2006 DODGE RAM 1500 GAS automatic transmission

Selection Of Lubricant
Refer to Fluids, Lubricants and Genuine Parts for correct
fluid type. It is important that the transmission fluid be
maintained at the prescribed level using the recom-
mended fluid.
CAUTION!
Using a transmission fluid other than the manufac-
turers recommended fluid may cause deterioration
in transmission shift quality and/or torque converter
shudder. Using a transmission fluid other than the
manufacturers recommended fluid will result in
more frequent fluid and filter changes. Refer to
Fluids, Lubricants and Genuine Parts for correct
fluid type.
Automatic Transmission Fluid and Filter Change
It is important that proper lubricant is used in the
transmission. Refer to Fluids, Lubricants and Genuine
Parts for correct fluid type.
The fluid and filter(s) should be changed as specified in
the Maintenance Schedule (Section 8).
NOTE: If the transmission is disassembled for any
reason, the fluid and filter(s) should be changed.
Special Additives
The manufacturer strongly recommends against the ad-
dition of any additives to the transmission. Exception to
this policy is the use of special dyes to aid in detecting
fluid leaks. The use of transmission sealers should be
avoided, since they may adversely affect seals.
456 MAINTAINING YOUR VEHICLE

Chassis
Component Fluids, Lubricants and Genuine Parts.
Automatic Transmission Mopar ATF+4, Automatic Transmission Fluid.
Transfer Case Mopar ATF+4, Automatic Transmission Fluid.
NVG 246 Automatic Transfer Case Only Mopar PN 05179014AA, NVG 246 Automatic Transmission Fluid or
equivalent.
Manaul Transmission Fluid (G238) Mopar ATF+4, Automatic Transmission Fluid.
Manual Transmission Fluid (G-56) Mopar ATF+4, Automatic Transmission Fluid.
Clutch Linkage Multipurpose Grease, NLGI Grade 2 E.P. or equivalent.
1500 Model Front Axle (4X4) GL-5 SAE 75W-90 (MS-9763) or equivalent.
1500 Model Rear Axle Mopar Synthetic Gear Lubricant SAE 75W-140 (MS-8985). Limited-Slip
Rear Axles on 1500 Models Require the addition of 118 ml (4 oz.) Mo-
par  limited slip additive or equivalent.
2500/3500 Model Front and Rear Axle Synthetic, GL-5 SAE, 75W-90 or equivalent. Limited-Slip 10.5/11.5 inch Rear Axles DO NOT REQUIRE a limited slip additive.
Brake Master Cylinder Mopar DOT 3 and SAE J1703 should be used or equivalent. If DOT 3
brake fluid is not available, then DOT 4 is acceptable. Use only recom-
mended brake fluids.
Power Steering Reservoir Mopar ATF+4, Automatic Transmission Fluid.
486 MAINTAINING YOUR VEHICLE

At Each Stop for Fuel
•Check the engine oil level about 5 minutes after a fully
warmed engine is shut off. Checking the oil level while
the vehicle is on level ground will improve the accu-
racy of the oil level reading. Add oil only when the
level is at or below the ADD or MIN mark.
•Check the windshield washer solvent and add if
required. When refilling the washer fluid reservoir,
take some washer fluid and apply it to a cloth or towel
and wipe clean the wiper blades, this will help blade
performance.
Once a Month
•Check tire pressure and look for unusual wear or
damage.
•Inspect the battery and clean and tighten the terminals
as required.
•Check the fluid levels of coolant bottle, brake master
cylinder, and transmission and add as needed.
•Check all lights and all other electrical items for correct
operation.
At Each Oil Change
•Change the engine oil filter.
•Lubricate Drivetrain/Steering/Suspension Grease Fit-
tings (if equipped)
•Inspect the exhaust system.
•Inspect the brake hoses.
•Inspect the CV joints/U— joints (if equipped) and
front suspension components.
•Check the automatic transmission fluid level.
•Check the manual transmission fluid level.
•Check the coolant level, hoses, and clamps.
•Lubricate Front Drive Shaft Fitting (2500/3500, 4X4).
490 MAINTENANCE SCHEDULES
8
M A I
N T
E
N A
N C E
S
C
H E
D
U L
E
S

Miles 48,000 51,000 54,000 57,000 60,000
(Kilometers) (80 000) (85 000) (90 000) (95 000) (100 000)
Inspect brake linings. X X
Inspect engine air cleaner filter, replace if neces-
sary. X
Replace spark plugs. X
Inspect and replace ignition cables if necessary. X
Inspect PCV valve, replace as necessary. ** X
Drain and refill automatic transmission fluid and
change main sump filter*. X
496 SCHEDULE “B”
8
M
A I
N T
E
N A
N C E
S
C
H E
D
U L
E
S

Miles 105,000 108,000 111,000 114,000 117,000 120,000
(Kilometers) (175 000) (180 000) (185 000) (190 000) (195 000) (200 000)
Inspect engine air cleaner filter, replace if
necessary. XX
Replace spark plugs. X
Inspect and replace ignition cables if neces-
sary. X
Inspect PCV valve, replace as necessary. ** X
Inspect auto tension drive belt and replace if
required (3.7L/4.7L/5.7L). XX
Drain and refill automatic transmission fluid
and change main sump and spin-on cooler
return filter (if equipped)*. X
Flush and replace engine coolant at 120
months if not replaced at 102,000 miles (170
000 km). X
SCHEDULE “B” 501
8
M
A I
N T
E
N A
N C E
S
C
H E
D
U L
E
S

Adding Fuel........................... 360
Air Cleaner, Engine
(Engine Air Cleaner Filter) ..............436,459
Air Conditioner Maintenance ............... 440
Air Conditioning Refrigerant .............440,441
Air Conditioning System ................277,440
Air Conditioning System, Zone Control ........ 280
Air Pressure, Tires .................... 344,352
Airbag .......................... 43,50,80,86
Airbag Light ...................... 53,109,220
Airbag On/Off Switch ................... 50,86
Airbag, Side ............................ 89
Alarm (Security Alarm) .................26,222
Alignment and Balance ................... 351
Alterations/Modifications, Vehicle ............. 7
Antenna, Satellite Radio ................... 269
Antifreeze (Engine Coolant) ..............448,483
Anti-Lock Brake System (ABS) .............. 331
Anti-Lock Warning Light ...............224,332 Anti-Theft System
..................... 26,222
Appearance Care ........................ 462
Ashtray ............................... 194
Automatic Transmission Adding Fluid ......................... 455
Fluid and Filter Changes ................. 456
Fluid Level Check ...................... 454
Fluid Type ........................ 456,486
Shift Indicator ........................ 222
Shifting ............................. 299
Special Additives ...................... 456
Axle Fluid .......................... 452,486
Axle Lubrication (Axle Fluid) ............... 452
Ball Joints ............................. 441
Battery ............................... 439
Emergency Starting ..................... 416
Saving Feature (Protection) ............... 163
Bearings .............................. 457
518 INDEX

Child Restraint Tether Anchors........60,63,97,101
Child Seat ....................... 56,62,94,100
Cigar Lighter ........................... 194
Climate Control ......................... 274
Clock ..................... 227,230,238,252,265
Clutch ............................... 451
Clutch Linkage Maintenance ................ 452
Compact Disc (CD) Maintenance ............. 273
Compact Spare Tire ...................... 347
Compass .............................. 180
Compass Calibration ..................... 180
Compass Variance ....................... 182
Computer, Trip/Travel .................... 176
Console, Overhead ....................... 175
Contract, Service ........................ 512
Converter, Catalytic ...................... 365
Cooling System ......................... 446
Coolant Capacity ...................... 483
Coolant Level ......................... 446 Disposal of Used Coolant
................ 449
Drain, Flush, and Refill .................. 447
Inspection ........................... 446
Radiator Cap ...................... 446,449
Selection of Coolant (Antifreeze) ......448,483,485
Temperature Gauge ..................... 221
Cruise Control (Speed Control) .............. 172
Cup Holder ............................ 195
Customer Assistance ..................... 510
Data Recorder, Event .................... 54,91
Daytime Running Lights ................... 164
Dealer Service .......................... 430
Defroster, Rear Window .............. 119,280,283
Defroster, Windshield .................. 275,278
Delay (Intermittent) Wipers ................. 168
Differential, Limited-Slip .................. 327
Dipsticks Automatic Transmission ................. 454
520 INDEX

Oil Selection....................... 433,483
Oil Synthetic ......................... 434
Temperature Gauge ..................... 221
Equipment Identification Plate .............. 395
Ethylene Glycol Antifreeze ................. 448
Event Data Recorder .................... 54,91
Exhaust Gas Caution .............108,211,360,445
Exhaust System ...................... 108,445
Exterior Lighting ........................ 164
Filters Air Cleaner ........................ 436,459
Engine Fuel .......................... 436
Engine Oil ........................ 435,485
Engine Oil Disposal .................... 435
Flashers Turn Signal .......................... 166
Flat Tire Stowage ..................... 404,415 Flexible Fuel Vehicles
Cruising Range ........................ 365
Engine Oil ........................... 364
Fuel Requirements ..................... 363
Maintenance .......................... 365
Replacement Parts ..................... 365
Starting ............................. 364
Flooded Engine Starting ................... 297
Fluid, Brake ........................... 486
Fluid Capacities ......................... 483
Fluid Level Checks Automatic Transmission ................. 454
Power Steering ........................ 441
Fluids, Lubricants and Genuine Parts .......... 485
Fog Lights ....................... 165,225,482
Fold Flat Load Floor ..................... 204
Four Wheel Drive ....................... 308
Four-Way Hazard Flasher .................. 398
Freeing A Stuck Vehicle ................... 419
522 INDEX