2006 DODGE RAM 3500 DIESEL ECU

Towing Requirements
To promote proper break-in of your new vehicle driv-
etrain components the following guidelines are recom-
mended:
CAUTION!
•Avoid towing a trailer for the first 500 miles (805
km) of vehicle operation. Doing so may damage
your vehicle.
•During the first 500 miles (805 km) of trailer
towing, limit your speed to 50 mph (80 km/h).
Perform the maintenance listed in Section 8 of this
manual. When towing a trailer, never exceed the GAWR,
or GCWR, ratings.
WARNING!
Improper towing can lead to an injury accident.
Follow these guidelines to make your trailer towing
as safe as possible:
Make certain that the load is secured in the trailer
and will not shift during travel. When trailering
cargo that is not fully secured, dynamic load shifts
can occur that may be difficult for the driver to
control. You could lose control of your vehicle and
have an accident.
•When hauling cargo or towing a trailer, do not over-
load your vehicle or trailer. Overloading can cause a
loss of control, poor performance or damage to brakes,
axle, engine, transmission, steering, suspension, chas-
sis structure or tires.
328 STARTING AND OPERATING

Fan
Inspection
Check the fan for cracks and bent or broken blades. If any
of these conditions exist, you must replace the fan. Make
sure it is securely mounted.
NOTE:This service procedure must be performed by a
trained service technician. Make arrangements with your
authorized Dodge Truck Dealer for this inspection.
Charge Air Cooler (Inter-Cooler)
The charge air cooler is positioned between the radiator
and the air conditioner condenser. Air enters the engine
through the air cleaner and passes through the turbo-
charger where it is pressurized. This pressurized air
rapidly reaches high temperature. The air is then directed
through a hose to the charge air cooler and through
another hose to the intake manifold of the engine. The air
entering the engine has been cooled by about 50 to 100degrees Fahrenheit. This cooling process enables more
efficient burning of fuel resulting in fewer emissions.
To guarantee optimum performance of the system, keep
the surfaces of the charge air cooler, condenser and
radiator clean and free of debris. Periodically check the
hoses leading to and from the charge air cooler for cracks
or loose clamps resulting in loss of pressure and reduced
engine performance.
Hoses And Vacuum/Vapor Harnesses
Inspect surfaces of hoses and nylon tubing for evidence
of heat and mechanical damage. Hard or soft spots,
brittle rubber, cracking, tears, cuts, abrasions, and exces-
sive swelling indicate deterioration of the rubber.
Pay particular attention to those hoses nearest to high
heat sources such as the exhaust manifold. Inspect hose
routing to be sure hoses do not come in contact with any
heat source or moving component which may cause heat
damage or mechanical wear.
402 MAINTAINING YOUR VEHICLE

Insure nylon tubing in these areas has not melted or
collapsed.
Inspect all hose connections such as clamps and cou-
plings to make sure they are secure and no leaks are
present.
Components should be replaced immediately if there is
any evidence of wear or damage that could cause failure.
Brake System
Power Disc Brakes (Front and Rear)
Disc brakes do not require adjustment; however, several
hard stops during the break-in period are recommended
to seat the linings and wear off any foreign material.
Brake Master Cylinder
The fluid level of the master cylinder should be checked
when performing under the hood service, or immedi-
ately if the brake system warning lamp indicates system
failure.The brake master cylinder has a translucent plastic
reservoir. On the outboard side of the reservoir, there is a
“FULL” dot and an “ADD” dot. The fluid level must be
kept within these two dots. Do not add fluid above the
full mark because leakage may occur at the cap.
MAINTAINING YOUR VEHICLE 403
7

Air Cleaner, Engine (Engine Air Cleaner Filter) . 385,412
Air Conditioner Maintenance............... 391
Air Conditioning Refrigerant.............391,392
Air Conditioning System................234,391
Air Conditioning System, Zone Control........ 238
Air Filter.............................. 385
Air Pressure, Tires....................301,309
Airbag..............................43,49
Airbag Light.........................72,178
Airbag On/Off Switch..................... 49
Airbag, Side............................ 52
Alarm, Out of Park Sense.................. 271
Alarm (Security Alarm).................26,180
Alignment and Balance................... 308
Alterations/Modifications, Vehicle............. 7
Antenna, Satellite Radio................... 227
Antifreeze (Engine Coolant)................ 400
Capacities........................... 437
Anti-Lock Warning Light...............182,290Anti-Theft System.....................26,180
Appearance Care........................ 416
Ashtray............................... 152
Automatic Transmission................... 407
Adding Fluid......................... 407
Fluid and Filter Changes................. 408
Fluid Level Check...................... 407
Fluid Type........................408,439
Shift Indicator........................ 180
Shifting............................. 266
Special Additives...................... 409
Axle Fluid..........................406,439
Axle Lubrication (Axle Fluid)............... 406
Ball Joints............................. 393
Battery............................... 390
Blanket..........................261,391
Emergency Starting..................... 363
Saving Feature (Protection)............... 121
478 INDEX

Child............................... 68
Folding Floor......................... 162
Heated.............................. 117
Lumbar Support....................... 109
Power.............................. 110
Rear Folding....................... 112,114
Reclining............................ 108
Reclining Rear........................ 112
Security Alarm (Theft Alarm).............26,180
Selection of Coolant (Antifreeze)............. 438
Sentry Key (Immobilizer)................... 12
Service Assistance....................... 470
Service Contract......................... 472
Service Information...................... 376
Service Manuals........................ 474
Setting the Clock.............185,188,196,209,223
Shifting............................... 266
Automatic Transmission................. 266
Manual Transmission................... 272Transfer Case......................... 276
Transfer Case, Shifting into Transfer
Case Neutral (N)..................340,342
Transfer Case, Shifting out of Transfer
Case Neutral (N)..................341,344
Shoulder Belt Upper Anchorage.............. 38
Shoulder Belts........................... 31
Side Airbag............................. 52
Signals, Turn........................... 124
Sliding Rear Window
Power............................... 29
Snow Chains (Tire Chains)................. 309
Snow Plow............................ 335
Snow Tires............................ 311
Spare Tire..........................304,305
Speed Control (Cruise Control).............. 130
Speedometer........................... 178
Starting............................... 253
Engine Block Heater.................253,260
INDEX 489
10