2006 FORD F150 instrument panel

The fuses are coded as follows.
Fuse/Relay
LocationFuse Amp
RatingPassenger Compartment Fuse
Panel Description
1 10A* Run/Accessory - Wipers,
Instrument cluster, Audio for
XL/STX
2 20A* Stop/Turn lamps, Brake on/off
switch
3 7.5A* Power mirrors, Memory seats and
pedals
4 10A* DVD battery power, Power fold
mirror
5 7.5A* Keep alive memory for Powertrain
Control Module (PCM) and
climate control module
6 15A* Parklamps, BSM, Instrument
panel illumination
7 5A* Radio (start signal)
8 10A* Heated mirrors, Switch indicator
2006 F-150(f12)
Owners Guide (post-2002-fmt)
USA(fus)
Roadside Emergencies
239

Fuse/Relay
LocationFuse Amp
RatingPassenger Compartment Fuse
Panel Description
25 10A* LH low beam headlamp
26 20A* Horn relay (PCB3), Horn power
27 5A* Passenger Air bag Deactivation
(PAD) warning lamp, Cluster air
bag warning lamp, Cluster RUN
/START power
28 5A* SecuriLock transceiver (PATS),
PCM IGN monitor
29 15A* PCM 4x4 power
30 15A* PCM 4x4 power
31 20A* Radio power
32 15A* Vapor Management Valve (VMV),
A/C clutch relay, Canister vent,
Heated Exhaust Gas Oxygen
(HEGO) sensors #11 and #21,
CMCV, Mass Air Flow (MAF)
sensor, VCT, Heated Positive
Crankcase Ventilation (PCV) valve
(4.2L engine), CID sensor (4.2L
engine), 4.6L/4.2L EGR
33 15A* Shift solenoid, CMS #12 and #22,
Ignition coils
34 15A* PCM power
35 20A* Instrument cluster high beam
indicator, High beam headlamps
36 10A* Trailer tow right turn/stop lamps
37 20A* Rear power point
38 25A* Subwoofer power
39 20A* Instrument panel power point
40 20A* Low beam headlamps, DRL
41 20A* Cigar lighter, Diagnostic connector
power
42 10A* Trailer tow left turn/stop lamps
101 30A** Starter solenoid
2006 F-150(f12)
Owners Guide (post-2002-fmt)
USA(fus)
Roadside Emergencies
241

available from your authorized dealer. This washer fluid contains
special solution in addition to alcohol which helps to remove the hot
wax deposited on the wiper blade and windshield from automated car
wash facilities. Be sure to replace wiper blades when they appear
worn or do not function properly.
•Do not use abrasives, as they may cause scratches.
•Do not use fuel, kerosene, or paint thinner to clean any parts.
Do not use sharp objects, such as a razor blade, to clean the
inside of the rear window or to remove decals, as it may cause
damage to the rear window defroster’s heated grid lines (if
equipped).
INSTRUMENT PANEL
Clean the instrument panel with a damp cloth, then with a clean, dry
cloth, or use Motorcraft Dash & Vinyl Cleaner (ZC-38-A).
•Avoid cleaners or polish that increase the gloss of the upper portion of
the instrument panel. The dull finish in this area helps protect the
driver from undesirable windshield reflection.
Do not use chemical solvents or strong detergents when cleaning
the steering wheel or instrument panel to avoid contamination of
the airbag system.
•Be certain to wash or wipe your hands clean if you have been in
contact with certain products such as insect repellent and suntan
lotion in order to avoid possible damage to the interior painted
surfaces.
INSTRUMENT PANEL AND CONSOLE
(HARLEY-DAVIDSON F150 ONLY)
Your Harley-Davidson F150 instrument panel and console is uniquely
painted with both high and low gloss paints that require special care.
The high gloss area is similar to that of the vehicle’s exterior; the low
gloss area is designed to help protect the driver from undesirable
windshield reflection.
High gloss paint area
In order to maintain the finish of the instrument panel and console, the
high gloss areas should be treated similar to the that of exterior paint or
glossy plastic surfaces. When cleaning the high gloss areas:
•Do not usepaper towels or newspaper.
2006 F-150(f12)
Owners Guide (post-2002-fmt)
USA(fus)
Cleaning
268

•Do not usesilicone or Teflon-based products.
Dust the high gloss areas with a clean, dry cloth, or use Motorcraft
Dusting Cloth (ZC-24 or ZC-25) or Motorcraft Dusting Cloth Mitts
(ZC-47).
For general cleaning, use mild, soapy water and a soft, damp cloth, then
dry with a clean, dry cloth, or use or use Motorcraft Dash & Vinyl
Cleaner (ZC-38-A) or Motorcraft Ultra-Clear Spray Glass Cleaner
(ZC-23).
For removal of fine scuffs and scratches, use Scotch-BriteMicrofiber
Cloth or cheese cloth along with Motorcraft Premium Liquid Wax
(ZC-53-A), Motorcraft Paint Sealant (ZC-45), or Motorcraft Custom Clear
Coat Polish (ZC-8-A).Note:Removal of deep scuffs and scratches
should be performed by an authorized dealer or an experienced repair
facility.
Low gloss paint area
The low gloss area of the instrument panel’s upper dash should be
cleaned with mild, soapy water and a soft, damp cloth, or Motorcraft
Dash & Vinyl Cleaner (ZC-38-A), then dried with a clean, dry cloth.
When cleaning the low gloss areas:
•Do not usepaper towels or newspaper.
•Do not usesilicone or Teflon-based products.
•Do not useexterior paint waxes or sealants.
Dust the low gloss areas with a clean, dry cloth, or use Motorcraft
Dusting Cloth (ZC-24 or ZC-25) or Motorcraft Dusting Cloth Mitts
(ZC-47).
INTERIOR TRIM
•Clean the interior trim areas with a damp cloth, then with a clean, dry
cloth; you may also use Motorcraft Dash & Vinyl Cleaner (ZC-38-A).
•Do not use household or glass cleaners as these may damage the
finish.
INTERIOR
For fabric, carpets, cloth seats and safety belts:
•Remove dust and loose dirt with a vacuum cleaner.
•Remove light stains and soil with Motorcraft Professional Strength
Carpet & Upholstery Cleaner (ZC-54).
•If grease or tar is present on the material, spot-clean the area first
with Motorcraft Spot and Stain Remover (ZC-14).
2006 F-150(f12)
Owners Guide (post-2002-fmt)
USA(fus)
Cleaning
269

2. Block the wheels.
•Manual transmission:
1. Set the parking brake, depress the clutch and place the gearshift in N
(Neutral).
2. Block the wheels.
Note:Do not start your engine with the air cleaner removed and do not
remove it while the engine is running.
OPENING THE HOOD
1. Inside the vehicle, pull the hood
release handle located under the
bottom of the instrument panel.
2. Go to the front of the vehicle and release the auxiliary latch that is
located on the front bumper under the grill.
3. Lift the hood until the lift cylinders hold it open.
2006 F-150(f12)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
275

IDENTIFYING YOUR VEHICLE
Safety Compliance Certification Label
The National Highway Traffic Safety
Administration Regulations require
that a Safety Compliance
Certification Label be affixed to a
vehicle and prescribe where the
Safety Compliance Certification
Label may be located. The Safety
Compliance Certification Label is
located on the structure by the
trailing edge of the driver’s door or
the edge of the driver’s door.
Vehicle identification number (VIN)
The vehicle identification number is
attached to a metal tag and is
located on the driver side
instrument panel.
Please note that in the graphic,
XXXX is representative of your
vehicle identification number.
XXXXXXXXXXXXXXXXX
2006 F-150(f12)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
324

A
Accessory delay ..........................71
Air cleaner filter ...............310, 312
Air conditioning ....................46, 49
Airbag supplemental
restraint system ................136–137
and child safety seats ............139
description ..............................137
disposal ....................................141
driver airbag ....................137, 140
indicator light .........................141
operation .........................137, 140
passenger airbag .............137, 140
Ambulance packages ....................8
Antifreeze
(see Engine coolant) ................286
Anti-lock brake system
(see Brakes) ..............................205
Armrests ....................................113
Audio system
(see Radio) ................22, 24, 28, 33
Automatic transmission
driving an automatic
overdrive .................................212
fluid, adding ............................305
fluid, checking ........................305
fluid, refill capacities ..............313
fluid, specification ..................319
Axle
lubricant specifications ..316, 319
refill capacities ........................313
traction lok ..............................209
B
Battery .......................................284
acid, treating emergencies .....284
jumping a disabled battery ....251maintenance-free ....................284
replacement, specifications ...312
servicing ..................................284
Bed extender ..............................94
Brakes ........................................205
anti-lock ...................................205
anti-lock brake system
(ABS) warning light ...............206
fluid, checking and adding ....304
fluid, refill capacities ..............313
fluid, specifications .........316, 319
lubricant
specifications ..................316, 319
parking ....................................206
shift interlock ..................209–210
Bulbs ............................................59
C
Capacities for refilling fluids ....313
Cell phone use ..............................9
Changing a tire .........................244
Child safety restraints ..............146
child safety belts ....................146
Child safety seats ......................150
attaching with tether straps ..158
in front seat ....................151, 154
in rear seat ..............151, 154, 158
Cleaning your vehicle
engine compartment ..............265
instrument panel ....................268
interior .....................................269
interior trim ............................269
plastic parts ............................267
safety belts ..............................269
washing ....................................264
waxing .....................................264
wheels ......................................265
wiper blades ............................267
2006 F-150(f12)
Owners Guide (post-2002-fmt)
USA(fus)
Index
329

Inspection/maintenance
(I/M) testing ..............................302
Instrument panel
cleaning ...................................268
cluster ........................................12
lighting up panel and
interior .......................................55
J
Jack ............................................244
positioning ...............................244
storage .....................................244
Jump-starting your vehicle ......251
K
Keyless entry system ...............106
autolock ...................................104
programming entry code .......107
Keys ...........................................109
positions of the ignition .........201
L
Lamps
autolamp system .......................53
bulb replacement
specifications chart ..................59
daytime running light ...............54
fog lamps ...................................55
headlamps .................................53
headlamps, flash to pass ..........54
instrument panel, dimming .....55
interior lamps .....................57–58
replacing bulbs ...................60, 63
Lane change indicator
(see Turn signal) ........................57
Lights, warning and indicator ....12
anti-lock brakes (ABS) ..........206
Load limits .................................180Loading instructions .................187
Locks
autolock ...................................104
childproof ..................................97
Lubricant specifications ...316, 319
Lug nuts ....................................250
Lumbar support, seats .............113
M
Manual transmission .................215
reverse .....................................217
Message center ...........................84
english/metric button ...............89
system check button ................88
warning messages .....................90
Mirrors ...................................65, 72
automatic dimming
rearview mirror .........................71
fold away ...................................72
heated ........................................73
programmable memory ....99, 115
side view mirrors (power) .......72
signal .........................................73
Moon roof ....................................77
Motorcraft parts ........272, 292, 312
O
Octane rating ............................296
Oil (see Engine oil) ..................280
P
Parking brake ............................206
Parts (see Motorcraft parts) ....312
Passenger Occupant
Classification Sensor .................118
2006 F-150(f12)
Owners Guide (post-2002-fmt)
USA(fus)
Index
332