
Work .22
.............................
SRS Indicator .25,47
...................................
Start Button .122.......................
Starting the Engine .122
In Cold Weather at High ..................................
Altitude .122
................
With a Dead Battery .178
..............
State Emissions Testing .204
........
Steam Coming f rom Engine .179
Steering Wheel
.............
Anti-theft Column Lock .62
.....................
Stereo Sound System .86
....................
Storing Your Vehicle .167
................................
Stuck Vehicle .191
Supplemental Restraint System ..................................
Servicing .27
.........................
SRS Indicator .25,47
...................
System Components .20
..................................
Synthetic Oil .144
Index
T
INDEX
VII
——y


y
(yy