2006 FORD F150 brake

BRAKE FLUID
The fluid level will drop slowly as
the brakes wear, and will rise when
the brake components are replaced.
Fluid levels between the “MIN” and
“MAX” lines are within the normal
operating range; there is no need to
add fluid. If the fluid levels are
outside of the normal operating
range the performance of your
brake system could be
compromised; seek service from
your authorized dealer immediately.
CLUTCH FLUID (IF EQUIPPED)
Check the fluid level. Refer toscheduled maintenance informationfor
the service interval schedules.
During normal operation, the fluid level in the clutch reservoir should
remain constant. If the fluid level drops, refill the fluid level to the step
in the reservoir.
Use only a DOT 3 brake fluid designed to meet Ford specification
ESA-M6C25–A. Refer toLubricant specificationsin this chapter.
Brake fluid is toxic. If brake fluid contacts the eyes, flush eyes
with running water for 15 minutes. Seek medical attention if
irritation persists. If taken internally, drink water and induce vomiting.
Seek medical attention immediately.
2006 F-150(f12)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
304

1. Clean the reservoir cap before
removal to prevent dirt and water
from entering the reservoir.
2. Remove cap and rubber
diaphragm from reservoir.
3. Add fluid until the level reaches
the step in the reservoir.
4. Reinstall rubber diaphragm and
cap onto reservoir.
TRANSMISSION FLUID
Checking automatic transmission fluid (if equipped)
Refer to yourscheduled maintenance informationfor scheduled
intervals for fluid checks and changes. Your transmission does not
consume fluid. However, the fluid level should be checked if the
transmission is not working properly, i.e., if the transmission slips or
shifts slowly or if you notice some sign of fluid leakage.
Automatic transmission fluid expands when warmed. To obtain an
accurate fluid check, drive the vehicle until it is at normal operating
temperature (approximately 20 miles [30 km]). If your vehicle has been
operated for an extended period at high speeds, in city traffic during hot
weather or pulling a trailer, the vehicle should be turned off for about
30 minutes to allow fluid to cool before checking.
1. Drive the vehicle 20 miles (30 km) or until it reaches normal operating
temperature.
2. Park the vehicle on a level surface and engage the parking brake.
3. With the parking brake engaged and your foot on the brake pedal,
start the engine and move the gearshift lever through all of the gear
ranges. Allow sufficient time for each gear to engage.
2006 F-150(f12)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
305

REFILL CAPACITIES
Fluid Ford Part
NameApplication Capacity
Brake fluid
and clutch
fluidMotorcraft
High
Performance
DOT 3
Motor
Vehicle
Brake FluidAll Fill to line or step
(for clutch) on
reservoir
Engine
coolant
1Motorcraft
Premium
Gold Engine
Coolant
(yellow-
colored)4.2L V6 engine 17.6 quarts (16.7L)
4.6L V8 engine 20.5 quarts (19.4L)
5.4L V8 engine 20.9 quarts (19.8L)
Engine oil
(includes
filter
change)
8
Motorcraft
SAE 5W-20
Premium
Synthetic
Blend Motor
Oil (US)
Motorcraft
SAE 5W-20
Super
Premium
Motor Oil
(Canada)4.2L engine 6.0 quarts (5.7L)
4.6L engine 6.0 quarts (5.7L)
5.4L engine 7.0 quarts (6.6L)
2006 F-150(f12)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
313

ItemFord part
name or
equivalentFord part
numberFord
specification
Brake fluid and
clutch fluidMotorcraft High
Performance
DOT 3 Motor
Vehicle Brake
FluidPM-1 ESA-M6C25-A
Engine coolantMotorcraft
Premium Gold
Engine Coolant
(yellow-colored)VC-7–A (except
CA, OR and
NM), VC-7-B
( CA, OR and
NM)WSS-
M97B51-A1
Engine oilMotorcraft SAE
5W-20 Premium
Synthetic Blend
Motor Oil (US)
Motorcraft SAE
5W-20 Super
Premium Motor
Oil (Canada)XO-5W20-QSP
(US)
CXO-5W20–LSP12
(Canada)
WSS-M2C930-A
and API
Certification
Mark
Seat tracksMulti-Purpose
GreaseXG-4 or XL-5 ESB-M1C93-B
Hinges, latches,
striker plates,
fuel filler door
hinge and door
check armMotorcraft
Silicone Brake
Caliper Grease
and Dielectric
CompoundXG-3-A ESE-M1C171–A
Lock cylindersMotorcraft
Penetrating and
Lock LubricantXL-1 none
2006 F-150(f12)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
317

ItemFord part
name or
equivalentFord part
numberFord
specification
Transmission
/steering/parking
brake linkages
and pivots,
brake and clutch
pedal shaft (if
equipped)Premium
Long-Life Grease
XG-1-C ESA-M1C75-B
Power steering
fluid, transfer
case fluid (4X4)
and manual
transmission
fluidMotorcraft
MERCONAT F
XT-2-QDX MERCON
Automatic
transmission
(4R70E and
4R75E)
2
Motorcraft
MERCONV
AT FXT-5-QM MERCONV
Windshield
washer fluidMotorcraft
Premium
Windshield
Washer
ConcentrateZC-32–A WSB-M8B16–A2
1Use Additive Friction Modifier XL-3 or equivalent for complete refill of
Traction-Lok axles.
2Ensure the correct automatic transmission fluid is used. Transmission
fluid requirements are indicated on the dipstick or on the dipstick
handle. Check the container to verify the fluid being added is of the
correct type. Refer to yourscheduled maintenance informationto
determine the correct service interval.
Some transmission fluids may be labeled as dual usage, such as
MERCONand MERCONV. These dual usage fluids are not to be used
in an automatic transmission that requires use of the MERCONtype
fluid.
2006 F-150(f12)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
318

The Vehicle Identification Number (VIN) contains the following
information:
1. World manufacturer identifier
2. Brake type and Gross Vehicle
Weight Rating (GVWR)
3. Vehicle line, series, body type
4. Engine type
5. Check digit
6. Model year
7. Assembly plant
8. Production sequence number
TRANSMISSION/TRANSAXLE CODE DESIGNATIONS
You can find a
transmission/transaxle code on the
Safety Compliance Certification
Label. The following table tells you
which transmission or transaxle
each code represents.
Description Code
Four-speed automatic (4R70E) A
Four-speed automatic (4R75E) Q
Five-speed manual (M5R2) M
2006 F-150(f12)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
325

A
Accessory delay ..........................71
Air cleaner filter ...............310, 312
Air conditioning ....................46, 49
Airbag supplemental
restraint system ................136–137
and child safety seats ............139
description ..............................137
disposal ....................................141
driver airbag ....................137, 140
indicator light .........................141
operation .........................137, 140
passenger airbag .............137, 140
Ambulance packages ....................8
Antifreeze
(see Engine coolant) ................286
Anti-lock brake system
(see Brakes) ..............................205
Armrests ....................................113
Audio system
(see Radio) ................22, 24, 28, 33
Automatic transmission
driving an automatic
overdrive .................................212
fluid, adding ............................305
fluid, checking ........................305
fluid, refill capacities ..............313
fluid, specification ..................319
Axle
lubricant specifications ..316, 319
refill capacities ........................313
traction lok ..............................209
B
Battery .......................................284
acid, treating emergencies .....284
jumping a disabled battery ....251maintenance-free ....................284
replacement, specifications ...312
servicing ..................................284
Bed extender ..............................94
Brakes ........................................205
anti-lock ...................................205
anti-lock brake system
(ABS) warning light ...............206
fluid, checking and adding ....304
fluid, refill capacities ..............313
fluid, specifications .........316, 319
lubricant
specifications ..................316, 319
parking ....................................206
shift interlock ..................209–210
Bulbs ............................................59
C
Capacities for refilling fluids ....313
Cell phone use ..............................9
Changing a tire .........................244
Child safety restraints ..............146
child safety belts ....................146
Child safety seats ......................150
attaching with tether straps ..158
in front seat ....................151, 154
in rear seat ..............151, 154, 158
Cleaning your vehicle
engine compartment ..............265
instrument panel ....................268
interior .....................................269
interior trim ............................269
plastic parts ............................267
safety belts ..............................269
washing ....................................264
waxing .....................................264
wheels ......................................265
wiper blades ............................267
2006 F-150(f12)
Owners Guide (post-2002-fmt)
USA(fus)
Index
329

Inspection/maintenance
(I/M) testing ..............................302
Instrument panel
cleaning ...................................268
cluster ........................................12
lighting up panel and
interior .......................................55
J
Jack ............................................244
positioning ...............................244
storage .....................................244
Jump-starting your vehicle ......251
K
Keyless entry system ...............106
autolock ...................................104
programming entry code .......107
Keys ...........................................109
positions of the ignition .........201
L
Lamps
autolamp system .......................53
bulb replacement
specifications chart ..................59
daytime running light ...............54
fog lamps ...................................55
headlamps .................................53
headlamps, flash to pass ..........54
instrument panel, dimming .....55
interior lamps .....................57–58
replacing bulbs ...................60, 63
Lane change indicator
(see Turn signal) ........................57
Lights, warning and indicator ....12
anti-lock brakes (ABS) ..........206
Load limits .................................180Loading instructions .................187
Locks
autolock ...................................104
childproof ..................................97
Lubricant specifications ...316, 319
Lug nuts ....................................250
Lumbar support, seats .............113
M
Manual transmission .................215
reverse .....................................217
Message center ...........................84
english/metric button ...............89
system check button ................88
warning messages .....................90
Mirrors ...................................65, 72
automatic dimming
rearview mirror .........................71
fold away ...................................72
heated ........................................73
programmable memory ....99, 115
side view mirrors (power) .......72
signal .........................................73
Moon roof ....................................77
Motorcraft parts ........272, 292, 312
O
Octane rating ............................296
Oil (see Engine oil) ..................280
P
Parking brake ............................206
Parts (see Motorcraft parts) ....312
Passenger Occupant
Classification Sensor .................118
2006 F-150(f12)
Owners Guide (post-2002-fmt)
USA(fus)
Index
332