2006 HONDA ACCORD engine

µµ µµÎ Î
ÎÎ
Î Î Î Î
ÎÎ ÎÎÎÎ
Specif ications
266
Dimensions
Air Conditioning
Weights
Capacities Capacities
189.5 in (4,813 mm)
71.7 in (1,820 mm)
57.2 in (1,453 mm)
HFC-134a (R-134a)
25 27 oz (700 750 g)
16 18 oz (450 500 g) ND-OIL8
17.09 US gal (64.7
)
107.9 in (2,740 mm)
61.1 in (1,553 mm)
61.2 in (1,554 mm)
Length
Width
Height
Wheelbase
Track
Refrigerant type
Charge quantity
Lubricant type
Gross vehicle weight rating See the certification label attached
to the driver’s doorjamb.
Fuel tank
Engine
coolant 1.35 US gal (5.1
)
1.32 US gal (5.0)
1.77 US gal (6.7)
1.90 US gal (7.2
)
1.88 US gal (7.1)
2.22 US gal (8.4) 4.4 US qt (4.2
)
4.5 US qt (4.3)
4.2 US qt (4.0)
5.6 US qt (5.3
)
5.3 US qt (5.0)
2.0 US qt (1.9)
2.2 US qt (2.1
)
3.1 US qt (2.9
)
3.2 US qt (3.0)
6.9 US qt (6.5)
7.4 US qt (7.0)
2.6 US qt (2.5)
4.8 US qt (4.5)
Engine oil
Manual trans-
mission oil Automatic
transmission
fluid
Windshield
washer
reservoir
2.3 US qt (2.2
)
2.6 US qt (2.5
)
Excluding the oil remaining in the engine.
Including the coolant in the reserve tank and that remaining in the
engine.
Reserve tank capacity: 0.16 US gal (0.6
)
6-cylinder models
Approx.
Front Rear
2: 3:
Change
Manual Automatic
Total ManualAutomatic Change
Including
filter
Without
filter
Total
ChangeTotal
ChangeTotalU.S.
Canada
1:
1
2 1 1 3
11 1111
——yy
(yy

µ
Î ÎÎ
ÎÎÎ Î
Î Î
Î
Î
ÎÎ ÎÎ ÎÎ
ÎÎ ÎÎ ÎÎÎÎ
ÎÎÎÎÎÎÎÎ
Specif ications
268
Engine
Alignment Tires
Type
BorexStroke
Displacement
Compression ratio
Spark plugs Water cooled 4-stroke, DOHC
i-VTEC 4-cylinder, SOHC VTEC
6-cylinder (V6), gasoline engine
3.43 x 3.9 in (87.0 x 99.0 mm)
3.39 x 3.39 in (86.0 x 86.0 mm) 143.6 cu-in (2,354 cm
)
182.8 cu-in (2,997 cm)
9.7 : 1
10 : 1
IZFR6K-11 SKJ20DR-M11IZFR6K-13SKJ20DR-M13
Toe-in
CamberCaster 0.00 in (0.0 mm)
0.08 in (2.0 mm)
0°1°
3°15’ Size
Pressure
P195/65R15 89H
T135/90D15
60 psi (420 kPa , 4.2 kgf/cm
)
P205/65R15 92H
29 psi (200 kPa , 2.0 kgf/cm)
30 psi (210 kPa , 2.1 kgf/cm)
P205/60R16 91V
30 psi (210 kPa , 2.1 kgf/cm)
32 psi (220 kPa , 2.2 kgf/cm)
P215/50R17 93V
Front Rear
FrontRear
Front NGK:
DENSO:NGK:
DENSO:
4-cylinder models
6-cylinder models
On some models
3:4:5: Front/Rear
Spare
Front Rear
Spare
U.S. VP
U.S. LX
U.S. SE, EX and EX-L
Canadian DX-G, SE and EX-L
U.S. LX-V6 and EX-V6
Canadian SE-V6 and EX-V6
1:2:3: 4:3 4
3
4
34 3, 4 3, 4
3, 5 3, 5 1234
1, 3, 42
1, 3
2, 4
——yy
(y
y

Î
ÎThe burning of gasoline in your
vehicle’s engine produces several by-
products. Some of these are carbon
monoxide (CO), oxides of nitrogen
(NOx), and hydrocarbons (HC).
Gasoline evaporating f rom the tank
also produces hydrocarbons. Con-
trolling the production of NOx, CO,
and HC is important to the environ-
ment. Under certain conditions of
sunlight and climate, NOx and HC
react to f orm photochemical ‘‘smog.’’
Carbon monoxide does not contri-
bute to smog creation, but it is a
poisonous gas. The United States Clean Air Act
sets standards f or automobile
emissions. It also requires that
automobile manufacturers explain to
owners how their emissions controls
workandwhattodotomaintain
them. This section summarizes how
the emissions controls work.
In Canada, Honda vehicles comply
with the Canadian emission
requirements, as specif ied in an
agreement with Environment
Canada, at the time they are
manuf actured.
Your vehicle has a positive
crankcase ventilation system. This
keeps gasses that build up in the
engine’s crankcase f rom going into
the atmosphere. The positive
crankcase ventilation valve routes
them from the crankcase back to the intake manif old. They are then
drawn into the engine and burned.
As gasoline evaporates in the f uel
tank, an evaporative emissions
control canister f illed with charcoal
adsorbs the vapor. It is stored in this
canister while the engine is of f . Af ter
the engine is started and warmed up,
the vapor is drawn into the engine
and burned during driving.
The onboard ref ueling vapor
recovery (ORVR) system captures
the f uel vapors during ref ueling. The
vapors are adsorbed in a canister
f illed with activated carbon. While
driving, the f uel vapors are drawn
into the engine and burned of f .
Emissions Cont rols
The Clean Air Act
Crankcase Emissions Control
System
Evaporative Emissions Control
System
Onboard Ref ueling Vapor
Recovery
272
——y

y
(yy

The exhaust emissions controls
include f our systems: PGM-FI,
ignition timing control, exhaust gas
recirculation, and three way catalytic
converter. These f our systems work
together to control the engine’s
combustion and minimize the
amount of HC, CO, and NOx that
comes out the tailpipe. The exhaust
emissions control systems are
separate f rom the crankcase and
evaporative emissions control
systems.
The PGM-FI system uses sequential
multiport f uel injection. It has three
subsystems: air intake, engine
control, and f uel control. The
powertrain control module (PCM) in
automatic transmission vehicles or
the engine control module (ECM) in
manual transmission vehicles uses
various sensors to determine how
much air is going into the engine. Itthen controls how much f uel to inject
under all operating conditions. The emissions control systems are
designed and certif ied to work to-
gether in reducing emissions to
levels that comply with the Clean Air
Act. To make sure the emissions
remain low, you should use only new
Honda replacement parts or their
equivalent f or repairs. Using lower
qualitypartsmayincreasethe
emissions f rom your vehicle.
The emissions control systems are
covered by warranties separate f rom
the rest of your vehicle. Read your
warranty manual f or more inf orma-
tion.
The exhaust gas recirculation (EGR)
system takes some of the exhaust
gas and routes it back into the intake
manif old. Adding exhaust gas to the
air/f uel mixture reduces the amount
of NOx produced when the f uel is
burned.
This system constantly adjusts the
ignition timing, reducing the amount
of HC, CO, and NOx produced.
The three way catalytic converter is
in the exhaust system. Through
chemical reactions, it converts HC,
CO, and NOx in the engine’s exhaust
to carbon dioxide (CO ), nitrogen
(N ), and water vapor.
2
2
Emissions Cont rols
Exhaust Emissions Controls Replacement Parts
PGM-FI Syst em
Three Way Catalytic Converter
Exhaust Gas Recirculat ion (EGR)
Syst em
Ignit ion T iming Cont rol Syst em
T echnical Inf ormation
273
——y
y
(yy

The three way catalytic converter
contains precious metals that serve
as catalysts, promoting chemical
reactions to convert the exhaust
gasses without af f ecting the metals.
The catalytic converter is ref erred to
as a three-way catalyst, since it acts
on HC, CO, and NOx. A replacement
unit must be an original Honda part
or its equivalent.Always use unleaded gasoline.
Even a small amount of leaded
gasoline can contaminate the
catalyst metals, making the three
way catalytic converter inef f ective.Keep the engine tuned-up.
The three way catalytic converter
must operate at a high temperature
for the chemical reactions to take
place. It can set on f ire any
combustible materials that come
near it. Park your vehicle away from
high grass, dry leaves, or other
f lammables. A defective three way catalytic
converter contributes to air pollution,
and can impair your engine’s per-
f ormance. Follow these guidelines to
protect your vehicle’s three way
catalytic converter.
Have your vehicle diagnosed and
repaired if it is misf iring, back-
f iring, stalling, or otherwise not
running properly.
Three Way Catalytic Converter
274
4-cylinder models
6-cylinder models
THREE WAY CATALYTIC CONVERTER
THREE WAY CATALYTIC CONVERTERS
——y
y
(yy

Make sure the gas tank is nearly,
but not completely f ull (around
3/4).Without touching the accelerator
pedal, start the engine, and let it
idle f or 20 seconds.
If you take your vehicle f or a state
emissions test shortly af ter the
battery has been disconnected or
gone dead, it may not pass the test.
This is because of certain ‘‘readiness
codes’’ that must be set in the on-
board diagnostics f or the emissions
systems. These codes are erased
when the battery is disconnected,
and set again only after several days
of driving under a variety of
conditions. If the testing f acility determines that
the readiness codes are not set, you
will be requested to return at a later
date to complete the test. If you must
get the vehicle retested within the
next two or three days, you can
condition the vehicle f or retesting by
doing the f ollowing.
Keep the vehicle in Park
(automatic transmission) or
Neutral (manual transmission).
Increase the engine speed to 2,000
rpm,andholditthereuntilthe
temperature gauge rises to at least
1/4of thescale(about3minutes).
Make sure the vehicle has been
parked with the engine of f f or 6
hours or more.
Make sure the ambient
temperature is between 40° and
95°F.
CONT INUED
St at e Emissions T est ing
T esting of Readiness Codes
T echnical Inf ormation
275
——y
y
(yy

µµ
µ
( % ) $ % ."#)
This manual covers maintenance and recommended
procedures f or repair to engine and chassis components.
It is written f or the journeyman mechanic, but is simple
enough f or most mechanically-inclined owners to under-
stand.
This manual complements the service manual by
providing in-depth troubleshooting inf ormation f or each
electrical circuit in your vehicle.
This manual describes the procedures involved in the
replacement of damaged body parts.
Authorized Manuals
Service Manual:
Electrical T roubleshooting Manual:
Body Repair Manual:
282 NOTE: Dealers and Companies please provide dealer or company name,
and also the name of the person to whose attention the shipment should
be sent. For purchases outside U.S.A. please write to the address shown
below for a quotation.
P.O. BOX 07280·DETROIT, MICHIGAN 48207·1-800-782-4356
Customer Name Attention
Apartment Number
State & Zip Code
City
Daytime Telephone Number
Check or money order enclosed payable to Helm Inc U.S. funds only.
Do not send cash
Master
Card VISA Check here if your billing address is different
from the shipping address shown above.
Account Number Expiration: Mo. Yr.
CUSTOMER SIGNATURE DATE
Street Address No P.O. Box Number
()
These Publications cannot be returned for credit without receiving advance authorization within 14
days of delivery. On returns, a restocking fee may be applied against the original order.
——y

y
(yy

CONT INUED
....................................
Accessories . 162
ACCESSORY (Ignition Key
.......................................
Position) . 76
...............
Accessory Power Socket . 99
....................
Additives, Engine Oil . 204
...................................
Airbag (SRS) . 11
..........
Airbag System Components . 23
............................
Air Conditioning . 105
.........................................
Usage . 107
.......................
Air Pressure, Tires . 228
Anti-lock Brakes (ABS)
...............................
Indicator . 59, 180
...................................
Operation . 180
.
Anti-thef t Steering Column Lock . 78
........
Audio System . 114, 122, 131, 135
.............
Automatic Speed Control . 145
..............
Automatic Transmission . 173
..........................
Capacity, Fluid . 266
.......................................
Shif ting . 173
.
Shif t Lever Position Indicator . 173
................
Shif t Lever Positions . 173
....................
Shif t Lock Release . 176 ............................
Capacities Chart . 266
.............
Carbon Monoxide Hazard . 52
.............................
Carrying Cargo . 164
..............
CAUTION, Explanation of . ii
...................................
CD Changer . 128
.......................................
CD Player . 122
..........................
CD Pocket, Center . 99
........................
Certif ication Label . 264
............................................
Chains . 232
....................
Changing a Flat Tire . 239
Changing Oil
........................................
How to . 205
......................................
When to . 193
...
Charging System Indicator . 58, 251
............
Checklist, Bef ore Driving . 168
..................
Childproof Door Locks . 78
Battery
Charging System
...........................
Indicator . 58, 251
............................
Jump Starting . 245
..............................
Maintenance . 234
............................
Specif ications . 267
..............................
Bef ore Driving . 153
........................................
Belts, Seat . 10
Brakes
...........
Anti-lock System (ABS) . 180
.............
Break-in, New Linings . 154
...........................................
Fluid . 215
.........................................
Parking . 99
.........................
System Indicator . 59
........................
Wear Indicators . 179
.............................
Braking System . 179
........................
Break-in, New Car . 154
..
Brightness Control, Instruments . 72
........................
Brights, Headlights . 70
Bulb Replacement
..........................
Back-up Lights . 223
..............................
Brake Lights . 223
................
Front Parking Lights . 221
.................................
Headlights . 218 ............................
Specif ications . 267
............
Turn Signal Lights . 221, 222
..............................
Bulbs, Halogen . 218
Index
AB
C
INDEX
I
——y

y
(yy