2006 FORD F750 tow

WINDSHIELD WASHER FLUID
The reservoir capacity is 4.0 quarts
(3.8L); use windshield washer fluid
that meets the Ford specification
listed. Refer toLubricant
specificationsin this chapter.
Inspect the fluid level in the washer
reservoir when insufficient fluid is
sprayed.
State or local regulations on volatile
organic compounds may restrict the
use of methanol, a common windshield washer antifreeze additive.
Washer fluids containing non-methanol antifreeze agents should be used
only if they provide cold weather protection without damaging the
vehicle’s paint finish, wiper blades or washer system.
Do not put engine coolant in the washer fluid reservoir. Engine
coolant can severely reduce visibility if sprayed on the
windshield.
CHANGING THE WIPER BLADES
To replace the wiper blades:
1. Pull the wiper arm away from the
windshield and lock into the service
position.
2. Turn the blade at an angle from
the wiper arm. Push the lock pin
manually to release the blade and
pull the wiper blade down toward
the windshield to remove it from the
arm.
3. Attach the new wiper to the
wiper arm and press it into place
until a click is heard.
2006 F-650/750(f67)
Supplement
USA(fus)
Maintenance and Specifications
185

FRAME AND TOW HOOKS
Your vehicles chassis is manufactured with frame rails of either HSLA
steel or heat-treated steel. Each must be handled in a specific manner to
ensure maximum service life. Before attempting frame repair or
modification, consult the service manual or your dealer.
It is important, particularly on vehicles where the tow hooks are used
frequently to inspect the front and rear tow hooks for damage or a loose
mounting.
U-BOLT NUT TORQUE
U-bolt diameter (nominal) (all
spring suspensions)U-bolt diameter (nominal)
Ft. lb. N•m
IROS Air w/15,500 lb. axles and
less260–300 353–407
IROS Air w/greater than 15,500 lb.
axles370–400 502–542
Hendrickson 23,000 lb. axle 370–400 502–542
Air suspension U-bolt checks and re-torquing procedures
1. Inspect the threads of the U-bolt and nut for rust and debris. Clean
the threads if contaminated.
2. Using a torque wrench, determine if any nuts can be turned with a
force below the specified torque.
3. Using the lowest discovered torqued nut as a starting point, retighten
the nuts using the sequence listed underAir suspension U-bolt and
U-bolt nut installation.
Air suspension U-bolt and U-bolt nut installation
1. Inspect the threads of the U-bolt and nut for rust and debris. Clean
the threads if contaminated.
2. Install the U-bolts and nuts and torque the nuts to 15 ft. lb. (20 N•m),
using a diagonal pattern.
3. Re-torque the nuts to 100 ft. lb. (136 N•m), using a diagonal pattern.
4. Re-torque the nuts to 200 ft. lb. (271 N•m), using a diagonal pattern.
5. Re-torque the nuts to 400 ft. lb. (542 N•m), using a diagonal pattern.
(For vehicles equipped with 14ACC, 14 ADN and 14ADP axles, do not
use Step 6.)
2006 F-650/750(f67)
Supplement
USA(fus)
Maintenance and Specifications
206

fluid, refill capacity ................232
fluid, specifications .................218
Power Take-Off (PTO)
operation .................................131
Power Windows ...........................59
R
Radio ..........................33–34, 39, 44
Relays ........................................145
Remote entry system
locking/unlocking doors ...........67
Roadside assistance ..................143
S
Safety belts
(see Safety restraints) .........74–76
Safety defects, reporting ..........162
Safety restraints ....................74–76
belt minder ...............................79
cleaning the safety belts ..........82
extension assembly ..................82
for adults .............................75–76
for children ...............................83
lap belt ......................................77
warning light and chime ....23, 78
Safety seats for children ............86
Scheduled Maintenance
Guide .........................................235
Coolant Change Record .........265
General Maintenance
Information .............................235
Seat belts
(see Safety restraints) ...............74
Seats ............................................68
child safety seats ......................86heated ........................................73
Special notice ................................6
Specification chart,
lubricants ...................................218
Speed control ..............................63
Speedometer ...............................28
Starting your vehicle ..................91
jump starting ..........................151
preparing to start your
vehicle .......................................91
Steering .....................................188
Steering wheel
controls ................................58, 63
tilting .........................................58
Suspension ........................119, 204
T
Tachometer .................................28
Temperature control
(see Climate control) ...........50–51
Tires
checking the pressure ............214
Towing
wrecker ....................................155
Traction control
off light ......................................23
Transmission .....................121, 125
automatic operation ...............121
fluid, checking and adding
(automatic) .............................192
fluid, checking and adding
(manual) .................................193
fluid, refill capacities ..............232
lubricant specifications ..........218
manual operation ....................125
Turn signal ..................................54
2006 F-650/750(f67)
Supplement
USA(fus)
Index
270

V
Vehicle loading ..................136–137
Voltmeter (see Battery voltage
gauge) ..........................................28
W
Warning chimes ...........................23
Warning lights (see Lights) .......23
Warranty coverage ........................6
Washer fluid ..............................185
Washing your vehicle ................163
Water, Driving through ...............96Waxing your vehicle .................163
Wheels
.......................................208
Windows
power
.........................................59
Windshield
defrosting
............................50–51
Windshield washer fluid and
wipers
..........................................58
checking and cleaning
............165
operation
...................................58
replacing wiper blades
...........185
Wrecker towing
.........................155
2006 F-650/750(f67)
Supplement
USA(fus)
Index
271