2006 FORD F750 warning light

Before hook-up, make sure:
•The fifth wheel jaws are fully opened.
•The fifth wheel is fully tilted back to prevent body damage when the
tractor is backed under a trailer.
•The trailer wheels are blocked and the trailer spring brakes are
adjusted and applied. Never chase a trailer.
•The brake hoses and light cords are clear of the fifth wheel.
Hook-up
1. Back the tractor squarely under the trailer, engaging the fifth wheel
jaws on the kingpin. Always back-up slowly, making sure the trailer is
neither too high nor too low. Avoid backing under the trailer from an
angle.
2. Connect the service and emergency brake hoses and trailer light
connector. Refer toTractor-trailer connectionin this chapter, adhering
to the warning and using the three-point stance while connecting and
disconnecting the trailer.
3. Inspect the jaws of the fifth wheel to be sure they have fully closed on
the trailer kingpin and the trailer plate is resting securely on the fifth
wheel.
4. Be sure the coupler release lever is in the locked position.
5. Charge the trailer brake system. Set the trailer brakes, either with the
hand valve or tractor protection valve. Pull against the trailer for an
additional check of proper hook-up. Do not pull hard enough to damage
or strain the equipment.
6. Set the tractor parking brakes and fully raise the trailer landing gear.
Refer toBrakesin this chapter for proper operation of the parking brake
and trailer brakes.
7. Check the operation of all trailer lights and correct any lights that may
be faulty.
2006 F-650/750(f67)
Supplement
USA(fus)
Driving
141

FUEL FILTER/WATER SEPARATOR
Do not drain water separator while engine is running. Fuel may
ignite if separator is drained while engine is running or vehicle is
moving.
The fuel filter/water separator removes any contaminated particles
and/or water from the fuel before the fuel enters the engine.
The fuel filter/water separator should be drained as recommended in the
Scheduled Maintenance Guidechapter.
DRAINING THE FUEL FILTER/WATER SEPARATOR – 6.0L POWER
STROKE ENGINE
Water should be drained whenever
the warning light comes on or every
5,000 miles (8,000 km).
1. Stop the vehicle andshut offthe engine.
2. Locate the drain valve and place
a suitable container at the end of
the drain tube.
3. Turn the drain valve to the drain position and allow water to drain out.
Note:Drain until the water/fuel mixture becomes only fuel.
4. Turn the drain valve to the closed position.
5. Restart the engine and check WATER IN FUEL indicator light; it
should not be illuminated. If it continues to illuminate, have the fuel
system checked and repaired.
WATER
IN
FUEL
2006 F-650/750(f67)
Supplement
USA(fus)
Maintenance and Specifications
194

Tire sizeLoad
rangeApproved
rim widthsAxle capacity
Front - lb.
(kg)/psi
(kPa)Rear - lb.
(kg)/psi
(kPa)
295/80R22.5 H8.2514400 (6531) /
120 (827)27760 (12591)
/ 120 (827)
9.0014780 (6704) /
120 (827)27760 (12591)
/ 120 (827)
Tire inflation information
All tires with Steel Carcass Plies (if equipped):
This type of tire utilizes steel cords in the sidewalls. As such, they
cannot be treated like normal light truck tires. Tire service, including
adjusting the air pressure, must be performed by personnel trained,
supervised and equipped according to Federal Occupational Safety and
Health Administration (OSHA) regulations. For example, during any
procedure involving tire inflation, the technician or individual must
utilize a remote inflation device, and ensure that all persons are clear of
the trajectory area.
WARNINGAn inflated tire and rim can be very dangerous if
improperly used, serviced or maintained. To avoid serious injury,
never attempt to re-inflate a tire which has been run flat or seriously
under-inflated without first removing the tire from the wheel assembly
for inspection. Do not attempt to add air to tires or replace tires or
wheels without first taking precautions to protect persons and
property.
2006 F-650/750(f67)
Supplement
USA(fus)
Maintenance and Specifications
216

A
Air conditioning ..........................51
manual heating and air
conditioning system .................51
Air suspension ...........................119
Anti-lock brake system
(see Brakes) ..............................117
Audio system
(see Radio) ................33–34, 39, 44
Automatic transmission ............121
fluid, adding ............................192
fluid, checking ........................192
fluid, refill capacities ..............232
fluid, specification ..................218
Auxiliary power point .................59
Axle ............................132, 170, 207
lubricant specifications ..........218
refill capacities ........................231
B
Battery .......................................186
charging system warning
light ............................................23
jumping a disabled battery ....151
servicing ..................................264
voltage gauge ............................28
BeltMinder ...................................79
Brakes ..........................98, 104, 170
adjustment ..............................173
anti-lock ...........................117–118
anti-lock brake system (ABS)
warning light .....................23, 117
brake warning light ..................23
fluid, checking and adding ...173,
186
fluid, specifications .................218
parking ....................100, 106, 174
Bulbs ............................................55C
Catalytic converter
(see Emission control) .............174
CD-single premium .....................33
Cell phone use ..............................7
Child safety restraints ................83
child safety belts ......................83
Child safety seats ........................86
attaching with tether straps ....90
in front seat ..............................88
in rear seat ................................88
tether anchorage hardware .....90
Child safety seats - booster
seats .............................................84
Cleaning your vehicle
chrome and aluminum
parts .........................................164
engine compartment ..............164
exterior ....................................166
instrument panel ....................165
interior .....................................165
interior trim ............................165
plastic parts ............................164
washing ....................................163
waxing .....................................163
wheels ......................................164
Climate control (see Air
conditioning or Heating) ......50–51
Clutch ................................123, 190
adjusting ..................................191
fluid ..........................................190
operation while driving ..........123
specifications ..........................218
Controls
power seat .................................71
Coolant ......................................181
checking and adding ..............181
refill capacities ........................232
2006 F-650/750(f67)
Supplement
USA(fus)
Index
267

Headlamps ...................................53
aiming ........................................54
daytime running lights .............53
high beam .................................53
warning chime ..........................23
Heating ..................................50–51
heater only system ...................50
manual heating and air
conditioning system .................51
Hood ..........................................175
I
Ignition .........................................91
chime .........................................23
Infant seats (see Safety seats) ..86
Instrument panel
cleaning ...................................165
lighting up panel and
interior .......................................54
J
Jump-starting your vehicle ......151
K
Keys
key in ignition chime ...............23
positions of the ignition ...........91
L
Lamps
bulb replacement
specifications chart ..................55
cargo lamps ...............................54
daytime running light ...............53
headlamps .................................53
high beams ................................53instrument panel, dimming .....54
interior lamps ...........................55
replacing bulbs ...................55–57
Lane change indicator
(see Turn signal) ........................54
Lights, warning and indicator ....23
air suspension ...........................23
anti-lock brakes (ABS) ....23, 117
brake ..........................................23
charging system ........................23
safety belt .................................23
service engine soon ..................23
traction control off ...................23
turn signal indicator .................23
Lubricant specifications ...........218
M
Manual transmission .................125
lubricant specifications ..........218
Mirrors .........................................61
fold away ...................................63
heated ........................................62
side view mirrors (power) .......61
O
Odometer .....................................28
P
Paint chips, repairing ...............163
Parking brake ....................100, 106
warning light .............................23
Power door locks ........................67
Power mirrors .............................61
Power point .................................59
Power steering ..........................189
fluid, checking and adding ....189
2006 F-650/750(f67)
Supplement
USA(fus)
Index
269

fluid, refill capacity ................232
fluid, specifications .................218
Power Take-Off (PTO)
operation .................................131
Power Windows ...........................59
R
Radio ..........................33–34, 39, 44
Relays ........................................145
Remote entry system
locking/unlocking doors ...........67
Roadside assistance ..................143
S
Safety belts
(see Safety restraints) .........74–76
Safety defects, reporting ..........162
Safety restraints ....................74–76
belt minder ...............................79
cleaning the safety belts ..........82
extension assembly ..................82
for adults .............................75–76
for children ...............................83
lap belt ......................................77
warning light and chime ....23, 78
Safety seats for children ............86
Scheduled Maintenance
Guide .........................................235
Coolant Change Record .........265
General Maintenance
Information .............................235
Seat belts
(see Safety restraints) ...............74
Seats ............................................68
child safety seats ......................86heated ........................................73
Special notice ................................6
Specification chart,
lubricants ...................................218
Speed control ..............................63
Speedometer ...............................28
Starting your vehicle ..................91
jump starting ..........................151
preparing to start your
vehicle .......................................91
Steering .....................................188
Steering wheel
controls ................................58, 63
tilting .........................................58
Suspension ........................119, 204
T
Tachometer .................................28
Temperature control
(see Climate control) ...........50–51
Tires
checking the pressure ............214
Towing
wrecker ....................................155
Traction control
off light ......................................23
Transmission .....................121, 125
automatic operation ...............121
fluid, checking and adding
(automatic) .............................192
fluid, checking and adding
(manual) .................................193
fluid, refill capacities ..............232
lubricant specifications ..........218
manual operation ....................125
Turn signal ..................................54
2006 F-650/750(f67)
Supplement
USA(fus)
Index
270

V
Vehicle loading ..................136–137
Voltmeter (see Battery voltage
gauge) ..........................................28
W
Warning chimes ...........................23
Warning lights (see Lights) .......23
Warranty coverage ........................6
Washer fluid ..............................185
Washing your vehicle ................163
Water, Driving through ...............96Waxing your vehicle .................163
Wheels
.......................................208
Windows
power
.........................................59
Windshield
defrosting
............................50–51
Windshield washer fluid and
wipers
..........................................58
checking and cleaning
............165
operation
...................................58
replacing wiper blades
...........185
Wrecker towing
.........................155
2006 F-650/750(f67)
Supplement
USA(fus)
Index
271