2006 FIAT STILO spare wheel

176
WARNING
LIGHTS AND
MESSAGES
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
IINDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
Versions with alloy rims
Proceed as follows:
❒Tighten the pin A-fig. 10in one of the
fastening bolt holes on the wheel hub;
❒Insert the wheel on the pin and, using
the wrench provided, tighten the four
bolts available. This is facilitated by the
extension provided B;
❒Loosen the pin Aand tighten the last
fastening bolt;
❒Lower the car and remove the jack;
❒Using the wrench provided, fully tight-
en the bolts in the sequence shown
previously for the space-saver spare
wheel (see fig. 9).When you have finished
❒Stow the space-saver spare wheel G-
fig. 11in the space provided in the
boot;
❒Insert the partially open jack into the
container Fand force it slightly into its
seat so that it does not vibrate when
the car is moving;
❒ Put the tools back into their places in
the container;
❒Stow the container complete with tools
on the spare wheel and secure every-
thing with the clamping device E;
❒Correctly reposition the boot stiff cov-
er.
fig. 10F0C0217m
fig. 11F0C0392m

213
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
ANNUAL INSPECTION
SCHEDULE
For cars with an annual mileage of below
30.000 km (for example about 15.000 km)
the following yearly inspection programme
is advised:
❒check tyre conditions/wear and adjust
pressure if required (including the
space-saver spare wheel);
❒check light system operation (head-
lights, direction indicators, hazard lights,
boot lights, passenger compartment
lights, glovebox light, warning lights,
etc.);
❒check windscreen wiper/washer oper-
ation, adjust nozzles;
❒check windscreen/rear window blade
position/wear;
❒ check front disk brake pad conditions
and wear;
❒sight inspect the conditions of: engine,
gearbox, transmission, pipes and hoses
(exhaust - fuel - brakes), rubber parts
(boots, sleeves, bushes, etc.) fuel and
brake system hoses;
❒check cleanness of bonnet and boot
locks, and lever cleanness and lubrica-
tion
❒check battery charge (by optical depth
gauge);
❒visual check on various drive belt con-
ditions;
❒check and top up fluid levels (engine
coolant, brakes, windscreen washer,
battery, etc.);
❒change engine oil and oil filter, if re-
quired (Multijet versions);
❒replace pollen filter.
ADDITIONAL CHECKS
Every 1,000 km or before long journeys,
check and top up if required:
❒engine coolant fluid level;
❒ brake fluid level;
❒ windscreen washer fluid level;
❒tyre pressure and conditions.
Every 3,000 km check and top up if re-
quired: engine oil level.
You are recommended to use FL Sele-
niaproducts, designed and produced
specifically for Fiat cars (see table “Ca-
pacities” in section “Technical specifica-
tions”).

229
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
WHEELS AND TYRES
Check the pressure of each tyre, includ-
ing the spare, every two weeks and before
long journeys. The pressure should be
checked with the tyre rested and cold.
For the correct tyre inflation pressure, see
“Wheels” in “Technical specifications”
section.
Incorrect pressure causes abnormal tyre
wearfig. 21:
A: normal pressure: tread evenly worn.
B: low pressure: tread particularly worn
at the edges.
C: high pressure: tread particularly worn
in the centre.
Tyres must be replaced when the tread
wears down to 1.6 mm. In any case, com-
ply with the laws in the country where the
car is being driven.IMPORTANT NOTES
❒As far as possible, avoid sharp braking
and screech starts, etc. Be careful not
to hit the kerb, potholes or other ob-
stacles hard. Driving for long stretch-
es over bumpy roads can damage the
tyres;
❒Periodically check that the tyres have
no cuts in the side wall, abnormal
swelling or irregular tyre wear. If any of
these occur, have the car seen to at a
Fiat Dealership;
❒avoid overloading the car when travel-
ling: this may cause serious damage to
the wheels and tyres;
fig. 21F0C0101m
❒if a tyre is punctured, stop immediate-
ly and charge it to avoid damage to the
tyre, the rim, suspensions and steering
system;
❒Tyres age even if they are not used
much. Cracks in the tread rubber are
a sign of ageing. In any case, if the tyres
have been on the car for over 6 years,
they should be checked by specialised
personnel, to see if they can still be
used. Also remember to check the
space-saver spare wheel;
❒ In the case of replacement, always fit
new tyres, avoiding those of dubious
origin;
❒ If a tyre is changed, also change the in-
flation valve;
❒To allow even wear between the front
and rear tyres, it is advisable to change
them over every 10-15 thousand kilo-
metres, keeping them on the same side
of the car so as to not reverse the di-
rection of rotation.

245
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
UNDERSTANDING TYRE
MARKING fig. 5
Example: 195/65 R 15 91T
195= Nominal width (S, distance be-
tween sidewalls in mm).
65= Percentage height/width ratio
(H/S).
R= Radial tyre.
15= Rim diameter in inches (Ø).
91= Load rating.
T= Maximum speed rating.
WHEELS
RIMS AND TYRES
Pressed steel or alloy rims. Tubeless tyres
with radial carcass. The homologated tyres
are listed in the Log book.
IMPORTANT In the event of discrepan-
cies between the information provided on
this “Owner handbook” and the “Log
book”, consider the specifications shown
in the log book only.
Attaining to the prescribed size, to ensure
safety of the car in movement, it must be
fitted with tyres of the same make and
type on all wheels.
IMPORTANT Do not use inner tubes
with Tubeless tyres.SPARE WHEEL
Pressed steel rim. Tubeless tyre.
WHEEL GEOMETRY
Front wheel toe-in measured from rim to
rim: – 1 ±1 mm.
The values refer to the car in running or-
der.
fig. 5F0C0200m

247
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
(*) On request for versions/markets where applicable.
VERSIONS RIMS TYRES SPARE WHEEL (*)Standard tyres Snow tyres Rim Tyre
1.416V61/2J x 15 ET 43 195/65 R15 91T 195/65 R15 91T (M+S)
7J x 16 ET 41 205/55 R16 91V (*) 205/55 R16 91H (M+S)
4B x 15 ET 35 T/125/90 R15 96M
7J x 17 ET 41 215/45 R17 87W (*) 215/45 R17 87H (M+S)
7J x 17 ET 41 215/45 ZR17 87W 215/45 ZR17 87H (M+S)
1.616V61/2J x 15 ET 43 195/65 R15 91H 195/65 R15 91H (M+S)
7J x 16 ET 41 205/55 R16 91V (*) 205/55 R16 91H (M+S) 4B x 15 ET 35 T/125/90 R15 96M
7J x 17 ET 41 215/45 R17 87W (*) 215/45 R17 87H (M+S)
1.816V61/2J x 15 ET 43 195/65 R15 91V 195/65 R15 91H (M+S)1.9 Multijet 16V7J x 16 ET 41 205/55 R16 91V (*) 205/55 R16 91H (M+S)
4B x 15 ET 35 T/125/90 R15 96M
7J x 17 ET 41 215/45 R17 87W (*) 215/45 R17 87H (M+S)
7J x 17 ET 41 215/45 ZR17 87W 215/45 ZR17 87H (M+S)
2.420V7J x 16 ET 41 205/55 R16 91W 205/55 R16 91H (M+S)
4B x 15 ET 35 T/125/90 R15 96M
7J x 17 ET 41 215/45 R17 87W (*) 215/45 R17 87H (M+S)
1.9 Multijet 8V61/2J x 15 ET 43 195/65 R15 91H 195/65 R15 91H (M+S)
7J x 16 ET 41 205/55 R16 91V (*) 205/55 R16 91H (M+S) 4B x 15 ET 35 T/125/90 R15 96M
7J x 17 ET 41 215/45 R17 87W (*) 215/45 R17 87H (M+S)

COLD TYRE INFLATION PRESSURE (bar)
Saloon versions
248
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
Add +0.3 bar to the prescribed inflation pressure when the tyres are warm. Recheck pressure value with cold tyres.
With snow tyres, add +0.2 bar to the inflation pressure value prescribed for standard tyres.
195/65 R15 91T 1.9 1.9 2.1 2.1
1.416V205/55 R16 91V 2.1 2.1 2.3 2.3 4.2
215/45 R17 87W 2.3 2.3 2.7 2.5
1.616V195/65 R15 91H 1.9 1.9 2.1 2.1
1.9 Multijet 8V205/55 R16 91V 2.1 2.1 2.3 2.3 4.2
215/45 R17 87W 2.3 2.3 2.7 2.5
195/65 R15 91V 1.9 1.9 2.1 2.1
1.816V205/55 R16 91V 2.1 2.1 2.3 2.3 4.21.9 Multijet16V215/45 R17 87W 2.3 2.3 2.7 2.5
2.420V205/55 R16 91W 2.1 2.1 2.3 2.3
4.2
215/45 R17 87W 2.3 2.3 2.7 2.5STANDARD TYRES SPACE-SAVER
Size Medium load Full load SPAREWHEEL
Front Rear Front Rear

249
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
Multi Wagon versions
Add +0.3 bar to the prescribed inflation pressure when the tyres are warm. Recheck pressure value with cold tyres.
With snow tyres, add +0.2 bar to the inflation pressure value prescribed for standard tyres.
(*) In full load conditions = 510 kg (including driver’s weight; special equipment and remaining load distributed on rear folded seats).
195/65 R15 91T 1.9 1.9 2.1 2.3/3.0 (*)
1.416V205/55 R16 91V 2.1 2.1 2.3 2.3/3.0 (*) 4.2
215/45 R17 87W 2.3 2.3 2.7 2.5/3.0 (*)
1.616V195/65 R15 91H 1.9 1.9 2.3 2.3/3.0 (*)
1.9 Multijet 8V205/55 R16 91V 2.1 2.1 2.3 2.3/3.0 (*) 4.2
215/45 R17 87W 2.3 2.3 2.7 2.5/3.0 (*)
195/65 R15 91V 1.9 1.9 2.3 2.3/3.0 (*)
1.816V205/55 R16 91V 2.1 2.1 2.3 2.3/3.0 (*) 4.21.9 Multijet16V215/45 R17 87W 2.3 2.3 2.7 2.5/3.0 (*)STANDARD TYRES SPACE-SAVER
Size Medium load Full load SPAREWHEEL
Front Rear Front Rear

ENGINE OIL CHANGE
1.416V - 1.616V- 1.816V- 2.420V- 1.9 Multijet 8V - 1.9 Multijet 16V
Tank capacity58
Reserve9
Only refuel cars with petrol engines with unleaded petrol with octane rating (RON) not less than 95.
Only refuel cars with diesel engines with diesel fuel for motor vehicles conforming to the EN590 European Specification.
REFUELLING (litres)
195/65 R15 91T
205/55 R16 91V
195/65 R15 91H (❒)
215/45 R17 87W
195/65 R15 91H
205/55 R16 91V
215/45 R17 87W
195/65 R15 91V
205/55 R16 91V
215/45 R17 87W
205/55 R16 91W
215/45 R17 87W1.9
2.1
1.9
2.3
1.9
2.1
2.3
1.9
2.1
2.3
2.1
2.31.9
2.1
1.9
2.3
1.9
2.1
2.3
1.9
2.1
2.3
2.1
2.32.1 - 2.3 (❒)/3.0 (**)
2.3
2.1 - 2.3 (❒)/3.0 (**)
2.7
2.1 - 2.3 (❒)/3.0 (**)
2.3
2.7
2.1 - 2.3 (❒)/3.0 (**)
2.3
2.7
2.3
2.72.1 - 2.3 (❒)/3.0 (**)
2.3
2.1 - 2.3 (❒)/3.0 (**)
2.5
2.1 - 2.3 (❒)/3.0 (**)
2.3
2.5
2.1 - 2.3 (❒)/3.0 (**)
2.3
2.5
2.3
2.54.2
4.2
4.2
4.2 1.4
16V
1.9 Multijet 8V1.616V
1.816V1.9 Multijet 16V
2.420V
VERSIONS STANDARD TYRES SPARE
Size Medium load Full load WHEEL
Front Rear Front Rear
Fiat Auto S.p.A.
Quality - Assistenza Tecnica - Ingegneria Assistenziale
Largo Senatore G. Agnelli, 5 - 10040 Volvera - Torino (Italia)
Print No. 603.81.012 - XI/2006 - 2
ndEdition
1.416V1.616V1.816V2.420V1.9 Multijet8V1.9 Multijet 16V
litres kg litres kg litres kg litres kg litres kg
Engine sump 2.5 2.2 4.3 3.9 3.7 3.3 4.5 3.9 4.4 3.8
Engine sump and filter 2.8 2.5 4.9 4.4 4.2 3.7 4.7 4.0 4.7 4.0
(❒) Multi Wagon Versions
(**) Under maximum load conditions = 510 kg (comprising driver’s weight. special equipment and the remaining load distributed over the rear pulled down seats).